1995 Ford Windstar Owner Complaints

TL* THE CONTACT OWNS A 1995 FORD WINDSTAR. WHILE THE VEHICLE WAS PARKED, THE CONTACT OBSERVED FUEL LEAKING UNDER THE REAR DRIVER SIDE TIRE. THE CONTACT NOTICED A VISIBLE CRACK IN THE FUEL TANK. THE LOCAL DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER STATED THAT THE VEHICLE WAS PREVIOUSLY REPAIRED PER NHTSA CAMPAIGN NUMBER: 99V309000 (FUEL SYSTEM). THE CONTACT STATED THAT THE RECALL PART THAT WAS SUPPOSED TO BE ON THE VEHICLE WAS NOT VISIBLE. THE VIN WAS INVALID. THE FAILURE MILEAGE WAS APPROXIMATELY 143,000.

NHTSA ID

11000366

Incident

Jun 18, 2017

Mileage

143,000 mi

SPEED CONTROL DOES NOT ENGAGE. THERE IS SMELL OF GAS WITH TANK FULL AND STATIONARY . THIS VEHICLE NOT DRIVEN OFTEN SO MAYBE A MONTH BETWEEN OCCURRENCES.

NHTSA ID

10949174

Incident

Dec 1, 2016

Mileage

155,000 mi

SMALL DAMAGE TO THE LEFT OUTSIDE OF THE LEFT FENDER, CAUSED BOTH AIR BAGS TO GO OFF. THIS BROKE THE REARVIEW MIRROR ON THE WINDSHIELD AND BOTH REAR WINDOW LATCHES TO BREAK THE VEHICLE WAS IN MOTION.

NHTSA ID

10789305

Incident

May 5, 2014

TL* THE CONTACT OWNS A 1995 FORD WINDSTAR. THE CONTACT STATED THAT WHILE DRIVING AT 35 MPH, THE REAR AXLE SHIFTED AND FRACTURED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 50,000.

NHTSA ID

10787319

Incident

Oct 28, 2015

Mileage

50,000 mi

TL* THE CONTACT OWNS A 1995 FORD WINDSTAR. WHEN THE VEHICLE WAS SHIFTED TO THE DRIVE POSITION, THE VEHICLE ACCELERATED AND THE CHECK ENGINE WARNING INDICATOR ILLUMINATED CONTINUOUSLY. THE CONTACT STATED THAT THERE WERE DIFFICULTIES SHIFTING THE VEHICLE TO DIFFERENT GEARS. THE FAILURES RECURRED NUMEROUS TIMES. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE IDLE AIR CONTROLLER FAILED AND NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED, BUT THE FAILURE RECURRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 245,000.

NHTSA ID

10786616

Incident

Oct 12, 2015

Mileage

245,000 mi

TL* THE CONTACT OWNS A 1995 FORD WINDSTAR. THE CONTACT STATED THAT THE VEHICLE FAILED TO START. THE VEHICLE RESTARTED AFTER SEVERAL ATTEMPTS, BUT THE FAILURE RECURRED AND THE VEHICLE STALLED. THE CONTACT COMPLAINED OF A CLICKING NOISE COMING FROM THE FUSE BOX BEFORE THE VEHICLE STALLED. THE VEHICLE WAS TAKEN TO THE DEALER, BUT WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN. THE VIN WAS NOT AVAILABLE.

NHTSA ID

10778394

Incident

Sep 15, 2015

THE ENGINE FREEZES UP AND SHUT DOWN WHEN DRIVING. HAD TO CHANGE THE FUEL PUMP AND PUT IN A NEW AC COMPRESSOR.

NHTSA ID

10777831

Incident

Aug 29, 2013

TL* THE CONTACT OWNS A 1995 FORD WINDSTAR. THE CONTACT STATED THAT THERE WERE STRONG FUEL FUMES COMING FROM OUTSIDE AND INSIDE THE VEHICLE. UPON FURTHER INSPECTION, IT WAS NOTICED THAT THERE WAS AN INTERMITTENT FUEL LEAK. THE VEHICLE WAS TAKEN TO THE AUTHORIZED DEALER A MONTH AGO AND THE CONTACT WAS STILL WAITING FOR THE RESULTS OF THE DIAGNOSTIC TESTING. THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN NUMBER: 99V309000 (FUEL SYSTEM, GASOLINE). THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS NOT AVAILABLE.

NHTSA ID

10689631

Incident

Feb 1, 2014

TL* THE CONTACT OWNS A 1995 FORD WINDSTAR. THE CONTACT STATED THAT GASOLINE FUEL WAS LEAKING FROM UNDER THE VEHICLE. THE FAILURE WAS NOT DIAGNOSED NOR WAS THE VEHICLE REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND STATED THAT THE VIN WAS NOT INCLUDED IN NHTSA RECALL CAMPAIGN NUMBER: 99V309000 (FUEL SYSTEM, GASOLINE). THE APPROXIMATE FAILURE MILEAGE WAS 110,000.

NHTSA ID

10621936

Incident

Jul 10, 2014

Mileage

110,000 mi

THE ABS LIGHT CAME ON AND REMAINS ON TO THIS DAY. *TR

NHTSA ID

10587943

Incident

Nov 9, 2013

Mileage

248,313 mi

AFTER RELOCATING TO GA, BEGAN EXPERIENCING STRONG ODOR OF GASOLINE. ODOR WAS STRONGEST AFTER TANK FILLED. SHORTLY THEREAFTER BEGAN FINDING WET STAINS ON GROUND ON LEFT SIDE OF VEHICLE. UPON FURTHER INSPECTION FOUND GASOLINE LEAKING FROM GAS TANK ON DRIVERS SIDE FROM A CRACK IN TANK IN VICINITY OF FORWARD GAS TANK STRAP.AFTER EXHAUSTIVE RESEARCH FOUND THERE WAS A RECALL ON THESE VEHICLES FOR THIS PROBLEM.VEHICLE WAS REGISTERED WITH FORD ON ITS WEB SITE AND SHOWS NO RECALLS BY VIN#. ALSO INFORMED BY ATHENS FORD THAT THERE WERE NO REPLACEMENT TANKS AVAILABLE ANYWHERE IN THE COUNTRY. HAVE BEEN TEMPORARILY SEALING LEAKS AND KEEPING VERY LITTLE FUEL IN THE TANK. ALSO FOUND NO AFTERMARKET TANKS AVAILABLE FOR THIS VEHICLE.HAVE NOT BEEN NOTIFIED BY FORD AS OF YET OF ANY PROBLEMS WITH THIS VEHICLE ALTHOUGH THEY HAVE SERVICED IT SINCE ITS PURCHASE IN PA, UNTIL IT ARRIVED IN GA. *TR

NHTSA ID

10509359

Incident

Jul 8, 2010

Mileage

98,000 mi

WHILE DRIVING BACK FROM ROME GA TO CARTERSVILLE GA MY VAN MADE A FUNNY NOISE AND MY SPEED DROPPED FROM 60 TO 50 AND THEN MY BACK TIRES FELT FUNNY LIKE I HAD RUN OVER SOMETHING BUT I KNOW I HAD NOT HIT ANY THING SO AS I GOT CLOSER TO THE EXIT THEN MY ABS LIGHT CAME ON. AFTER I STOPPED AT A STATION I CHECKED MY BRAKE FLUID BUT IT WAS FULL, I CHECKED MY TIRES THEY WHERE GOOD BECAUSE THEY ARE NEW. WHEN I GOT HOME I HAD MY BREAKS & PLUGS CHECKED AND THEY ARE GOOD. I DON'T KNOW WHAT ELSE TO DO. THE ABS LIGHT IS STILL ON, WHILE DRIVING MY VAN STILL LOSE SPEED ON HILLS AND LEVEL GROUND. HELP ME PLEASE THIS IS MY ONLY WAY TO GET WHERE I NEED TO GO. *TR

NHTSA ID

10504408

Incident

Mar 19, 2013

TL* THE CONTACT OWNS A 1995 FORD WINDSTAR. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 25 MPH, THE ENGINE STALLED WITHOUT WARNING AND RESTARTED. IN ADDITION, THERE WAS A WHINING NOISE. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC TWO TIMES AND EACH TIME THE ENGINE BELT AND TENSIONER PULLEY ASSEMBLY WERE REPLACED. THREE DAYS AFTER THE SECOND REPAIR WAS PERFORMED THE FAILURE RECURRED. THE VEHICLE HAD NOT BEEN REPAIRED FOR THE MOST RECENT FAILURE. THE MANUFACTURER WAS NOT NOTIFIED OF THE PROBLEM. THE APPROXIMATE FAILURE MILEAGE WAS 154,000.

NHTSA ID

10487435

Incident

Sep 20, 2012

Mileage

154,000 mi

AFTER FILLING THE VEHICLE FUEL TANK AT THE FULLERTON MD BJ'S WAREHOUSE STORE, GASOLINE BEGAN SPILLING FROM THE UNDERSIDE OF THE VEHICLE ONTO THE PAVEMENT. THE BALTIMORE COUNTY FIRE DEPARTMENT (BCFD) WAS CALLED TO THE SCENE AND RESPONDED WITH THREE PIECES OF EQUIPMENT. BCFD APPLIED ABSORBENT TO THE SPILLED FUEL AND CONTAINED IT UNTIL THEY COULD TRANSFER THE FUEL (APPROX. 25 GALS) FROM MY VEHICLE'S TANK INTO A SAFE STORAGE CONTAINER. AFTER THEY COMPLETED THAT SERVICE, THE VEHICLE WAS TOWED TO THE LOCAL FORD DEALERSHIP, BOB DAVIDSON FORD, FOR DIAGNOSIS AND REPAIR. THE VEHICLE TANK HAD DEVELOPED A STRUCTURAL CRACK IN ITS WALL APPROX. 3 INCHES LONG ("HAIRLINE") IN THE SAME LOCATION ALREADY DESIGNATED THE DOCUMENTATION DESCRIBED BY NHTSA RECALL NUMBER 99V309 / FORD RECALL NO. 99S33, IMMEDIATELY ABOVE THE CENTER LEFT TANK SUPPORT STRAP. I CAN PRODUCE CLEAR PHOTOS OF THE CRACK. I REQUIRE ASSISTANCE FROM THE NHTSA IN RECOVERING THE $1,660.01 I PAID THE FORD DEALER ON 10/9/12 FOR THE REPAIR OF THE TANK (THEY COULD ONLY FIND A USED TANK TO INSTALL) FOR WHAT IS OBVIOUSLY A MANUFACTURER'S DEFECT. AS OF THIS DATE, 8 DAYS LATER, THE USED "NEW" TANK HAS ALSO BEGUN TO LEAK. MANY THANKS.

NHTSA ID

10481781

Incident

Sep 29, 2012

Mileage

270,000 mi

TL* THE CONTACT OWNS A 1995 FORD WINDSTAR. THE CONTACT STATED THAT THE STRAPS THAT HELD THE FUEL TANK FAILED. THE VEHICLE WAS TAKEN TO THE DEALER FOR DIAGNOSIS. THE DEALER STATED THAT THEY NEEDED TO REPLACE THE STRAPS AND THE FUEL TANK. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED AND STATED THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 99V309000 ( FUEL SYSTEM). THE FAILURE AND THE CURRENT MILEAGE WAS 184,000.

NHTSA ID

10467802

Incident

Jul 26, 2012

Mileage

184,000 mi

TL* THE CONTACT OWNS A 1995 FORD WINDSTAR. THE CONTACT STATED THAT BRAKE FLUID WAS LEAKING FROM THE VEHICLE AND THE BRAKE AND ABS WARNING LIGHTS WERE ILLUMINATED. THE VEHICLE WAS TAKEN TO THE DEALER WHERE THE CONTACT WAS AWAITING A DIAGNOSIS OF THE FAILURE. THE MANUFACTURER WAS CONTACTED AND ADVISED THE CONTACT THAT THE VEHICLE WAS NOT INCLUDED IN THE RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER: 02V101000 (SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:HOSES, LINES/PIPING, AND FITTINGS). THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE APPROXIMATELY 37,000.

NHTSA ID

10450050

Incident

Mar 1, 2012

Mileage

37,000 mi

ABS BRAKE WARNING LIGHT (YELLOW) COMES ON WHILE DRIVING AND WON'T GO OFF. *TT

NHTSA ID

10432948

Incident

Oct 24, 2011

Mileage

196,602 mi

TL* THE CONTACT OWNS A 1995 FORD WINDSTAR. THE CONTACT STATED THAT THE FUEL TANK WAS CRACKED AND THE VEHICLE WAS LEAKING FUEL. THE VEHICLE WAS NOT TAKEN TO THE DEALER TO HAVE THE FAILURE DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE, BUT OFFERED NO ASSISTANCE BECAUSE THE VEHICLE WAS NOT INCLUDED IN THE RECALL ASSOCIATED WITH NHTSA CAMPAIGN ID NUMBER 99V309000 (COMPONENT: FUEL SYSTEM, GASOLINE:STORAGE:TANK ASSEMBLY). THE VEHICLE DID NOT RESIDE IN ONE OF THE STATES LISTED UNDER THE RECALL. THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 216,000. UPDATED 10/18/2011 *LN UPDATED 10/26/11 *BF UPDATED 3/29/12 *CN *TR

NHTSA ID

10422495

Incident

Aug 22, 2011

Mileage

216,000 mi

TL* THE CONTACT OWNS A 1995 FORD WINDSTAR. THE CONTACT STATED THAT AN ABNORMAL BANGING WAS HEARD FROM THE VEHICLE WHILE DRIVING AT VARIOUS SPEEDS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT REPAIR SHOP WHERE THE CONTACT WAS TOLD THAT THE FRAME WAS COMPLETELY RUSTED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED BUT OFFERED NO ASSISTANCE. THE FAILURE AND CURRENT MILEAGES WERE 150,000.

NHTSA ID

10400750

Incident

May 12, 2011

Mileage

150,000 mi

OVERDRIVE LIGHT STARTS FLASHING AND DOES NOT GO INTO GEARS AS IT SHOULD. ALSO HAVE RECENTLY HAD TO REPLACE STRUTS--BROKE AS I WAS DRIVING ALONG. HAD TO REPLACE REAR AXLE ALREADY AND HAVE BEEN TOLD MY YEAR OF WINDSTAR WAS NOT INCLUDED IN RECALL. *TR

NHTSA ID

10375441

Incident

Dec 23, 2010

Mileage

175,250 mi

FORD WINDSTAR ABS/BRAKE LIGHT STILL COMES ON AFTER RECALL. *TR

NHTSA ID

10362816

Incident

Aug 1, 2010

Mileage

100,000 mi

TL*THE CONTACT OWNS A 1995 FORD WINDSTAR. THE CONTACT STATED BLACK SMOKE WAS COMING FROM THE TAIL PIPE AND THERE WAS A STRONG ODOR OF GASOLINE INSIDE THE VEHICLE. THE VEHICLE BEGAN BURNING AN EXCESSIVE AMOUNT OF FUEL SINCE THE BLACK SMOKE STARTED COMING FROM THE TAIL PIPE. THE O2 SENSORS, SPARK PLUGS/WIRES, INTAKE GASKETS AND INTAKE ISOLATOR BOLTS WERE ALL REPLACED BY A CERTIFIED TECHNICIAN. THE MANUFACTURER REFUSED TO WORK ON THE VEHICLE. THE FAILURE MILEAGE AND CURRENT MILEAGES WERE 89000.

NHTSA ID

10360351

Incident

Aug 28, 2010

Mileage

89,000 mi

I HAVE A 95 FORD WINDSTAR (89K) LX3.8; DTC P0306.... GAVE RICH CONDITION, BLACK SMOKE OUT TAILPIPE, EXCESSIVE FUEL CONSUMPTION ... DON'T STAY RUNNING. SPENT MORE THAN $4,000 ON THE REPAIRS DIDN'T RESOLVE THE PROBLEM. - HAVE REPLACED ALL O2 SENSORS; - HAVE REPLACED SPARK PLUGS/ WIRES; - HAVE REPLACED STARTER/ BATTERY; - HAVE REPLACED ALL THE UPPER INTAKE GASKETS AND INTAKE ISOLATOR BOLTS; - HAVE REPLACED THE FUEL INJECTOR #6; - HAVE HAD REPLACED ALL WATER PUMP/GASKET, A/C AND TRANSMISSION TWO YEARS AGO STILL DIDN'T SOLVE THE PROBLEM. NEED RUN THE COMPRESSION TEST FOR ANY MECHANIC ISSUES BUT DON'T HAVE THE TOOLS TO DO SO' FORD DON'T WANT HELP ANYTHING/REPAIRS. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

NHTSA ID

10359634

Incident

Sep 4, 2010

Mileage

89,000 mi

DRIVING HOME FROM A 1HR TRIP TURNED IN TO A 3HR TIP HOME.RPMS GOING UP TO HIGH AND SPEED DROPS. LIKE PULLING A BIG LODE. HAD WHAT SOUNDED LIKE A WINNING OR RACING SOUND. NO LIGHTS CAME ON NO SHAKING OR RUFF RIDE. WOULD BE LIKE THIS FOR A BIT THEN RUN FINE FOR A BIT THEN DO IT AGEN.STOPPED CHECKED FLUIDS ALL FINE.GOT HOME AND RAN TO PARTS STORE PUT IT ON THE READ OUT.NOTED THEN OD BLINKING BUT NO CODS FOR TRANS AXEL CAME UP. BUT YET THE BOOK SAYS THAT IS A TRAN AXEL MAL. THEY GUY HIT RESET AND THE OD STOPPED BLINKING. PUT IT IN SHOP AND THEY CAN NOT FIGURE OUT WHAT IS WRONG THEY GOT NO CODS. FOR THE TRANS AXSEL.TOLD ME TO COME GET IT THEY SPENT TO MUCH TIME ON IT AS IT IS. YA 45MINS. OUT OF ONE DAY.ALL THEY DID WAS DRIVE IT AND SEEN IT WAS DOING WHAT I SAID.THATS IS TO MUCH TIME.BUT FEELS IT HAS TO BE INTERNAL TRANS.$45 FOR THAT.NOW WILL HAVE TO TAKE IT TO A FORD DEALER $80 FOR THEM TO SEE WHAT IT IS IF THEY CAN AND THEN FIX WHAT EVER IT IS AND GOD KNOWS HOW MUCH IT WILL BE TO FIX.I AM SURE I CAN NOT AFFORD IT.I AM LEFT WITH A CAR.THIS IS MESSED UP.FORDS ARE A MESS.AND PEOPLE LIKE ME PAY FOR IT.I HAVE HAD ONE PROB.AFTER ANOTHER AND HAVE ONLY HAD IT FOR 2 YEARS MOM HAD IT BEFORE THAT FOR ABOUT 6 YEARS. SHE HAD THE SERVES ENGINE LIGHT COME ON AND STAY ON FOR A LONG TIME BUT SHOP FOUND NOTHING WRONG. IT WENT OFF ONE DAY DON'T EVEN KNOW WHEN. IT IS NOW ON AGAIN.

NHTSA ID

10344827

Incident

Jul 12, 2010

TL* THE CONTACT OWNS A 1995 FORD WINDSTAR. WHILE PARKED AT A GAS STATION, THE VEHICLE CAUGHT FIRE FROM UNDER THE HOOD WITHOUT WARNING. THE MANUFACTURER ADVISED THE VEHICLE WAS UNDER AN UNKNOWN RECALL AND AN INVESTIGATOR WOULD FURTHER INSPECT THE VEHICLE FOR THE CAUSE OF THE FIRE. THE VEHICLE WAS REPAIRED UNDER THE UNKNOWN RECALL HOWEVER, THE CONTACT STATED THE BRAKE WARNING LIGHT ILLUMINATED FOLLOWING REPAIRS. THE CONTACT HAD NOT HAD ANY PROBLEMS WITH THE BRAKING SYSTEM BEFORE REPAIRS. THE CONTACT SPOKE WITH THE MANUFACTURER WHO PROVIDED NO ASSISTANCE AND HE WAS UNABLE TO LOCATE A DEALER WHO WOULD MAKE FURTHER REPAIRS TO THE VEHICLE. THE FAILURE MILEAGE WAS 170,000 AND THE CURRENT WAS 177,000.

NHTSA ID

10330151

Incident

May 8, 2010

Mileage

170,000 mi