1996 Ford Windstar Steering Problems

I BROUGHT MY 1996 FORD WINDSTAR IN FOR AN OIL CHANGE, AND WAS TOLD TIE RODS FAILED AND NEEDED TO BE REPLACED. , THEN, NEXT DAY, THEY PHONED AND ADVISED ME THAT TRANSMISSION WAS DEFECTIVE BECAUSE THE PAN WAS FULL OF SHAVINGS, ALSO, POWER STEERING RACK WAS LEAKING, AND INTAKE GASKET NEEDED REPLACEMENT. , A TOTAL OF $5000 TO FIX THIS VEHICLE. I BOUGHT IT AT 118,000 MILES, AND THIS HAPPENED SHORTLY AFTER OWNING IT FOR ONE YEAR. CURRENTLY, IT HAS 134,000 MILES, AND CANNOT BE DRIVEN. I PARKED VEHICLE THEN STARTED IT AFTER BEING PARKED FOR A WEEK. HEARD A NOISE FROM FRONT, AND THEN WHITE SMOKE CAME OUT OF THE TAIL PIPE. I DO BELIEVE THAT PAUL CORNIES, THE DEALER THAT I PURCHASED VEHICLE KNEW THAT THEY WERE SELLING ME A LEMON. IT HAS CAUSED ME A LOT OF HARDSHIP AS I NO LONGER WORK DUE TO HEALTH REASONS. I FILED FOR DISABILITY INSURANCE, AND WAS TOLD THAT I HAD A PREEXISTING DISEASE , AND REFUSED TO PAY THE INSURANCE. CURRENTLY, I HAVE A JUNKER IN MY DRIVEWAY THAT I CAN'T AFFORD TO FIX , AND A BILL FOR THE NEXT 3 YEARS, SINCE I STILL OWE FOR IT. I WILL NEVER BUY ANOTHER FORD. *AK

NHTSA ID

10118128

Incident

Apr 5, 2004

Mileage

134,000 mi

THE VEHICLE'S DOOR LOCKS LOCKED AND UNLOCKED ON THEIR OWN. *NM THERE WERE PROBLEMS WITH THE FRONT DRIVER SIDE WHEEL AND THE ENGINE LIGHT AND THE ABS LIGHT WAS INTERMITTENT. THE CONSUMER EXPERIENCED AN ACCIDENT WHICH MAY BE DUE TO THE BRAKE LINES. REFER TO RECALL#02V101000. *SC THE SWAY BAR RATTLED, THE TIE RODS WERE REPLACED. *JB

NHTSA ID

10109574

Incident

Aug 8, 2004

VEHICLE HAS BEEN LOOSING COOLANT FOR MANY YEARS. *LA THE VEHICLE WAS TAKEN IN FOR A ROUTINE OIL CHANGE BUT ENDED UP HAVING MAJOR REPAIRS. APPROXIMATELY EIGHT MONTHS AFTER THE REPAIR, THE ENGINE QUIT AND THE CONSUMER WAS INFORMED BY TWO DEALERS THAT THE VEHICLE NEEDED A SHORT BLOCK INSTALLED. THERE WAS ALSO NOISE IN THE STEERING AND A COOLANT LEAK. THE INTAKE UPPER AND LOWER MANIFOLD GASKETS WERE ALSO REPLACED. *SC *JB

NHTSA ID

10074111

Incident

Jun 19, 2002

Mileage

66,000 mi

12-15-97 AT 21,145 MILES I REPORTED NOTICING THE COOLANT LEVEL ALWAYS BEING LOW. NO LEAK WAS FOUND AND I WAS TOLD THERE MUST BE A LEAK SOMEWHERE IN THE RADIATOR. 12-27-99 AT 56,526 MILES I BEGAN HAVING A "COLD START" PROBLEM. IT ACTED LIKE IT WAS NOT GETTING FUEL. 12-1200 AT 74,306 MILES I HAD THE SAME "COLD START" PROBLEM AND THE FUEL FILTER WAS REPACED. 12-22-00 AT 74,930 A NEW THERMOSTAT & GASKET. 12-29-00 AT 75,113 A FUEL PRESSURE REGULATOR. 03-02-01 AT 77,569 MILES A NEW FUEL PUMP RELAY(CCRM), FUEL PUMP AND PVC VALVE. 09-11-01 AT 87,907 MILES A MULT-FUNCTION SWITCH. 01-31-02 AT 95,069 MILES A SECOND CCRM RELAY. 03-06-02 AT 99,348 MILES ON AN 80 DEGREE DAY "NO START" SAME SYMPTOMS AS "COLD START" PROBLEM. INSTEAD OF NOT GETTING FUEL IT IS SUSPECTED IT IS FLOODING. 4-23-02 AT 99,348 MILES COLD START PROBLEM, FUEL INJECTORS CLEANED. 05-30-02 AT 101,330 MILES WOULDN'T START, NO FUEL PRESSURE-INTERMITTENT. HAD TO HAVE IT TOWED. 6-7-02 AT 101,388 MILES "NO START" PROBLEM. NEW FUEL FILTER, FUEL PUMP AND SENDER O-RING. 12-01-2-01 109,530 MILES VAN STARTED STEAMING - APPEARED TO BE A COOLANT LEAK OR BROKEN HOSE. ADDED COOLANT DIRECT IN RADIATOR. I HAVE CARRIED OWN COOLANT AND ADDED FREQUENLTY SINCE 1997, WHEN I WAS TOLD THERE MUST BE A LEAK IN THE RADIATOR. I COULD NOT FIND ANY TRACE OF SUCH A LEAK BY PUTTING CARDBOARD UNDER VAN. SUSPECTED THE PLASTIC COOLANT CONTAINER HAD A LEAK. NO COOLANT LEAKS WHERE EVER FOUND DURING ROUTINE OIL CHANGES. 12-04-02 109,568 M,ILES FOUND LEAKING FRONT TIMING COVER GASKET. REPLACED HEADGASKET AND ALL ELSE THAT GOES WITH IT. COST OF REPAIR $1,915.21. I BELIEVE THE HEADGASKET DEFECT HAS BEEN THE PROBLEM ALL A LONG, COSTING ME A SMALL FORTUNE.

NHTSA ID

10069811

Incident

Dec 15, 2002

REPLACED RACK AND PINION FOR THE SECOND TIME 8/01 ( BY DEALERSHIP) AND 5/03. ALSO REPLACED FRONT END BEARING IN 1999 AND TRANSMISSION. WIRING HARNESS IN 2000. REAR A/C DOES NOT WORK AND THAT'S ONLY THE ITEMS I CAN REMEBER.*AK

NHTSA ID

10030855

Incident

Aug 5, 2003

Mileage

85,550 mi

WHEN THE KEY WAS TAKEN OUT OF THE IGNITION, THE ENGINE DID NOT SHUT OFF. THE VEHICLE WAS TAKEN TO THE DEALERSHIP WHO STATED A PIN CAME OUT OF THE STEERING SYSTEM. *JB

NHTSA ID

10017603

Incident

Apr 24, 2003

CONSUMER STATED REPAIR WORK WAS PERFORMED ON THE STEERING BOX MECHANISM.*JB

NHTSA ID

567741

NEED TO REPLACE SPEEDOMETER HEAD, REPLACED TIE ROD, FRONT AND REAR BRAKES, CYLINDERS, HEAD GASKET AND NOW ENGINE BLEW NEED NEW ENGINE. *AK

NHTSA ID

766129

Incident

Aug 19, 2002

THE LEFT OUTER TIE ROD WAS REPLACE. *YH THE FUEL INJECTOR, TIMING COVER GASKETS AND WIPER BLADES WERE REPLACED. THE REAR BRAKE LIGHT WAS REPLACED . THE SWITCH HEADLIGHT CONTROL WAS REPLACED. THE DRIVERS DOOR AJAR SWITCH WAS REPLACED. UPDATED *JB

NHTSA ID

565966

Incident

Jun 1, 2002

NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK

NHTSA ID

762270

Incident

Apr 25, 2002

VEHICLE WAS PULLING TO THE RIGHT AT ALL TIME, VEHICLE WAS TAKEN TO DEALER FOR ALIGNMENT. DEALER STATED ALIGNMENT COULD NOT BE DONE, DUE TO THE TIE ROD COUPLING BEING CRACKED. NLM

NHTSA ID

8008115

Incident

Mar 28, 2002

NO SUMMARY LISTED FOR ABOVE VEHICLE. *AK

NHTSA ID

755146

Incident

Sep 10, 2001

WHILE DRIVING DOWN THE INTERSTATE THE VEHICLES NEEDLE STARTED TO HUM. THEN NEXT, THE SPEEDOMETER NEEDLE STARTED TO FLY BACK AND FORTH BETWEEN 40-110MPH. I DID SOME FURTHER RESEARCH ABOUT THIS PROBLEM ON THE INTERNET AND FOUND THAT ABOUT 20 OTHER INDIVIDUALS WITH THIS SAME PROBLEM WERE HAVING TO REPLACE THIS COMPONENT WITH LESS THAN 40,000 MILES USAGE BETWEEN REPLACEMENTS. UP TO TWO OR THREE WERE BEING REPLACED WITHIN THE VEHICLES. NOW IF THERE WERE 20 REPORTS ON ONE WEBSITE ABOUT THIS CONCERN THEN THERE ARE PROBABLY HUNDREDS MORE NOT BEING REPORTED. AN INVESTIGATION IS WARRANTED. THIS IS A MAJOR SAFETY CONCERN FOR ALL DRIVERS ON THE ROADS WITH THIS PROBLEM. *AK

NHTSA ID

754818

Incident

Nov 23, 2001

BOUGHT CAR 3/01-IMMEDIATELY REPLACED CAT. CONVERTER. OVERDRIVE LT FLASHING-NEEDED NEW TRANSMISSION, TORQUE CONVERTER, PLANETARY GEARS, SOLENOIDS; HAD TO REALIGN;SPEEDOMETER OFF BY AT LEAST 10 MPH; NEED NEW RACK & PINION-POWER STEERING FLUID LEAKING; NOTHING BUT PROBLEMS HAVE SPENT SO MUCH MONEY AND ALSO BEEN WITHOUT CAR FOR OVER A MONTH -ONLY HAD IT 7 MONTHS!

NHTSA ID

754235

Incident

Oct 1, 2001

WHILE DRIVING THERE CAME A LOUD SQUEAKING NOISE FROM STEERING AREA. CONTACTED DEALER, AND DEALER NOTED THAT THERE COULD BE PROBLEMS WITH TIE RODS. *AK PROBLEM BEGAN ABOUT 50000 MILES. *YH

NHTSA ID

886478

Incident

Jan 1, 2001

TWO FROZEN OUTER TIE RODS. CONUSMER WOULD NOTICE SINCE HE HEARD SOME NOISES. ALSO, STREEING WHEEL WOULD NOT COMPLETEY TURN BACK TO ITS PLACE. CONTACTED DEALER, DEALER FIXED PROBLEM.*AK *SLC

NHTSA ID

882572

Incident

Feb 10, 2001

FRONT RIGHT WHEEL SEPARATED BECAUSE TIE ROD SEPARATED FROM WHEEL. DEALER REPAIRED TIE ROD. 30000 MILES LATER, DEALER REPLACED THE TIE RODS. EARLIER HAS RECENTLY INSPECTED VEHICLE AND DISCOVERED THAT THE TIE RODS NEEDED TO BE REPLACED AGAIN. *AK

NHTSA ID

873295

IN THE PAST TWO WEEKS THE TRANSMISSION HAS SLIPPED TWICE. WHEN AT A COMPLETE STOP AND ACCELERATING THE VEHICLE HAS TO BE PUT INTO PARK AND THEN BACK INTO DRIVE. THIS IS VERY DANGEROUS. THERE IS ONLY 56000 ON VEHICLE. BATTERY LIGHT CONTINUALLY COMES ON THIS CAN BE VERY NERVE WRACKING WHEN IN HEAVY TRAFFIC. . SPEEDOMETER FLUCTUATES AND FLOPS AROUND AFTER 40MPH, SOMETIME STICKS AT 50MPH. REAR WIPERS WORK WHEN THEY WANT. WE HAVE JUST RETURNED FROM SERVING 8 YEARS OVERSEAS, THIS IS OUR ONLY VEHICLE AND FROM THE RESEARCH WE HAVE JUST BEEN ABLE TO START THIS WINDSTAR IS HEADACHES WITH THE SAME PROBLEMS. I WOULD LIKE TO BE ABLE TO TAKE MY FAMILY TO SEE RELATIVES THEY HAVE NOT SEEN IN OVER 8 YEARS BUT THIS VEHICLE IS UNSAFE.

NHTSA ID

734258

Incident

Sep 30, 2000

THE VEHICLE EXPERIENCED PREMATURE TIE ROD FAILURE. *MJS

NHTSA ID

553998

VEHICLE BOUGHT IN 3/99 THROTTLE BODY LINKAGE BROKE REPAIRE BILL $500.00 SHORTLY THEREAFTER SENSOR WENT OUT (FUEL)BILL 256.00 LATER NOTICED SQUEKING IN FRONT END ADVISED IT WAS TIE ROD ENDS NOT FIXED YET THIS THING HAS BROKE ME HAVE HAD MANY OCCURENCES WITH SPEED ODOMETER GOING CRAZY AFTER 45MPH RECENTLY NOTICED POPPING WHEN TURNING STEERING OR APPLING THE BRAKES BUT BEFORE I COULD GET IT FIXED TRANSMISSION BEGIN TO EITHER NOT SHIFT UPWARD ,SLIP AT 45MPH AND HAS DOWNSHIFTED AFTER REACHING SPEEDS OF 45MPH (ON I-85) HAS JERKED SEVERAL TIMES ..WAS TOLD ANYWHERE FROM 100.00-2000.00 ? SEEMS I HAVE NOT BEEN ALONE IN MY DISQUEST WITH FORD...ONLY PROBLEM NOT ENCOUNTERED HEAD GASKET THANK GOD PLEASE HELP US WORKING FOLKS AGAINST THIS BIG BOY ON THE BLOCK THANKS

NHTSA ID

727625

Incident

Mar 1, 2000

I HAD MY FRONT BRAKES REPLACED JANUARY 7 , 2000 . I RECENTLY HEARD A LOUD " TUMPING " NOISE IN THE RIGHT FRONT WHEEL / AXLE ASSEMBLY. I TOOK THE VAN BACK TO THE DEALER FOR REPAIRS. THEY REPLACE THE " SWAY BAR / TIE RODS ON THE RIGHT SIDE AND DID A SUSPENSION ADJUSTMENT AND ASSURED ME THE PROBLEM WAS FIXED. I TOOK THE VAN OUT OF THE PARKING LOT ONLY TO RETURN IMMEDIATLY. I THEN TOOK THE " EXPERT " FRONT END MECHANIC FOR A TEST DRIVE . HE HEARD THE NOISE FOR THE " FIRST " TIME AND TOLD ME I NOW NEEDED STRUTS. THIS HE SAID WOULD SOLVE MY PROBLEM . I AM SCHEDULED TO HAVE THIS REPAIR DONE ON JULY 23 , 2000. I DO NOT BELIEVE THIS TO BE MY PROBLEM . ALSO I AM CONCERNED THAT MY DEALER AS WELL AS FORD WILL NOT COVER ANY OF THESE REPAIRS BECAUSE THE 36 MONTHS ON MY WARRANTY HAS EXPIRED BUT NOT MY 36,000 MILES ( I AM AT 33,900 MILES ) . IF YOU COULD SEND ANY INFORMATION ON RECALLS , CLASS ACTION SUITS OR HELPFUL TIPS ON WHAT TO DO I WOULD BE FOREVER GRATEFULL . THANKS RON TURNER

NHTSA ID

725823

Incident

Jan 5, 2000

THE SPEEDOMETER STARTS MOVING ERRATICALLY ONCE SPEEDS OF 25 MPH ARE REACHED. ALSO, SOMETIMES, THE WINDSHIELD WIPERS WILL ONLY WORK ON HIGH SPEED. I HAVE CONTACTED THE DEALER, AND AM TOLD IT WILL BE $500.00 FOR THE SPEEDOMETER. I FEEL THIS, AS WELL AS THE PROBLEMS WITH THE WIPERS IS A SERIOUS SAFETY ISSUE. I'VE READ SEVERAL COMPLAINTS ON THIS SITE ABOUT PROBLEMS WITH SPEEDOMETERS ON 1996 WINDSTARS, AND I THINK FORD SHOULD BE RESPONSIBLE FOR REPAIRS, NOT ME. *AK

NHTSA ID

723235

Incident

Feb 7, 2000

POWER STEERING FAILED. NLM

NHTSA ID

552331

Incident

Jun 16, 1999

SPEEDOMETER JUMPS ERRATICALLY AFTER 40 MPH; ENGINE CHECK LIGHT COMES ON OFTEN, WITH VARIOUS DIAGNOSES THAT SEEM TO ONLY FIX THE PROBLEM FOR AWHILE; WE HAVE PAID ALMOST $1000 IN REPAIRS SO FAR, NONE OF IT UNDER WARRANTY, PER THE DEALER. *AK

NHTSA ID

722792

Incident

Aug 10, 1999

SPEEDOMETER FAILED AT 35000 MILES, THE NEEDLE JUMPS ALL OVER HAVE NO ACCURATE SPEED READING. THE SPEEDOMETER WAS REPLACED UNDER WARRINTY BY MANUFACTURER. THE SPEEDOMETER BROKE AGAIN AT APP. 75000 MILES, THE SAME PROBLEM, THIS TIME THE MANUFACTURER WILL NOT FIX IT EVEN THOUGH IT IS A REOCCURRING PROBLEM.*AK

NHTSA ID

721348