Owner-reported complaints naming the tire or wheel system, filed with NHTSA
Data refreshed
Reports naming tires, wheels, hubs, or the tire-pressure monitoring system. Every record below is an owner-reported complaint about the 2001 Ford Windstar submitted to NHTSA — not a confirmed defect, not a recall and not a manufacturer bulletin. 19 reports on file name it.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Shown in the owner’s own words, exactly as filed
WE HAD OUR LEFT REAR TIRE BLOW OUT AND IT TORE OFF OUR FUEL FILLER PIPE. I IMAGINE THIS COULD BE EXTREMELY DANGEROUS IF THE RIM HAD SPARKED IT COULD HAVE CAUGHT FIRE. *TR
I DIDN'T HAVE A CRASH I NOTICED THAT MY ABS BRAKE AND TIRE PRESSURE LIGHT WAS STAYING ON AND A SHORT TIME AFTER I STARTED HEARING A LOUD RUMBLING NOISE IN THE FRONT END EVERY TIME I SLOW AN IT'S IMPOSSIBLE TO MAKE SUDDEN STOPS AND AT TIMES MY SPEEDOMETER STARTS FLICKERING BACK AND FORTH AS WELL AS MY CRUISE CONTROL IS CURRENTLY INOPERABLE. I HAVE LIMITED DRIVING THIS VEHICLE IN WHICH I PURCHASED DUE TO FEELING IT IS NOT IN A SAFE MANNER FOR MY CHILDREN TO BE IN. I HAVE HAD SEVERAL SHOPS AS WELL AS INDIVIDUALS THAT TOLD ME THESE AREAS ARE COMMON TO GO OUT ON THIS SPECIFIC VEHICLE AND THAT THERE IS POSSIBLE RECALL. I JUST WANT TO BE ABLE TO DRIVE MY VAN WITH OUT WORRYING IF I'M GOING TO BE ABLE TO COME TO A STOP WHEN NEEDED AS WELL AS NOT KNOWING IF I COULD POSSIBLE BREAK DOWN OR SOMETHING BREAK IN THE FRONT END WHILE I AM DRIVING AT SOMEWHAT HIGH SPEEDS. THANK YOU AND HOPE TO HEAR FROM SOMEONE SOON IN REGARDS TO THIS SITUATION! *TR
DRIVING THE VEHICLE BECAME UNCOMFORTABLE AT BOTH LOW AND HIGH SPEED; THEREFORE, I STARTED INVESTIGATING TO TRY TO IDENTIFY THE CAUSE. 1ST I FOUND ONE OF THE REAR SHOCKS WAS VERY BOUNCY, THE REAR TIRES WERE NOT STRAIGHT AND BOTH REAR TIRES WERE WEARING ON THE INSIDE. REPLACED BOTH REAR SHOCKS. THAT DIDN'T SOLVE THE PROBLEM AND THE REAR TIRES WERE STILL NOT STRAIGHT. NEXT I WENT TO MIKE NAUGHTON FORD DEALERSHIP AND TALKED WITH A SERVICE REPRESENTATIVE ABOUT THE PROBLEM AND ASKED IF THERE WAS A RECALL. THE TECHNICIAN SAID THAT I NEEDED TO BRING THE VEHICLE IN FOR AN ALIGNMENT AND HAVE THE REAR CAMBERS SHIMMIED SO THAT THE WHEELS WOULD BE STRAIGHT AT A ESTIMATE COST OF $200.00, THAT THERE WERE NO RECALLS TO HAVE THIS WORK DONE. LAST NIGHT (10-13-2013), I JACKED THE VEHICLE UP TO LOOK UNDER TO SEE HOW DIFFICULT IT WOULD BE TO PERFORM THE WORK MYSELF. I DECIDED THAT I WOULD TAKE THE VEHICLE TO FORD AND PAY THEM TO DO THE WORK. I WAS JACKING THE VEHICLE UP TO REMOVE THE JACK STANCE AND BOTH TIRES FELL ALMOST TO THE FLOOR. I LOOK UNDER THE VEHICLE TO IDENTIFY WHAT HAPPENED AND FOUND THE AXLE HOUSING BENT/BROKEN IN HALF. IT APPEARS THAT IT HAS BEEN CRACKED/BROKEN FOR SOME TIME BECAUSE THE INITIAL BREAK WAS RUSTY. HAVE NOT BEEN ABLE TO FOLLOW-UP WITH THE FORD DEALER YET - I BELIEVE THAT THE SERVICE DEPARTMENT MIGHT BE CLOSED TODAY (COLUMBUS DAY) BECAUSE I HAVEN'T BEEN ABLE TO REACH ANYONE BY PHONE. *TR
OCCURRENCE: 12 OCTOBER 2010. TRAVELING I-95 WASHINGTON,DC/SUITLAND, MD. VEHICLE: FORD WINDSTAR, 2001. SPEED : 60-65 MPH. TRAFFIC : DENSE. FAILURE OF DEFECTIVE PART : REAR AXLE SNAPPED IN TWO PARTS WHILE TRAVELING ON SMOOTH HIGHWAY, NORTHBOUND. EXPLOSIVE SOUND , LOTS OF SMOKE, EXTREME CONSTERNATION/FEAR OF HEART ATTACK EXPERIENCED BY MY WIFE AND I ( MY WIFE HAS A DANGEROUS HEART CONDITION "IHSS") AT OCCURRENCE. I IMMEDIATELY TURNED ON HAZARD FLASHERS. MANAGED TO MANEUVER ACROSS SEVERAL LANES OF TRAFFIC TO GET TO HIGHWAY SHOULDER SAFELY!! THANK GOD FOR THE ALERT FELLOW TRAVELERS BEHIND US!!! IF WE WERE HIT BY ANY 18-WHEELERS ON THE HIGHWAY, I WOULDN'T BE WRITING THIS COMPLAINT NOW!!! CONCERN FOR OUR SAFETY WAS SHOWN TO US BY FELLOW TRAVELERS; PARTICULARLY, MD TRAFFIC SAFETY PERSON, WHO SHOULD BE COMMENDED BY HIS SUPERIORS FOR HIS PROFESSIONAL AND UNDERSTANDING ACTIONS!! HE LOOKED AT THE DAMAGE AND SAID THAT HE HAD NEVER SEEN ANYTHING LIKE IT BEFORE; AND HE SAID THAT WE WERE LUCKY TO BE ALIVE!!! VAN WAS TRANSPORTED BY PROFESSIONALS TO THE NEAREST FORD DEALERSHIP WHERE I FIRST BECAME AWARE THAT A RECALL NOTICE WAS IN FORCE FOR MY VEHICLE!!! AT THIS POINT, I BECAME GREATLY DISTURBED THAT I HAD NO PREVIOUS NOTIFICATION OF THIS DANGEROUS CONDITION AND THAT MY WIFE, GRAND CHILDREN, ETAL WERE TRAVELING IN POTENTIAL ROLLING COFFIN! IN MY OPINION, THIS SEEMS TO BE CRIMINAL; PARTICULARLY IF GREATER PROFIT MOTIVES MIGHT BE INVOLVED! I CERTAINLY HOPE THAT INFERIOR MATERIALS WERE NOT USED IN THIS REGARD!! I WAS INFORMED THAT MY VAN WOULD HAVE TO REMAIN AT THE FORD DEALERSHIP UNTIL FORD MOTOR COMPANY DECIDES HOW I WILL BE PROVIDED WITH A SAFE VEHICLE , SINCE NO REPLACEMENT AXLES WERE AVAILABLE. (NB ; I HAVE NO IDEA WHATEVER OTHER DAMAGE EXISTS AS A RESULT OF THIS AWFUL FAILURE! I CERTAINLY DON'T WANT A DUPLICATE AXLE REPLACEMENT TO REPLAY THIS HORRIFIC CATASTROPHE! IN MY WIFE'S DELICATE CONDITION, I CANNOT EXPECT HER TO TRAVEL IN THIS UNSAFE VEHICLE! JUSTICE!!! *TR
2001 FORD WINDSTAR SE SPORT, 20,000 MILES ABS, BRAKE, & TIRE PRESSURE LIGHTS COME ON AFTER FIRST STARTING CAR AND RUNNING FOR A WHILE.. ABS AND BRAKE LIGHTS GO ON AND OFF, TIRE PRESSURE LIGHT STAYS ON EVEN WITH ALL 4 NEW TIRES EQUALLY FILLED AT 35PSI. JUST BOUGHT THIS VAN. TRANSMISSION SLIPS, HAD IT DRAINED AND SERVICED 1 MONTH AGO WITH NO PROBLEM REPORTED. *TR
RE: 2001 FORD WINDSTAR MINIVAN HAVING CONTINUOUS PROBLEMS WITH THE ABS/ BRAKE LIGHT /TIRE GAUGE BEING DISPLAYED ON THE DASHBOARD. ALSO HAVING PROBLEMS WITH THE SPEEDOMETER NOT WORKING . HAVE HAD THE VAN IN SEVERAL TIMES TO BE REPAIRED & PROBLEM KEEPS OCCURRING. *TR
2001 FORD WINDSTAR ABS WARNING LIGHT COMES ON INTERMITTENTLY WITH FEWER INCIDENCE OF LOW TIRE PRESSURE WARNING LIGHT ALTHOUGH ALL TIRES PRESSURE READS 32PSI WHEN COLD JUST HAD SCDS SWITCH REPLACED UNDER RECALL AND WAS TOLD HAD NOTHING TO DO WITH THE ABS WARNING LIGHT. *TR
EHA TIRE VALVE TR-414 CRACKED AND LEAKED AIR FROM TIRE. OCCURRED AT SLOW SPEED SO NO CATASTROPHIC OUTCOME. TIRE WAS DAMAGED WHILE DRIVING AND REMOVING VEHICLE FROM ROADWAY. NEW SET OF TIRES PURCHASED JULY 2008. VALVE STEM FAILURE JULY 2009. PURCHASE WAS FROM JUST TIRES BRAND WAS GOODYEAR ASSURANCE COMFORTREAD. *TR
RUBBER TIRE VALVE STEM CRACKED. TIRE DEFLATES. HAS OCCURRED SO FAR ON 3 OF 4 TIRES PURCHASED IN OCTOBER 2006. FAILURES OCCURRED IN MARCH 2008, JULY 2008 (TWICE). IN ALL THREE CASES, VALVE REPLACED BY TIRE DEALER. *TR
THE TIRE PRESSURE INDICATOR WILL ILLUMINATE FOR NO REASON. *TR
TL* - WHILE DRIVING AT ABOUT 65 MPH ON 12/26/06 THE CONTACT HEARD A LOUD NOISE. HE PROCEEDED TO PULL THE VEHICLE OVER TO SIDE OF THE ROAD AND NOTICED IT HAD A FLAT TIRE. THE CONTACT STATED THAT THE ROAD CONDITIONS WERE GOOD AND THE EVENING WAS CLEAR. THE CONTACT SAID THAT HE THEN RETURNED HOME AND INSPECTED THE TIRE AND FOUND NO PUNCTURES IN IT, BUT DID NOTICE A BUMP IN THE TIRE. THE CONTACT STATED HE TOOK TIRE TO FIRESTONE TIRE CENTER THE NEXT MORNING , AND THE TECHNICIAN SAID THAT THE TIRE WAS PUNCTURED BY A NAIL, BUT THERE WAS NO NAIL IN THE TIRE. THE TECHNICIAN DID SHOW HIM AN IMPRINT OF THE NAIL ON THE INSIDE OF THE TIRE. THE CONTACT CALLED TO FIND OUT IF THIS TIRE HAD ANY SAFETY ISSUES. THE INFORMATION ON THE TIRE WAS: 214/65R16, MODEL # FR380 AND DOT# W26V38B2306. THE CONTACT HAS THE DAMAGED TIRE, AND FIRESTONE DID REPLACE IT WITH A NEW TIRE. THE TECHNICIAN TOLD THE CONTACT THAT THEY HAD TO SCRAP THE INSIDE OF TIRE AND CLEAN IT UP BEFORE THEY GAVE THE DAMAGED TIRE BACK. *AK UPDATED 02/06/07. *JB
TIRE FAILURE
I HAVE MADE CONTACTS BEFORE WITH FORD. MANY ITEMS UPON MY VEHICLE HAVE WENT BAD SINCE PURCHASE. MY MAIN CONCERN WAS TIRE BLOW OUTS. I CONTACTED FORD AFTER 2 TIRES BLOW OUTS WITHIN 3 MONTHS TIME. SINCE MY CONTACT I HAVE HAD TO REPLACE AN AIR CONDITIONER, AND OTHER ITEMS. BUT MY MAIN CONCERN WAS A TIRE BLOW OUT AGAIN THAT LEFT MY VEHICLE WITH FRONT DAMAGE AND MY LOWER BACK IN PAIN.*AK
WHILE THE VEHICLE WAS RUNNING, THE TIRE RESET WARNING LIGHT ILLUMINATED UNTIL THE VEHICLE WAS SHUT OFF. *JB
OVER THIRTY SEPARATE WARRANTY REPAIRS OVER TWO YEARS. FAULTY ELECTRICAL DOOR LOCKS (KIDS COULDN'T EXIT), TRANSMISSION LEAKAGE, TRANSMISSION FAILURE, FRONT-END DEFECTS WITH LOUD THUMPING NOISES AND SEVERAL BODY PROBLEMS. MOST NOTABLE BODY PROBLEMS ARE WIND NOISE AND WATER LEAKAGE THROUGH DOORS AND WINDOWS. MOST RECENTLY, THE FUEL PUMP FAILED (@ 37,000 MILES). FORD HAS ALL ALONG REFUSED TO ACKNOWLEDGE THE PROBLEMS. NOW THAT THE VEHICLE IS OUT OF WARRANTY, THEY HAVE AGAIN SAID THEY WILL NOT DOING ANYTHING. THE VEHICLE IS UNRELIABLE AND UNSAFE TO OPERATE.*AK
POWER STEERING SYSTEM FAILURE. TRACTION CONTROL FAILURE. ANTI-LOCK BRAKE (ABS) SYSTEM FAILURE. TIRE PRESSURE MONITOR SYSTEM FAILURE. *TT
TIRES WERE REPLACED WITH WRONG SIZE BY 2 SEPARATE DEALERS CAUSING TIRE SENSOR LIGHT TO BE ON . AFTER OVER 25 SERVICE VISITS PROBLEM DISCOVERED .DEALER SENT HOME WITH KNOWN SAFETY PROBLEM "WOULD NOT CORRECT PROPERLY" 4 DAYS LATER ACCIDENT RESULTED. *NLM
WHILE IN MOTION, VEHICLE SUFFERED A BLOWOUT. THE CONSUMER IS SEEKING REIMBURSEMENT FOR CHARGES INCURRED FOR THE BLOWN TIRE. *JG THE CONSUMER FOUND THAT THE SEAT BELT BUCKLE INOPERATIVE. (RECALL#01V227001) THE TIRE HAD LESS THAN ONE THOUSAND MILES WHEN THE INCIDENT OCCURRED. *SCC RQ04011.*PCO
CONSUMER STATES CHECK ENGINE LIGHT IS ON. DEALER REPLACE FUEL CAP AND EVAPORATIVE PURGE VALVE, HOWEVER PROBLEM STILL EXIST AND NOW THE VEHICLE IS STALLING CAUSING VEHICLE TO HAVE NO BRAKING AND POWER STEERING POWER. SQUEAKING NOISE WHEN SETTING STILL. BELT TENSIONER REPLACED. *TT
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Categories with enough reports to have a page of their own
Data on this page last refreshed .