2024 Forest River No Boundaries Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2024 Forest River No Boundaries, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Other / unspecified1100.0%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Other / unspecified
Reports whose component NHTSA recorded as unknown, or that do not map to one of the categories above.
From owner reports, verbatim
*The black water tank of our 2024 Forest River NoBo 20.4 was found to be leaking. Upon inspection, it was discovered that the factory installed tank heating pad applied to our black water tank suffered a severe electrical and structural malfunction. The carbon fiber heating element inside the pad was found to be bent, concentrating heat to an extreme degree. The element experienced a high-resistance thermal event, melting completely through the protective heating pad and burning a hole directly through the structural plastic of the black water tank it was applied to. * This created a severe fire hazard for two individuals who had been using the travel trailer at the time of the finding. *This issue is consistent with current NHTSA recalls on this component. RV manufacturers like Grand Design and WInnegago have already issued urgent Federal safety recalls and "Do Not Drive" advisories on vehicles equipped with ThermaHeat pads due to high resistance and severe terminal overheating. *There were no warning lamps or advisories from control panels to indicate the issue and potential danger.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .