2024 Forest River Xlr Toyhauler Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2024 Forest River Xlr Toyhauler, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Body & structure150.0%
- Tires & wheels150.0%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Body & structure
Reports naming the vehicle structure, frame, body panels, doors, hood and trim.
From owner reports, verbatim
The contact owns a 2024 Forest River XLR Toy Hauler equipped with Castle Rock Tires, Tire Line: ST Trailer and Wheel Radial, Tire Size: 225/75/R15, DOT Number: (N/A). The contact stated that while driving 65 MPH, three tires had blowouts, one after the other. The passenger’s side front and rear tires and the driver's front tire had experienced the blowouts. There was damage to the aluminum siding on the RV. No warning lights were illuminated. The contact was stranded for five hours before assistance was provided. A mobile tire service arrived and replaced the tires with Goodyear Endurance tires. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The tire failure mileage was 1,000. The vehicle mileage was unknown.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Tires & wheels
Reports naming tires, wheels, hubs, or the tire-pressure monitoring system.
From owner reports, verbatim
The contact owns a 2024 Forest River XLR Toy Hauler equipped with Castle Rock Tires, Tire Line: ST Trailer and Wheel Radial, Tire Size: 225/75/R15, DOT Number: (N/A). The contact stated that while driving 65 MPH, three tires had blowouts, one after the other. The passenger’s side front and rear tires and the driver's front tire had experienced the blowouts. There was damage to the aluminum siding on the RV. No warning lights were illuminated. The contact was stranded for five hours before assistance was provided. A mobile tire service arrived and replaced the tires with Goodyear Endurance tires. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The tire failure mileage was 1,000. The vehicle mileage was unknown.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .