Reports submitted to NHTSA by owners and drivers, shown in full
Data refreshed
Our database holds 68 NHTSA owner-reported complaints for the 1994 Geo Metro. Each one is a report filed by an owner or driver and published by NHTSA without most of them being verified. A complaint is not a confirmed defect, not a recall and not a manufacturer bulletin. Narratives are shown exactly as filed.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Showing 1–25 of 68 · page 1 of 3
SEVERE CORROSION OF BODY FRAME HARD POINT TO REAR OF LOWER CONTROL ARM OF FRONT SUSPENSION CAUSED BOTH FRONT WHEELS TO SPLAY OUT WITH UNCONTROLLABLE CAMBER AND STEERING. BOTH FRONT TIRES WORE ON INNER HALF OF TIRES ONLY AND VEHICLE REQUIRED HARD LEFT FORCE ON STEERING WHEEL TO CONTROL. *TR
TL*THE CONTACT OWNS A 1994 GEO METRO. WHILE DRIVING AT AN UNKNOWN SPEED, THE CONTACT HEARD A NOISE WHEN SHE DROVE OVER A BUMP. THE DEALER STATED THAT THE FRONT DRIVER SIDE TIRE FRAME WAS CORRODED, AND THE TIRE COULD FALL AT ANY MOMENT. THE MANUFACTURER WAS NOTIFIED; HOWEVER, THEY STATED THAT THE VEHICLE WAS OLD AND THE CONTACT WOULD BE RESPONSIBLE FOR THE REPAIR. THE VEHICLE WILL BE TAKEN TO A BODY SHOP FOR REPAIR. THE CURRENT AND FAILURE MILEAGES WERE 159,000.
SEAT BELT USE FOR PEOPLE OVER SIX FEET TALL. I RECEIVED THROAT INJURIES FROM THE SEAT BELT JUST BY HITTING A BUMP. IF THIS OCCURRED DURING A MINOR ACCIDENT, I WOULD BE DEAD. THE CAR WAS A GEO METRO 1994. THIS ALSO HAPPEN DURING HARD BREAKING. I HAVE SOLD THE CAR BUT STILL HAVE PROBLEMS WITH THE SHOULDER BELT RAPPING AROUND MY NECK. I HAVE JUST RECEIVED A TICKET FOR WEARING THE SHOULDER STRAP UNDER MY ARM. THE SEAT BELT EXTENDER ARE A POOR DESIGN, AND WILL NOT WORK. I WOULD LIKE A LAW ALLOWING EVERYONE OVER SIX FEET TO BE ABLE TO WEAR A SEAT BELT UNDER THE ARM. DID YOU EVER DO A STUDY ON HOW MANY PEOPLE ARE KILLED BY BEING STRANGLED BY A SEAT BELT? *TR
LTR FM SUSAN LEBLANC (WI) RE HER 1994 GM GEO METRO HATCHBACK, THE FRAME OF THE CAR BROKE AWAY FROM THE BODY OF THE CAR, REPLY TO THE JANESVILLE DISTRICT OFFICE, ALL ATTACHMENTS NOT IMAGED FWD TO NVS200. *PH *JB *CB
WHILE DRIVING AT HIGHWAY SPEED, THE FRAME BROKE WITHOUT WARNING. *AK THE CONSUMER NOTED SHE WAS ALMOST KILLED BY THE DEFLECTING STEEL FROM THE DEFECTIVE FRAME. *PH *JB
WHEN CONSUMER UNLOCKED SEAT BELT IT FLEW OUT OF HER HAND AND SNATCHED BACK. SHE HEARD SOMETHING INSIDE OF THE LOCKING PART, SOUNDED AS IF IT BROKE. *AK
CONSUMER NOTICED A BUBBLE IN THE SIDEWALL OF THE REAR LEFT TIRE, AND A SLASH IN THE FRONT RIGHT TIRE. *JB *SCC
HEADLIGHTS WOULD GO OUT WHILE DRIVING. DEALER AND MANUFACTURER WERE NOTIFIED AND INFORMED THAT NO RECALL IS OPEN FOR THAT PROBLEM, FEEL FREE TO PROVIDE ANY FURTHER DETAILS ON THIS MATTER.*AK
WHILE DRIVING VEHICLE HOOD RELEASED FROM LATCH AND FLEW UP AND SMASHED DRIVER'S AND PASSENGER'S FRONT WINDSHIELD. CONSUMER WAS ABLE TO KEEP CONTROL OF VEHICLE. CONSUMER HAS CONTACTED DEALER, AND DEALER HAS NOT FOUND A REMEDY. PLEASE PROVIDE ANY FURTHER INFORMATION. *AK
WHILE DRIVING ABOUT AT ANY MPH WOULD STEP ON BRAKES PEDAL, BUT BRAKES WILL NOT ACTIVATE ON TIME. MOST OF TIMES THIS HAPPENED IN THE MORNING. HAD CONTACTED DEALER, AND THEY SAID THIS PROBLEM HAS HAPPENED OFTEN TO THIS MAKE AND MODEL.*AK
ALTERNATOR BELT KEEPS POPPING OFF, CAUSING VEHICLE TO STALL POSSIBLY DUE TO A DEFECT IN PULLEY , CONSUMER HAS REPLACED BELT 4 TIMES.*AK
CAR HAS GREAT GAS MILEAGE BUT HAS DEADLY STRUCTURAL,SAFETY AND COMFORT DESIGN FLAWS
MAP SENSOR FAILED CAUSEING STALLING AND POOR PERFORMANCE IN COLD WEATHER. *ET
TURN SIGNALS BEGAN TO WORK INTERMITTENTLY EVEN THOUGH I CLEANED SOCKETS AND REPLACED BULBS. THEN HEADLIGHTS FAILED AT 2AM 0N 11/15/99 AND I TOOK THE CAR TO THE DEALER THAT AFTERNOON. THEY FOUND THE HARNESS SHORTING OUT INTERMITTENTLY AND THEY REPLACED IT. LOOKING AT THE PLUG-INS ONE OF THEM LOOKED DISCOLORED FROM THE SHORTING OUT. *AK
THE METAL ATTACHMENT ON THE UNDERSIDE OF THE HOOD THAT LOCKS INTO THE HOOD LATCH IS RIPPING LOOSE FROM THE HOOD. THE PROBLEM HAS BEEN REPORTED TO THE DEALERSHIP. THE DEALERSHIP WOULD NOT REPAIR THE PROBLEM BECAUSE OF LIABILITY. PLEASE PROVIDE ANY FURTHER INFORMATION. *AK
WHILE DRIVING HOOD FLEW UP, CRACKING THE WINDSHIELD. *AK
WHILE DRIVING THE HOOD FLEW UP, CRACKING THE WINDSHIELD. *AK
CONSUMER WAS REAR ENDED AT VERY HIGH SPEED IN WHICH DRIVER'S AND PASSENGER'S SEATBACKS COLLAPSED FROM THE UPRIGHT POSITION. PLEASE GIVE ANY FURTHER DETAILS. *AK
REAR DRIVER'S AND PASSENGER'S DOOR LOCKS ARE INOPERABLE. PASSENGERS CANNOT ENTER OR EXIT THE VEHICLE FROM THE REAR DOORS. CAUSE UNKNOWN. PLEASE GIVE ANY FURTHER DETAILS. *AK
VEHICLE CAUGHT ON FIRE IN THE ENGINE COMPARTMENT WITHOUT PRIOR WARNING. NO ONE HAS INSPECTED THE VEHICLE YET. PLEASE PROVIDE FURTHER INFORMATION AND VIN#. *AK
THE ENGINE OF THE 1994 GEO METRO HAVE FAILED 3 TIMES AT A TOP SPEED OF 60MPH. EACH TIME THERE IS ENGINE FAILURE, IT LOOSES DECOMPRESSION. ONCE THE ENGINE LOOSES DECOMPRESSION, THE VALVES BURN AND/OR TWIST. THREE TIMES WE HAVE HAD THE BLOCK HEAD REMOVED, THE VALVES REDONE AND EACH TIME THE ENGINE FAILS AGAIN. THE LAST TIME THE ENGINE FAILED, TOP SPEED WAS 55MPH AFTER 10 MINUTES OF DRIVING. THE CHEVROLET MANUFACTURER SAYS THERE HAVE BEEN NO RECALLS OF THIS ENGINE OR MAKE/MODEL. EVEN THOUGH WE PURCHASED IT USED WITHOUT WARRANTIES, WE HAVE SPENT THOUSANDS OF DOLLARS FOR THIS VEHICLE THAT CONTINUOUSLY FAILS TO OPERATE. THE DEALER REFUSED TO REPLACE THE UNIT AFTER OUR REPEATED REPORTING OF OTHER PROBLEMS PRIOR TO OUR EXPERIENCE WITH ENGINE FAILURE. CAN YOU HELP US?
WHEN ROTATING TIRES EVERY 6000 MILES SEVERAL OF THE LUG STUDS BREAK OFF -
WATER PUMP FAILED.
IN DRIVING THE CAR 30.000 MILES, I HAVE PUT ON FOUR SETS OF ROTORS, SOMETHING THAT IS WRONG WITH THE CAR KEEPS MAKING THEM "RUT OUT"....A NEW SET OF ROTORS ONLY WORKS FOR ABOUT 3 MONTHS....I KNOW THERE HAS TO BE SOME TYPE OF DEFECT WITH THE FRONT END BRAKING SYSTEM, BUT CHEVY REFUSED TO CHECK INTO IT FOR ME
WHILE DRIVING APPROX. 15MPH, THE FRONT AXLE FELL OUT OF THE HOLE. THIS CAUSED THE VEHICLE TO SLAM TO THE GROUND DUE TO A DEFECTIVE BOLT IN THE AXLE. THE MECHANIC SAID IT SHOULD NOT HAVE FALLEN OUT & DID NOT KNOW WHAT HAD HAPPENED. *AK
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Categories with enough reports to have a page of their own
Data on this page last refreshed .