RoadVitals

1998 Gillig 29 Foot Low Floor Recalls

Safety recall campaigns filed with NHTSA that cover this model year

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
Recall campaignsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
0
Carrying an NHTSA advisoryCampaigns where NHTSA told owners not to drive the vehicle, or to park it outside, until the repair is done.
0
Open investigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
0
2 investigations on file

Recall campaigns

No recall campaigns in our database for this model year

This does not guarantee that a specific vehicle is unaffected. Recalls are issued against ranges of VINs rather than against a whole model year, new campaigns are announced regularly, and a manufacturer may have opened one since our last refresh. The authoritative answer for one vehicle is NHTSA’s own lookup — check a VIN on NHTSA.gov.

What a recall is

Safety recall
A safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
Safety investigation
NHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
Manufacturer communication
Manufacturers file copies of the bulletins they send to dealers with NHTSA. These often describe diagnostic or repair procedures for a known condition. They are not recalls: repairs described in a bulletin are usually only free if the vehicle is still under warranty or the manufacturer has extended coverage.

Safety investigations

NHTSA inquiries naming this vehicle. An investigation is not a finding of a defect, and it is not a recall.

EA03009ClosedEngineering Analysis

ENGINE COMPARTMENT FIRES

Opened Jun 30, 2003
Closed Oct 21, 2003

THIS INVESTIGATION WAS OPENED BASED ON INFORMATION RELATED TO ENGINE FIRES ON MODEL YEAR 2000-2001 GILLIG BUSES.WHILE CONDUCTING THE ENGINEERING ANALYSIS, PROBLEMS WERE IDENTIFIED GOING BACK TO THE 1997 MODELS, THUS EARLIER MODELS WERE ADDED TO THE SUBJECT VEHICLES UNDER INVESTIGATION.DURING THE INVESTIGATION, ODI INVESTIGATORS CONDUCTED TWO FIELD INSPECTIONS AND FOUND POTENTIAL PROBLEMS RELATED TO LOOSE WIRE HARNESSES IN THE ENGINE COMPARTMENT AREA.ODI ALSO DISCUSSED THE MATTER WITH INDEPENDENT FIRE INVESTIGATORS AND HAD EXTENSIVE DISCUSSIONS WITH GILLIG OFFICIALS.A COMMON TREND NOTED IN THESE DISCUSSIONS OF THE FIRES PERTAINED TO WIRE HARNESS PROTECTION AND ROUTING ISSUES.GILLIG HAD PREVIOUSLY PUBLISHED A SERVICE BULLETIN AND THAT BULLETIN HAS NOW BEEN UPGRADED TO A SAFETY RECALL.OWNERS WILL BE NOTIFIED OF THE APPROPRIATE REMEDY.FULL DETAILS ARE INCLUDED IN THE ATTACHED OWNER LETTER.THIS RECALL ACTION ADDRESSES THE CONCERNS DISCOVERED BY ODI DURING THE INVESTIGATION.THEREFORE, THIS INVESTIGATION IS CLOSED.

ELECTRICAL SYSTEM:WIRING:FUSES AND CIRCUIT BREAKERSLed to recall 03V392000
PE02090ClosedPreliminary Evaluation

ENGINE COMPARTMENT INSULATION SAGGING

Opened Nov 29, 2002
Closed Dec 13, 2002

ON SEPTEMBER 26, 2002, GILLIG ISSUED A SERVICE BULLETIN (FS-2002-04)ADDRESSING THE OVERHEAD INSULATION IN THE ENGINE COMPARTMENT THAT OVER TIME COULD SAG AND CONTACT THE HOT SURFACE OF THE ENGINE TURBOCHARGER.THIS TYPE FAILURE COULD POTENTIALLY LEAD TO A VEHICLE FIRE.DUE TO THE AGENCY'S INVESTIGATION INTO THIS MATTER, GILLIG HAS AGREED TO INITIATE A SAFETY RECALL CAMPAIGN AND RETROFIT 2,108 BUSES WITH NEW INSULATION AND RETAINING STRIPS.THE ACTION TAKEN BY GILLIG IS SUFFICIENT TO RESOLVE THE ISSUES RAISED BY THIS INVESTIGATION.A COPY OF THE SAFETY RECALL IS ATTACHED.THIS INVESTIGATION IS CLOSED.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.

ENGINE AND ENGINE COOLINGLed to recall 02V325000

Elsewhere on this vehicle

Data sources