RoadVitals

2004 Gillig 35 And 40 Foot Low Floor Recalls

Safety recall campaigns filed with NHTSA that cover this model year

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
Recall campaignsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
2
Newest Jun 9, 2005
Carrying an NHTSA advisoryCampaigns where NHTSA told owners not to drive the vehicle, or to park it outside, until the repair is done.
0
Open investigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
0

Recall campaigns

2 campaigns cover this model year — what the defect is, what it could cause, and what the remedy is

05V271000

SUSPENSION:FRONT

Jun 9, 2005
1,096 units potentially affected
The defect: ON CERTAIN TRANSIT BUSES, THE CAST CLAMP PORTION OF THE TORQUE ROD COULD CRACK UNDER INITIAL TORQUEING OF THE CLAMP FASTENERS RESULTING IN BREAKAGE OR CRACKS. CASTING POROSITY AND INCORRECT HEAT TREATMENT CAUSED POTENTIAL WEAKNESS IN THE CAST CLAMP PORTION OF THE TORQUE ROD.
The risk: THIS COULD RESULT IN LOSS OF VEHICLE CONTROL AND A CRASH COULD OCCUR WITHOUT PRIOR WARNING.
The remedy: DEALERS WILL REPLACE THE CAST IRON TORQUE ROD CLAMPS WITH A FABRICATED STEEL CLAMPS FREE OF CHARGE. THE RECALL BEGAN ON JUNE 17, 2005. OWNERS MAY CONTACT GILLIG AT 510-785-1500.
GILLIG CORPORATIONView on NHTSA.gov
05V106000

ENGINE AND ENGINE COOLING

Mar 17, 2005
10 units potentially affected
The defect: ON CERTAIN TRANSIT BUSES EQUIPPED WITH WEBASTO HEATERS, THE BURNER TUBES ARE MADE OF MATERIAL THAT DOES NOT MEET SPECIFICATIONS AND COULD FAIL PREMATURELY.
The risk: SHOULD THE BURNER TUBE FAIL, THE COOLANT HEATER COULD OVERHEAT, POSSIBLY RESULTING IN A FIRE.
The remedy: WEBASTO IS CONDUCTING THE OWNER NOTIFICATION AND REMEDY FOR THIS CAMPAIGN. WEBSTO WILL REPLACE THE SUSPECTED DEFECTIVE PARTS. OWNERS MAY CONTACT WEBASTO AT 810-593-6000 OR GILLIG AT 510-264-5031.
GILLIG CORPORATIONView on NHTSA.gov

What a recall is

Safety recall
A safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
Safety investigation
NHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
Manufacturer communication
Manufacturers file copies of the bulletins they send to dealers with NHTSA. These often describe diagnostic or repair procedures for a known condition. They are not recalls: repairs described in a bulletin are usually only free if the vehicle is still under warranty or the manufacturer has extended coverage.

Elsewhere on this vehicle

Data sources