2022 Grand Design Momentum Owner Complaints

The contact owns a 2022 Grand Design Momentum RV. The contact stated that there was an excessive frame flex in the body of the RV. The contact stated that the walls were separating, and the doors were opening unintendedly while driving. The vehicle was taken to the local dealer, where it was diagnosed and the lag bolts were replaced. The vehicle was repaired, but the failure reoccurred. The manufacturer was contacted, but no assistance was provided. The failure mileage was unknown.

NHTSA ID

11752065

Incident

Feb 1, 2022

The contact owns a 2022 Grand Design Recreational Trailer. The contact stated that while the trailer was parked, an inspection of the trailer revealed that the front passenger-side door was inoperable and failed to properly open and close. The contact also noticed sawdust present in the bedroom area of the trailer. Additionally, the generator compartment was inoperable and failed to lock properly. The contact received a recall notification from the manufacturer related to the trailer. The trailer was taken to the dealer; however, the trailer was not diagnosed or repaired. The dealer informed the contact that the trailer needed to be inspected, and photographs of the failure were sent to a specialist for further evaluation. The contact later stated that the dealer advised that the inspection had been canceled after the photographs were submitted. The trailer was not diagnosed or repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 200.

NHTSA ID

11737122

Incident

May 11, 2026

Mileage

200 mi

Lag bolts that connect the frame to the wall are coming out/ or were never put in place. Wall is separating from the frame and can see to the outside from the inside. If we had not seen this these bolts could have come all the way out causing the wall the separate while driving. Unknown at this time if there is any frame damage. Grand Design 2022 Momentum 381m

NHTSA ID

11705270

Incident

Dec 11, 2025

The contact owns a 2026 GMC Sierra 3500 used to haul a 2022 Grand Design Momentum RV. The contact stated while driving approximately 70 MPH, the interior bedroom cabinets shifted and were rubbing against the wall. On another occasion while driving at an undisclosed speed, the contact pulled over and noticed that the 8-inch gap between the RV and the bed of the vehicle was no longer there and the RV was sitting on the bed of the vehicle. The contact stated that on another occasion, while parked, the contact became aware that the running lights were inoperable. The contact stated that on another occasion he observed that the bedroom baseboards were separating from the wall and there was a crack running along the side of the wall. The contact inspected the outside of the RV and noticed that the driver’s side wall was bulging and had a diagonal crack. The RV was towed to a dealer where it was diagnosed that there was frame damage due to poor design. The RV was not repaired. The manufacturer was notified of the failure. The failure mileage was unknown.

NHTSA ID

11704492

Incident

Apr 18, 2024

Mileage

70 mi

NHTSA – Complaint filed 7/24/25 ODI #11675985 1.Pin box movement within the upper deck, sagging geometry. 2.Entry door opens during travel despite safety bar being engaged. 3.Entry door is difficult to close and does not stay secured even when locked while stationary. 4.Passenger-side main slide partially opens during travel. 5.Passenger-side main slide is separating from the camper; frame is damaged, floor plywood is exposed and deteriorating. 6.Suspension wet bolts cracked on all six tires due to excessive wear from frame flex; all replaced. 7.Exterior garage door (near front cap) bows outward, opens during travel, and is difficult to secure even after Grand Design’s previous replacement. 8.Master bedroom dresser is detaching from the wall; sides are collapsing. 9.Washer/dryer doors no longer align; they remain open during travel due to changed dimensions. 10.Multiple interior wall cracks. 11.Master bedroom floor is sagging and produces loud noises underfoot. 12.Nails protruding through walls throughout the camper. 13.Ceiling and wall trim detaching throughout the unit. 14.Loft near the main slide is separating from the wall.

NHTSA ID

11676479

Incident

Jul 25, 2023

The contact owns a 2022 Grand Design Momentum RV. The contact stated while driving at an undisclosed speed, the camper was bouncing up and down. Due to the failure, the furniture detached from the wall. In addition, the bedroom floor fractured and pieces of the floor were separated. The manufacturer was made aware of the failure and the contact was advised to take the camper to a dealer in North Carolina, a six-hour drive away. The dealer determined that the failure was the result of nine lag bolts that were missing from the camper frame. The contact was informed that the failure was due to a manufacturer defect. The camper was repaired; however, the failure reoccurred. The contact stated that the pin box shifted downward, and the main slide on the passenger's side fractured and shifted down towards the ground and the furniture detached away from the wall. The main bedroom floor was fractured and sagging. The contact stated that while the RV was hitched and traveling, the main door unlatched and opened. Additionally, the garage door was bowed due to the failure of the frame. The manufacturer was made aware of the failure and a case was filed. The contact was advised to take the camper back to the dealer. The contact requested the manufacturer to buy the camper back, however the request was denied.

NHTSA ID

11675985

Incident

Jul 25, 2023

The issue with the frame having issues causing a safety concern and interior damages. When the frame over flexes it will stress other components, walls, trim, and cabinets.

NHTSA ID

11667274

Incident

Jun 14, 2025

DUE TO EXTREME FRAME FLEX, THE WELDS IN THE FRONT OF MY COACH BROKE AWAY FROM THE METAL. MY UNDERSTANDING IS THAT THE ONLY THING HOLDING MY 44' TOY HAULER ON MY TRUCK WAS THE INTERIOR AND EXTERIOR SKIN OF THE COACH. I WAS HORRIFIED TO FIND THAT I WAS DRIVING MY COACH UNDER THESE DANGEROUS CONDITIONS CAUSING EXTREME RISK TO MY FAMILY AND THOSE ON THE ROAD. TO BE CLEAR, THIS FAILURE ONLY SHOWED ITSELF WITH ONLY MINOR SYMPTOMS TO AN UNTRAINED EYE. AFTER READING ALL THE COMMENTS ONLINE, I REALIZED THIS NEEDS TO BE ADDRESSED FOR EVERYONE CONCERNED

NHTSA ID

11663662

Incident

May 5, 2025

Our 2022 395ms is being taken back to the factory in Elkhart Indiana due to unsafe frame flex/failure

NHTSA ID

11650775

Incident

Mar 26, 2025

FRAME & STRUCTURE FAILURE What component or system failed or malfunctioned, and is it available for inspection upon request? Frame failure - yes, it is available How was your safety or the safety of others put at risk? Structure failure during transport would cause obvious harm and possibly deaths Has the problem been reproduced or confirmed by a dealer or independent service center? No, this is our first step Has the vehicle or component been inspected by the manufacturer, police, insurance representatives or others? Not since the issue occurred. Were there any warning lamps, messages or other symptoms of the problem prior to the failure, and when did they first appear? No. Current symptoms are: Huge gap in filon (1 inch or greater) by pin box, sawdust and trim falling off in bedroom closet, doors opening during travel - pantry door, refrigerator door, laundry door in bedroom.

NHTSA ID

11646188

Incident

Mar 3, 2025

Fiberglass separated, storage doors bowed, Movement in pinbox, broken frame, inside wall movement, trim wearing with movement

NHTSA ID

11637878

Incident

Apr 15, 2024

I am having the frame flex issues as well as others. I’m not getting anywhere with grand design. The doors come open when traveling if not strapped from the inside. Pin box on the hitch moves excessively, interior panels are moving in the front, middle and rear of the trailer.

NHTSA ID

11637760

Incident

May 3, 2024

There are several things starting off with frame flexing issue causing numerous of parts to fail and move out of place. The manufacturer did a repair of this and my confidence in it being repaired correctly is very low. I do not feel safe towing this RV anywhere. Second, the broken leaf spring on the front axle. This could have caused the vehicle to lose control and cause a serious accident. It has been repaired. We have had the entry doors come open on us during towing. Nothing was lost from this. Lastly, the master bedroom slide has come out about 3 inches during travel. They repaired the inside bottom brace at the service center.

NHTSA ID

11634579

Incident

Sep 3, 2023

The contact owns a 2022 Grand Design Momentum. The contact stated that there was sawdust in the trailer and the frame was sinking. The contact stated that the cabinets were loose and were detaching from the frame. There was evidence that the frame was flexing. The contact noticed a lot of movement and bending with the frame. The contact stated that the front hitch and furniture were detaching from the walls. The screws were not properly torqued. Additionally, there was water entering through the slides. There were no warning lights illuminated. The local dealer was not contacted. The RV was not diagnosed or repaired. The manufacturer was contacted. The failure mileage was unknown.

NHTSA ID

11633070

Incident

Oct 1, 2024

Multiple systems failed on this unit. Trailer Brake failure—The rear trailer brake wires were discovered to be severed inside the wheel drum from the factory. For the first year of use they were inoperable. This was suspected and confirmed with a thermal camera. The tow vehicle also alarmed “Check trailer brakes” while driving. A dealer inspected them and found the wires severed. This was repaired. Suspension failure—the rear driver side leaf spring broke on a paved highway 9 months after purchase. Pulled over immediately to inspect the issue and repair it. On 2 other separate occasions, we found broken wet bolts (after the unit was sitting in one place, unmoved for weeks). Also a cracked equalizer was replaced under warranty within the first year. The front passenger side leafspring also broke on an empty unit. Frame Failure & opening baggage compartment doors, slide out backing out in transit—symptoms of excessive upperdeck flex and frame failure began immediately upon purchase. Baggage compartment doors frequently open in transit. This has been a significant safety risk to the operator as well as other drivers. On more than one occasion the doors open in dense traffic in the middle of a city with nowhere to safely pull over. None of the contents of the compartment has fallen out to our knowledge, but could very easily fall out since none of the doors can be adequately secured. One door was replaced, but the issue not resolved. Upon further inspection, there were severely broken welds in the frame of the unit. The unit has sustained over 22 hours of welding on it to repair and reinforce the damaged frame. However, this has been repaired a total of 3 separate times. There is no guarantee that the repairs will hold moving forward. Also a result of the broken frame, the slide out began backing out in transport. Before leaving, the slide out was fully retracted and measured. Upon arrival the slide would be backed out 0.5-1” from the pre-departure measuremen

NHTSA ID

11631546

Incident

Jan 31, 2023

This unit is suffering from frame failure. Cargo doors have started opening on the freeway, cabinets are rubbing the wallpaper from frame flex, the forward floor has started squeaking, the forward lower exterior trim panel on the drivers' side is buckling, the forward walls have started creaking and popping when hitching up/unhitching and the pin-box "sinks" more than it ever did in the past when hitching up. I am very worried since these are all symptoms of frame failure. I've taken the unit to an authorized Grand Design repair center and so far, am not getting any support from Grand Design to actually fix the frame, the root cause for all of these symptoms. I'm worried if I accept the trailer and continue to use it, the problem will progress and we could end up with a complete failure while on the freeway.

NHTSA ID

11629723

Incident

Jun 1, 2024

The front frame has been in for repairs before for flexing issues/excessive movement. We have had a door pop open during travel and suspension parts break (hanger and leaf spring) in 2 separate incidents. The frame appears to have further issues on the passenger side more recently.

NHTSA ID

11627843

Incident

Nov 23, 2024

The RV has significant frame failure that Grand Design (the manufacturer) is ignoring. I noticed my floors warping and a cabinet crack. There was also some cracking of the fiberglass. I asked the dealership to check it out. The found that the frame is warped, multiple lagbolts are missing and several welds have popped. The RV is unsafe and not road worthy. Grand Design is aware of this issue and has yet to issue a recall or notify owners of the significant structural defect they caused by undersizing the frame and using the wrong lagbolts.

NHTSA ID

11618500

Incident

Oct 7, 2024

BOTH ACCESS doors are opening in transit along with pass thru baggage storage doors this has been brought to the attention of the manufacturer and the selling dealership We have had to tape the doors shut just to get somewhere safe These problems started shortly after purchasing its been back to the factory for repairs where they found abnormal frame flex / failure ,we were told additional frame gussets were added There was stress cracks in the front cap area which we found out later that is a sign of abnormal frame flex which we believe is causing the doors to open allowing items to eject onto the roadway

NHTSA ID

11603906

Incident

Jul 19, 2024

Frame not strong enough to support full GVWR. Result. Frame flexing excessively which can lead to frame failure and separation from the vehicle on the highway endangering everyone. Manufacturer has done their recommended fix on my rv but they have a history of ineffective repairs. So far my rv hasn’t been on the road enough since first repair to know if it will hold.

NHTSA ID

11602042

Incident

Jun 1, 2024

A spring snapped in two near the mounting point to the frame. Rv was not overloaded. Grand design authorized replacement of all springs which is now complete. Others have had similar failures. Im guessing the metal used was too brittle. The busted spring can cause the rv to pull sideways a bit making safe controlling on the highway a possible hazard to everyone on the highway. An accident could occur endangering everyone around the rv with failed suspension. I managed to catch the failure before any injuries occured.

NHTSA ID

11602039

Incident

Apr 2, 2024

I was towing my 5th wheel RV when I noticed doors I locked were swinging open. I noticed the rear toy hauler door first. The plastic screen door cover was missing and was unable to be found. A few miles later I noticed the front underbelly storage area on the passenger side was swinging open. Some power tools fell out and were unable to be found. A few hundred miles later the propane door unlatched and was swinging open. I closed and proceeded on route. My Lippert frame is flexing causing these locked doors to open mid travel, losing personal belonging in the middle of the interstate. Later that trip I noticed my front bedroom slide-out was moving out on one side (driver) After pulling over and attempting to pull it in, the slide would not pull in. It was sticking out about 8" off the side of the walls of the RV. Lastly I noticed my pin box was at a hard angle when traveling. It appears that something on the frame to the pin box is not secure. The RV needs to be inspected by the manufacturer as soon as possible to prevent major casualty.

NHTSA ID

11600889

Incident

Jun 17, 2024

We live and travel full time in a 2022 Grand Design Momentum model 376THS. Screws and bolts holding the front opposing schwintek slides are breaking or backing out of the slide frame every time we travel, the front floors are squeaking and getting worse, the front cap developed stress cracks and was repaired one year ago - they have now reappeared and there are several more stress cracks visible on the front cap, the front side storage doors are coming OPEN DURING travel, we have lost items on the road from these areas, they are always locked closed before we travel. I believe this maybe be caused by a flexing coach frame.

NHTSA ID

11600080

Incident

May 4, 2023

Upper deck failure ( side pod door opens when in transit, front of trailer at king pin mounting flexing when in transit, king pin mounting hits truck bed rails when turning, bedroom floor buckling, bed rollers leave indentations in bedroom floor closet door not plumb and will not lock when disconnected from truck, front wall height changes when connected to truck, trim and panels coming loose in transit. ). Wall to frame mounting has loose, missing and wrong size lag bolts. Inspection is available upon request. Door popping open in transit is a safety hazard for myself and everyone on the road. The vehicle has been to two different dealerships and the representatives at both mentioned frame issues as part of the problem. The first issues were noted at 2,000 miles on 9-19-2021

NHTSA ID

11591933

Incident

Sep 19, 2021

I am experiencing what I believe to be a frame issue. When I take the weight of the 5th wheel off the landing gear and transfer to the 5th wheel pin I see lots of movement and hear a lot of popping and cracking noise. My floor above the 5th wheel hitch is now squeaking badly and there is a nail that has pushed through the flooring. I have broken screw in my slide out and the sealant is showing signs of movement. The trim cover sealant is pulling away so I believe the whole front of my 5th wheel is moving. My concern is this is getting to the point it maybe unsafe to pull down the highway. This appears to be a rising concern with Grand Design and Lipert frames as there is now a TSB sent out for inspection instructions.

NHTSA ID

11591257

Incident

Apr 2, 2024