2002 Harley-Davidson 1200 Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2002 Harley-Davidson 1200, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Visibility233.3%
- Brakes116.7%
- Driver assistance116.7%
- Electrical116.7%
- Suspension116.7%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Visibility
Reports naming windshields, glass, wipers, defrosters and mirrors.
From owner reports, verbatim
CONSUMER IS STILL HAVING PROBLEMS WITH SIDE MIRROR AFTER GIVEN THE REPAIR PARTS WHICH CAUSED THE BOLTS TO LOOSEN. RECALL NUMBER UNKNOWN. PLEASE PROVIDE THE DEALER NAME, NUMBER AND ADDRESS.*AK
WHILE RIDDING THE MOTORCYCLE, AT THE SPEED OF 50MPH THE LEFT MIRROR BROKE AND HIT THE CHEST LOOSING THE CONTROL. MANUFACTURER HAS BEEN NOTIFIED. NLM
Too few reports in this category for a page of its own — they appear in the full complaint list.
Brakes
Reports naming service brakes, the antilock braking system, brake hoses, master cylinders or the parking brake.
From owner reports, verbatim
THE FRONT AND REAR BRAKE MADE A NOISE WHEN APPLIED, ALSO THE REAR BRAKES DID NOT HOLD. *JB THE FRONT BRAKES MADE NOISE CONTINUOUSLY AND THERE WAS INADEQUATE EFFECTIVENESS OF THE REAR BRAKES AND REMAIN A PROBLEM. THE DEALER STATED THAT THE FACTORY WOULD NOT AUTHORIZE THE REPLACEMENT OF THE ADDITIONAL PARTS TO REMEDY THE PROBLEM. (COMMON PROBLEM IN THIS MODEL PER DEALER AND OTHER HARLEY DAVIDSON DEALERS) *SCC
Too few reports in this category for a page of its own — they appear in the full complaint list.
Driver assistance
Reports naming forward-collision avoidance, lane keeping, back-over prevention, cruise control and related electronic driver-assistance systems.
From owner reports, verbatim
WHILE DRIVING THE THROTTLE WOULD NOT COME DOWN CAUSING THE BIKE TO STAY AT A HIGH SPEED CAUSING ACCIDENT. TS *JG
Too few reports in this category for a page of its own — they appear in the full complaint list.
Electrical
Reports naming the electrical system — wiring, battery, charging, control modules, infotainment and electrical accessories.
From owner reports, verbatim
CONSUMER RECEIVED A RECALL NOTICE FOR REPLACEMENT OF THE CIRCUIT BREAKER BETWEEN BATTERY AND IGNITION. NO PARTS WERE AVAILABLE. SERVICE MANAGER DENNIS MAAS. *AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Suspension
Reports naming suspension components — springs, struts, shocks, control arms and related hardware.
From owner reports, verbatim
THE PERSON DRIVING THIS VEHICLE IS NOT THE OWNER OF THIS MOTORCYCLE AND IS DRIVING THIS MOTORCYCLE ON A SUSPENDED LICENSE. THE SUSPENDED LICENSE IS FOR EXCESSIVE DUIS AND HAS BEEN USING THIS VEHICLE (A FRIEND OF THEIRS) TO GO OUT AND PARTY.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .