RoadVitals

2002 Harley-Davidson Flhpi Problems

Owner-reported complaints filed with NHTSA, grouped by component

Data refreshed

Owner complaintsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
1
Latest Aug 3, 2004
Components namedHow many of our component categories appear on at least one report for this model year. One report can name several.
1
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
0

What this page shows

Everything below is an owner-reported complaint submitted to NHTSA about the 2002 Harley-Davidson Flhpi, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

Reports by component

Ranked by how many owner reports name each component category

  • Fuel system1100.0%

Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.

Each component in detail

What the reports in each category say, in the owners' own words

Fuel system

Reports naming fuel storage or delivery — tanks, pumps, lines, injectors and fuel leaks.

1
report

From owner reports, verbatim

WHILE OPERATING MY MOTORCYCLE, THE ENGINE BEGAN SPUTTERING AND THE ODOR OF GASOINE FUMES BECAME OVERWHELMING. I LOOKED DOWN AT THE AIR INTAKE AND NOTICED GASOLINE SPRAYING ON THE ENGINE AND PAST THE AIR INTAKE. IT WAS QUITE FORTUNATE THAT THIS DID NOT RESULT IN A FIRE! THE FUEL LINE HAD SEPARATED FROM THE CONNECTOR ON THE FUEL RAIL AND THE FUEL PUMP WAS SUPPLYING FUEL AT THE FULL DELIVERY RATE. INSPECTION OF THE FUEL LINE SHOWED THAT THE FUEL LINE WAS A HARDENED PLASTIC LINE (COVERED BY A PLASTIC CORREGATED HEAT SHIELD) THAT WAS HELD IN PLACE BY FRICTION ONLY, THERE WERE NO CLAMPS USED. BECAUSE THE FUEL LINE WAS A HARDENED MATERIAL, WITHOUT ELASTICITY OR RETAINING HARDWARE, THE VIBRATION OF THE ENGINE (AND MOST LIKELY THE HEAT AS WELL) DETERIORATED THE ADHESION OF THE CONNECTION RESULTING IN THE SEPARATION. THIS WAS A USED MOTORCYCLE, BUT IT ONLY HAD 638 MILES AND NO EVIDENCE OR RECORD OF MAINTENANCE IN THIS AREA. THE PROBLEM WAS FIXED BY THE DEALER USING HARLEY-DAVIDSON'S PART LIST WHICH INDICATED 1/4" RUBBER FUEL LINE PROTECTED BY A CORREGATED PLASTIC COVERING FOR HEAT ISOLATION, AND TWO CRIMPED HOSE CLAMPS FOR RETENTION, ONE ON EACH END. I HAVE THE ORIGINAL FUEL LINE FOR INSPECTION.*AK

NHTSA ID 10086100 · filed Aug 3, 2004

Too few reports in this category for a page of its own — they appear in the full complaint list.

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.

Elsewhere on this vehicle

Data sources

Data on this page last refreshed .