2003 Harley-Davidson Flhrci Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2003 Harley-Davidson Flhrci, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Brakes125.0%
- Electrical125.0%
- Engine125.0%
- Other / unspecified125.0%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Brakes
Reports naming service brakes, the antilock braking system, brake hoses, master cylinders or the parking brake.
From owner reports, verbatim
REAR BRAKE FAILURE DUE TO USE OF DOT 5 BREAK FLUID AT HIGH ALTITUDE IN HOT WEATHER. ON TRIP OVER SIERRAS ON JULY 16, 2006, I AND FOUR OTHERS HAD REAR BRAKE OR OTHER HYDRALIC FAILURE. *NM
Too few reports in this category for a page of its own — they appear in the full complaint list.
Electrical
Reports naming the electrical system — wiring, battery, charging, control modules, infotainment and electrical accessories.
From owner reports, verbatim
THE STOCK HORN ON MY 2003 HARLEY DAVIDSON ROAD KING CLASSIC MOTORCYCLE HAD BEEN ANEMIC AT BEST FROM NEW AND HAD PROGRESSIVELY GOTTEN WEAKER IN VOLUME AND NOW ONLY WORKS INTERMITTENTLY. THE DEALERS HAS CLAIMED THAT THE LOW VOLUME IS TYPICAL OF HD HORNS AND THAT, SINCE THE INTERMITTENT FAILURE OCCURRED AFTER THE 12 MONTH ORIGINAL WARRANTY, IT IS NOT A HD PROBLEM. THERE HAS NOT BEEN AN ACCIDENT YET. IF THERE IS, I MIGHT NOT BE AROUND TO COMPLAIN. *JB
Too few reports in this category for a page of its own — they appear in the full complaint list.
Engine
Reports naming the engine itself — including stalling, misfires, oil consumption, cooling and internal engine components.
From owner reports, verbatim
CATASTROPHIC ENGINE FAILURE OCCURRED TWICE IN A NEW 2003 HARLEY-DAVIDSON MOTORCYCLE AT 3284 MILES AND AGAIN AT 7420 MILES. THE FIRST WAS DUE TO A CRACKED FLYWHEEL, WHICH WAS REPLACED UNDER WARRANTY, AND THE SECOND DUE TO A BROKEN OIL PUMP. THE CAUSE WAS DETERMINED BY AN ENGINEER'S MEASUREMENTS TO BE MIS-ALIGNED CRANKCASE, AND THE MANUFACTURER REFUSES TO REPAIR OR REPLACE THE ENGINE. *LA
Too few reports in this category for a page of its own — they appear in the full complaint list.
Other / unspecified
Reports whose component NHTSA recorded as unknown, or that do not map to one of the categories above.
From owner reports, verbatim
HARLEY DAVIDSON FLHRCI 2003. THE HOSES TO THE OIL COOLER COULD POSSIBLY RUBBED AGAINST THE ENGINE CRANKCASE. THE HOSES MAY LEAK OIL WHICH CAN CAUSE THE REAR TIRE TO SPIN OUT IF THE OIL CAME IN CONTACT WITH THE TIRE. PLEASE PROVIDE FURTHER DETAILS. *PH THE CONSUMER RECEIVED RECALL#03E051000 FROM A THIRD PARTY, HOWEVER WHEN THE CONSUMER CONTACTED THE MANUFACTURER, HE WAS INFORMED THAT A FIX HAD NOT BEEN DEVELOPED AND TO TAKE THE MOTORCYCLE TO THE DEALER WHO MAY PROVIDE A SOLUTION. THE DEALER REPLACED THE HOSE, HOWEVER THE CONSUMER DID NOT BELIEVE THAT WOULD SOLVE THE PROBLEM.*JB
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .