RoadVitals

2017 Harley-Davidson Flhtk Problems

Owner-reported complaints filed with NHTSA, grouped by component

Data refreshed

Owner complaintsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
8
Latest Jun 13, 2019
Components namedHow many of our component categories appear on at least one report for this model year. One report can name several.
3
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
0

What this page shows

Everything below is an owner-reported complaint submitted to NHTSA about the 2017 Harley-Davidson Flhtk, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

Reports by component

Ranked by how many owner reports name each component category

  • Powertrain (other)666.7%
  • Fuel system222.2%
  • Engine111.1%

Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.

Each component in detail

What the reports in each category say, in the owners' own words

Powertrain (other)

Powertrain reports that are not specifically the engine or transmission — driveshafts, axles, transfer cases and differentials.

6
reports

From owner reports, verbatim

WHEN COMING TO A COMPLETE STOP THE RPM DROPS AND MOTOR STALLS. HAVE TO GET BACK TO NEUTRAL AND RESTART THE BIKE.

NHTSA ID 11219904 · filed Jun 13, 2019

TL* THE CONTACT OWNS A 2017 HARLEY-DAVIDSON FLHTK. THE CONTACT STATED THAT THE RECALL REPAIR FOR NHTSA CAMPAIGN NUMBER: 18V734000 (POWER TRAIN) FAILED TO PROVIDE A PERMANENT REMEDY. THE VEHICLE WAS SERVICED BY CANNONBALL HARLEY-DAVIDSON (3912 S US HWY 41, TERRE HAUTE, IN 47802, 1-(812) 232-7821). THE DEALER REFUSED TO PROVIDE FURTHER ASSISTANCE AFTER BEING MADE AWARE THAT THE NEW SECONDARY CLUTCH ACTUATOR PISTON ASSEMBLY FAILED. THE CONTACT ORDERED THE PART FROM LEGACY HARLEY-DAVIDSON (1315 ALTHOFF DR, EFFINGHAM, IL 62401, 1-(217) 342-3494) AND THE OWNER REPLACED THE PART. THE MANUFACTURER WAS NOTIFIED AND DID NOT ASSIST. THE MOTORCYCLE WAS REPAIRED. THE FAILURE MILEAGE WAS NOT AVAILABLE.

NHTSA ID 11216942 · filed May 30, 2019

Too few reports in this category for a page of its own — they appear in the full complaint list.

Fuel system

Reports naming fuel storage or delivery — tanks, pumps, lines, injectors and fuel leaks.

2
reports

From owner reports, verbatim

MOTORCYCLE STALLS CUTS OUT IN STOP AND GO TRAFFIC. RPMS DROP FROM 1,000 - 500 WHEN YOU APPLY FUEL IT SPUTTERS AND CUTS OUT. TOOK TO DEALERSHIP THEY SAID IT WAS NORMAL, BUT IF IT STALLED OUT WHILE IN THE FREEWAY THEN BRING IT IN.

NHTSA ID 11088507 · filed Apr 16, 2018

ON A DAILY BASIS, WHILE OPERATING THE MOTORCYCLE WITH THE CLUTCH ENGAGED, IN GEAR, AND AT IDLE SPEED, THE ENGINE WILL STALL. THIS OCCURS WHEN YOU ARE STOPPING FOR A STOP SIGN, RED LIGHT, OR IN BUMPER-TO-BUMPER TRAFFIC. WHEN THIS OCCURS, YOU CAN NOT RESTART THE ENGINE. NEW RESTRICTIONS ON THE MOTORCYCLE DO NOT ALLOW THE ENGINE TO BE STARTED WITH THE MOTORCYCLE CLUTCH ENGAGED WITH IT "IN GEAR". YOU MUST COME TO A COMPLETE STOP, PLACE THE TRANSMISSION IN NEUTRAL. AND THEN YOU ARE ALLOWED TO RESTART THE ENGINE. THIS IS PROBLEMATIC AT BEST AND EXTREMELY HAZARDOUS WHEN IN BUMPER-TO-BUMPER TRAFFIC. NUMEROUS OCCASIONS HAVE OCCURRED WHEN MY ENGINE HAS STALLED AND TRAFFIC BEHIND ME STARTS MOVING AND I CAN'T.

NHTSA ID 11055610 · filed Dec 19, 2017

Too few reports in this category for a page of its own — they appear in the full complaint list.

Engine

Reports naming the engine itself — including stalling, misfires, oil consumption, cooling and internal engine components.

1
report

From owner reports, verbatim

IT IS TRANSFERRING OIL FROM THE TRANSMISSION TO THE PRIMARY WHILE RIDING. THIS CAUSES THE PRIMARY TO OVERFILL WHICH RESULTS IN CLUTCH ISSUES AND DIFFICULTY FINDING NEUTRAL. THE TRANSMISSION IS GOING DOWN WHICH IS PROBABLY DECREASING ITS LIFE AND COULD CAUSE IT TO LOCK UP DUE TO LOW OIL LEVEL. THIS IS POTENTIAL SAFETY ISSUE THAT COULD LEAD TO A CATASTROPHIC ACCIDENT IF THIS OCCURS AT HIGHER SPEEDS. BIKE HAS ONLY 2500 MILES ON IT AND SHOULD NOT BE DOING THIS. NO ACKNOWLEDGEMENT FROM THE DEALER.

NHTSA ID 11012209 · filed Aug 1, 2017

Too few reports in this category for a page of its own — they appear in the full complaint list.

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.

Elsewhere on this vehicle

Data sources

Data on this page last refreshed .