2016 Harley-Davidson Flhtkse Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2016 Harley-Davidson Flhtkse, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Powertrain (other)375.0%
- Electrical125.0%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Powertrain (other)
Powertrain reports that are not specifically the engine or transmission — driveshafts, axles, transfer cases and differentials.
From owner reports, verbatim
THE ASSIST & SLIP CLUTCH OF MY HD NEARLY GOT ME KILLED THE OTHER DAY. I WAS TURNING IN AN INTERSECTION AND HAD SHIFTED INTO 2ND GEAR WHEN A CAR DIDN'T SEE ME AND WAS COMING RIGHT AT ME. I ACCELERATED HARD WHILE LETTING THE CLUTCH OUT, AND INSTEAD OF IT GRABBING, IT SLIPPED! SO MY MOTORCYCLE JUST SAT THERE REVVING THE ENGINE AND BARELY MOVING BECAUSE THE CLUTCH WAS SLIPPING! THANK GOD THE ONCOMING CAR SLAMMED ON ITS BRAKES AT THE LAST MINUTE AND BARELY MISSED ME. THIS IS A VERY DANGEROUS PROBLEM WITH THE A&S CLUTCH HARLEY HAS IN MY CVO HARLEY.
TRANSMISSION SHIFTING HARD AND LOUD SHIFTING BETWEEN SOME OF THE GEARS IS EXTREMELY HARSH AND LOUD AND CAN BE FELT THROUGH THE WHOLE BIKE, FROM MY HANDS ON THE HANDLEBARS TO MY FEET ON THE FLOORBOARDS! IT FEELS LIKE A HAMMER HITTING THE TRANSMISSION WHETHER IT IS AN UPSHIFT OR A DOWNSHIFT. IT FEELS LIKE THE TRANSMISSION COULD SHATTER THE NEXT TIME I SHIFT AND POSSIBLY FAIL ME SOMETIME I WILL NEED IT THE MOST IN THE MIDDLE OF TRAFFIC AND CAUSE ME TO GET IN A CAR ACCIDENT!
Too few reports in this category for a page of its own — they appear in the full complaint list.
Electrical
Reports naming the electrical system — wiring, battery, charging, control modules, infotainment and electrical accessories.
From owner reports, verbatim
THE SPARK PLUG WIRE FOR THE FRONT CYLINDER RUBS AGAINST THE FUEL TANK WEARING THE PROTECTIVE SHEATH AROUND THE SPARK PLUG WIRE. PROLONGED RUBBING WILL WEAR A HOLE IN THE SHEATHING AND CAUSE AN ELECTRICAL SHORT AGAINST THE FUEL TANK OR ENGINE STUMBLE. MOTORCYCLE HAS LESS THAN 8100 MILES ON IT AND VEHICLE HAS NOT BEEN MODIFIED TO CAUSE THE RUBBING. THIS PROBLEM IS WIDESPREAD ACROSS ALL 2014-2016 HARLEY DAVIDSON TOURING SERIES MOTORCYCLES, BOTH OF MY NEIGHBORS 2015 AND 2016 MOTORCYCLES HAVE THE SAME ISSUE.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .