RoadVitals

2018 Harley-Davidson Fxlr Owner Complaints

Reports submitted to NHTSA by owners and drivers, shown in full

Data refreshed

Complaints on fileComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
2
Latest May 13, 2019
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
0
Filed in the last 12 monthsReports filed with NHTSA in the trailing 365 days. Recent volume reflects attention and vehicle age as much as anything else.
0
Reports on file since May 7, 2019

What this page shows

Our database holds 2 NHTSA owner-reported complaints for the 2018 Harley-Davidson Fxlr. Each one is a report filed by an owner or driver and published by NHTSA without most of them being verified. A complaint is not a confirmed defect, not a recall and not a manufacturer bulletin. Narratives are shown exactly as filed.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

Complaints, most recent first

Showing 1–2 of 2

Fuel system
Filed May 13, 2019

LIQUID GASOLINE EXPELS FROM FUEL TANK OVERPRESSURE VENT TUBE, AT A RATE >5 DROPS/SEC, ANYTIME WHEN THE ENGINE IS RUNNING AND THE TANK IS AT OR BELOW 1/2. DEALER WARRANTY REPAIR, 2ND ATTEMPT, SOLUTION WAS TO REVERSE THE VENT LINE CHECK VALVE SO THE FUEL LEAK OUTFLOW STOPPED BUT NOW THE FUEL TANK BUILDS CONSIDERABLE PRESSURE WITH AMBIENT OR OTHER TEMPERATURE RISES LEAVING THE ONLY VENT PATH AS THE GAS CAP REMOVAL. VIDEO AVAILABLE OF BOTH FUEL LEAK AND FUEL TANK PRESSURE RELIEF. THE FUEL LEAK ISSUE WAS FIRST NOTICED ON 07/09/2018; HOWEVER IT WAS NOT RECOGNIZED TO BE A CONSTANT ISSUE AS THE FUEL TANK WAS NORMALLY KEPT BETWEEN FULL AND 5/8 DUE TO COMMUTE PATTERN. ON 04/07/2019 IT WAS NOTICED AGAIN AND VIDEO OF THE FUEL EXPELLING WAS CAPTURED AND SENT TO DEALER ALONG WITH OBSERVATION OF 1/2 TANK OR BELOW REQUIREMENT FOR THE FUEL LEAK TO OCCUR. THE FUEL TANK OVERPRESSURE ISSUE WAS REALIZED AFTER 05/03/2019 AND VERIFIED SEVERAL TIMES SINCE.

NHTSA ID
11207346
Incident
May 11, 2019
Mileage
3,000 mi
BrakesElectricalEngine
Filed May 7, 2019

FOR SOME REASON THE FUEL CAP VIBRATES QUITE LOUD AT CURTAIN RPM. I ALSO HAD ISSUES WITH THE BRAKES. THE REAR BRAKE WAS SQUEALING A LOT AND AT ONE POINT MY FRONT BRAKE WAS GOING SOFT ON ME. THE FIRST TIME I HAD IT IN THERE FOR THAT REASON THEY CALLED ME THE NEXT DAY AND TOLD ME THAT THEY DIDN'T HEAR ANYTHING, THE BRAKES OF THE CAP. OF COURSE I WAS NOT HAPPY WITH THIS AND TOOK IT BACK THE FOLLOWING WEEK. THIS TIME THEY SAID THE SAME THING, THAT IT COULD BE HEARD AND NOTHING IS WRONG WITH THE BIKE. AFTER THAT I CONTACTED HARLEY DIRECTLY AND WITHIN 2 HOUR RECEIVED A CALL FROM ROMMEL HARLEY AND ALL OF A SUDDEN IT TURNS OUT THAT THE PART NUMBER AS MY GAS CAP WAS FOUND TO BE DEFECTIVE AND THE NEW MODEL WAS ORDERED, ALSO THEY BROKE MY BRAKES DOWN TO PIECES TO FULLY INSPECT THEM AND HAND FILE THEM. THE ISSUE WITH THE FRONT AND REAR BRAKES ARE BETTER BUT I CAN TOLERATE IT, AS FOR THE GAS CAP IT STILL IS DOING THE SAME THING. WHEN I CONTACTED THEM I WAS TOLD NOTHING MORE CAN BE DONE SO AGAIN I CONTACTED HARLEY DIRECTLY AND ASKED WHAT COULD BE DONE. THEY CALLED ROMMEL AND SPOKE WITH THEY. I WAS CALLED BACK AND INFORMED THAT NOTHING WOULD BE DONE AND I HAD TO DEAL WITH IT BECAUSE ROMMEL SAID NOTHING WAS WRONG. ALSO HAD THE CHECK ENGINE LIGHT CAME ON. CODES P1510H P2127H P2138H. REDUCED POWER MODE ALONG WITH RANDOM THROTTLE FROM ALMOST STALLING TO THE BIKE DECIDE TO GIVE ITSELF FULL GO REQUIRING EITHER TAKING THE BIKE OUT OF GEAR OR PULLING THE CLUTCH IN. NOTHING WAS DONE BECAUSE "WE NEED TO SEE IT HAPPEN". ERROR CODES WE'RE STILL STORED AND COULD BE READ. NOT SURE IF YOU'RE FAMILIAR WITH MOTORCYCLES BUT WHEN YOU'RE GOING DOWN THE HIGHWAY AND IT DECIDED TO GO FULL THROTTLE IT'S QUITE A SCARY THING ESPECIALLY BECAUSE IT'S QUITE HARD IF NOT IMPOSSIBLE TO SHIFT IN THAT SITUATION.

NHTSA ID
11205934
Incident
Dec 11, 2018
Mileage
2,500 mi

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.

Data sources

Data on this page last refreshed .