2009 Honda Accord Brakes Problems

I installed (2) identical Advance Auto Parts Platinum rear brake rotors on my vehicle. Both rotors were installed at the same time, in the same manner, and under normal conditions. After approximately (1) mile of normal driving on of the rear brake rotors catastrophically failed by completely separating at the hat (the center mounting section). The opposite side rear rotor, installed at the same time, did not fail. The failure occurred without warning and resulted in immediate loss of braking integrity at that wheel. This type of structural failure presents a significant safety risk, including the potential for sudden brake loss, wheel lockup, or loss of vehicle control. The vehicle was not being driven aggressively, and there were no abnormal conditions prior to the failure. The failed rotor has been preserved and is available for inspection. Photographs documenting the separation are also available. A brake rotor should not experience complete structural separation under normal driving conditions, especially immediately after installation. This appears to be a manufacturing or material defect that poses a serious safety hazard. I am submitting this complaint to document the defect and to help prevent potential injury or accidents involving similar components.

NHTSA ID

11710545

Incident

Jan 11, 2026

The contact owns a 2009 Honda Accord. The contact stated that the vehicle had been taken for an alignment. While performing the alignment, the parking brake activated independently. After the service was completed, the contact disengaged the parking brake and noticed that the vehicle seemed a bit more difficult than normal to steer. The contact pulled over, stopped, and became aware that the rear rotors were overheated and turning red. The contact stated that the parking brake was still activated even though the instrument panel had indicated that the parking brake was disengaged. The contact turned off the vehicle until the vehicle had cooled off and then returned home with the vehicle. Once the contact was home and the vehicle was parked, the contact noticed that the parking brake was still engaged even after disengaging the parking brake. The contact stated that the brakes were still overheated. The contact also noticed that the brake pads had started to fracture from the overheating. There were no warning lights illuminated. The contact had not taken the vehicle to the dealer. The vehicle had not been diagnosed or repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 128,000.

NHTSA ID

11482408

Incident

Jul 1, 2022

Mileage

128,000 mi

HAVE HAD THE CAR FOR SEVERAL YEARS AND HAVE TAKEN IT IN FOR INSPECTIONS OF THE BRAKING SYSTEM WHICH CAME BACK WITH NO ISSUES. REPORTED TO OWNER/CEO OF COMPANY AS WELL. BRAKES DO NOT WORK WHEN USED IN AN EMERGENCY. THE PEDAL WILL GO TO THE FLOOR BUT THE CAR WILL NOT STOP EVEN AFTER PUNCHING THE BRAKES SEVERAL TIMES. WORSE WHEN ON A DECLINE OF A HILL. I HAVE HAD THE BRAKES REDONE AND THE PROBLEM STILL PERSISTED AND ENDED UP IN AN ACCIDENT DUE TO THE FAULTINESS OF THE BRAKING SYSTEM. I'M GLAD IT WASN'T WORSE THAN IT WAS BUT THERE HAVE BEEN A LOT OF CLOSE CALLS. *TR

NHTSA ID

11327521

Incident

May 2, 2019

REAR BRAKES DEFECTIVE-SINCE JUNE 2014 HAVE HAD 5 CALIFERS, 4 ROTORS, 2 SETSOF PADS REPLACED. CAR HAS TOTAL OF 73000 MILES ON IT. ALL REPLACEMENTS BY HONDA. BRAKES HAVE FROZEN UP, GOT WHEELS SO HOT THEY SMOKED, COULD NOT TOUCH, PADS WOULD NOT RELEASE WHILE DRIVING COULD HEAR THEM RUBBING AGAINST ROTORS, PARKED CAR IN GARAGE AND COULD NOT GET IT TO MOVE NEXT DAY, SET PARKING BRAKE AND FLUID LEAKED NOT SURE BUT AT TIMES REAR BRAKES DID NOT SEEM TO WORK WHEN BRAKES RAPIDLY APPLIED, ALL REPAIRS SEEM TO BE ONLY TEMPORARY I HAD A LETTER FROM HONDA SHORTLY AFTER BUYING THE NEW CAR ASKING ME TO BRING CAR IN FOR BRAKE INSPECTION-DID SO- TOLD LETTER DID NOT APPLY TO ME-BRAKES FINE. HAVE COMPLAINED TO TWO DEALERS AND MADE FORMAL COMPLAINT TO HONDA---STONEWALLED

NHTSA ID

11290701

Incident

Dec 15, 2009

COULDN'T GET TRACTION ON LIGHT SNOW-COVERED ROAD. VSA LIGHT WAS FLASHING AND MY CAR WASN'T RESPONDING TO BRAKE TO VSA. I APPLIED MY BRAKES TO SLOW DOWN (TO NO AVAIL). NOW MY CAR IS OUT OF CONTROL AND PROCEEDING DOWN A SLIGHT INCLINE TO A STOP SIGN...PICKING UP SPEED ALONG THE WAY.MY BRAKES ARE "TO THE FLOOR" THE WHOLE TIME AS I SLIDE THROUGH INTERSECTION I HAVE MY STEERING WHEEL TURNED RIGHT. THE FRONT PASSENGER SIDE ENDED UP CRASHING INTO A STREET SIGN & TELEPHONE POLE. I WAS TOLD BY POLICE THAT A CAR THAT SWERVED TO AVOID ME MADE CONTACT WITH MY REAR FENDER AND MY CAR THEN SPUN RIGHT INTO THE POLES. ALSO, NEITHER FRONT AIR BAGS DEPLOYED UPON IMPACT

NHTSA ID

11169894

Incident

Jan 9, 2019

Mileage

67,000 mi

PREMATURE FAILURE OF REAR BRAKE PADS AND ROTORS @40K MILES. JUST OUTSIDE LIMITS OF HONDA BRAKE SETTLEMENT. REAR BRAKES FAILED AGAIN AT 100K WITH PADS, ROTORS, AND 1 CALIPER NEEDING REPLACEMENT.

NHTSA ID

11063714

Incident

Jan 25, 2013

Mileage

39,855 mi

2009 HONDA ACCORD. CONSUMER WRITES IN REGARDS TO MALFUNCTIONING CALIPER PISTON. *LD *JS

NHTSA ID

11053208

Incident

Aug 1, 2016

I BOUGHT CAR CPO AND REAR PADS WERE SUPPOSED TO BE NEW. A YEAR LATER, I STARTED HAVING PROBLEMS WITH MY REAR BRAKE PADS (HIGH PITCH NOISE, BURNT SMELL). TOOK IT TO A DEALERSHIP. THEY CHARGED ME OVER $160.00 FOR CLEANING AND LUBRICATING. A MONTH AND A HALF LATER - THE SAME PROBLEM APPEARS AGAIN. TOOK IT TO A LOCAL MECHANIC. I WAS CHARGED $220 FOR CLEANING, LUBRICATING AND NEW BRAKE PADS REPLACEMENT. TWO AND A HALF YEARS LATER, STARTED HAVING PROBLEMS AGAIN. RUSTED REAR ROTORS, 20% LEFT OF THE REAR PADS. ALL NEEDS A REPLACEMENT - $350.00 BILL. I HAD PUT A LITTLE LESS THAN 20K MILES FOR THE PAST TWO AND A HALF YEARS. FRONT BRAKES HAVEN'T HAD AN ISSUE AND ARE STILL USABLE. IT APPEARS THAT I AM NOT ALONE AND A LOT OF OWNERS OF THE SAME MAKE AND MODEL REPORT THE SAME ISSUES. THIS IS SO RIDICULOUS. I WOULD LIKE HONDA TO ACKNOWLEDGE BAD DESIGN AND REPLACE IT IN THE VEHICLE ALTOGETHER.

NHTSA ID

11023466

Incident

Sep 14, 2017

Mileage

89,343 mi

THE BRAKES PADS ON MY 2009 HONDA ACCORD LX ARE WEARING OUT EXPECTIONALLY FAST. EVERY 6 MONTHS. THERE IS A LAWSUIT PENDING AGAINST HONDA FOR FIX. I WANT TO JOIN THE CLASS ACTION LAWSUIT DUE TO HONDA SELLING ME A DEFECTIVE PRODUCT.

NHTSA ID

10995800

Incident

May 28, 2017

Mileage

115,000 mi

TL* THE CONTACT OWNS A 2009 HONDA ACCORD. WHILE DRIVING VARIOUS SPEEDS, THERE WAS A KNOCKING NOISE COMING FROM THE REAR OF THE VEHICLE. WHEN THE BRAKE PEDAL WAS DEPRESSED, THE CONTACT NOTICED SMOKE COMING FROM THE REAR OF THE VEHICLE. THE CONTACT PULLED INTO THE DRIVEWAY AND NOTICED THAT THE CALIPER WAS RUBBING TOGETHER. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 80,000. THE VIN WAS NOT AVAILABLE.

NHTSA ID

10955057

Incident

Nov 2, 2016

Mileage

80,000 mi

TL* THE CONTACT OWNS A 2009 HONDA ACCORD. WHILE DRIVING 65 MPH WITH THE CRUISE CONTROL ACTIVATED, THE VEHICLE ACCELERATED WHEN THE BRAKE PEDAL WAS DEPRESSED. THE CONTACT HAD TO PLACE THE GEAR INTO NEUTRAL AND DEPRESS THE BRAKE PEDAL IN ORDER FOR THE BRAKES TO OPERATE. IN ADDITION, WHILE THE VEHICLE WAS IN PARK, THE ENGINE CONTINUE TO ACCELERATE. THE CONTACT HAD TO TURN THE ENGINE OFF TWICE IN ORDER TO RESUME DRIVING. THE FAILURE RECURRED TWICE. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 160,631. UPDATED 10/21/16*LJ *TR

NHTSA ID

10899643

Incident

Aug 30, 2016

Mileage

160,631 mi

LAST WEEK I HEARD A RUBBING/SCRAPING NOISE COMING FROM THE RIGHT REAR OF MY 2009 HONDA ACCORD. TODAY I TOOK IT TO THE DEALERS AND HAD TO HAVE THE RIGHT REAR CALIPER REPLACED, NEW BRAKE PADS AND NEW ROTORS. THIS VEHICLE IS WELL TAKEN CARE OF AND IS GARAGE KEPT. I DO NOT UNDERSTAND WHY I NEEDED NEW BRAKES AND ROTORS AS MY CAR HAS APPROXIMATELY 22,000 MILES ON IT. I AM EXTREMELY UPSET BY THIS.

NHTSA ID

10886268

Incident

Jul 11, 2016

Mileage

22,000 mi

VEHICLE IN MOTION TURNING RIGHT INTO PARKING SPACE. BRAKES APPLIED, VEHICLE ACCELERATED INTO BRICK POST CAUSING SIGNIFICANT DAMAGE TO FRONT END OF VEHICLE AND POST. SECOND INCIDENT VEHICLE IN MOTION TURNING RIGHT INTO PARKING SPACE. BRAKES APPLIED, VEHICLE ACCELERATED INTO GRASSY STRIP. VEHICLE DIFFICULT TO BRING TO STOP.

NHTSA ID

10864873

Incident

Dec 3, 2015

Mileage

70,000 mi

TL* THE CONTACT OWNS A 2009 HONDA ACCORD. WHILE DRIVING APPROXIMATELY 60 MPH, THE VEHICLE INDEPENDENTLY ACCELERATED ABOVE 100 MPH FOR TWO MILES OR LONGER. THE CONTACT APPLIED BOTH FEET ON THE BRAKE PEDAL. THE VEHICLE SHOOK AGGRESSIVELY AND CONTINUED TO INCREASE IN SPEED. THE CONTACT WAS ALONE ON THE ROAD AND NOTICED THAT THE BRAKE PEDAL WENT TO THE FLOOR BUT DID NOT SLOW DOWN THE VEHICLE. THE CONTACT WAS ABLE TO CHANGE GEARS TO NEUTRAL. THE VEHICLE MADE A LOUD ABNORMAL NOISE AND WAS ABLE TO GRADUALLY DECELERATE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN WAS UNKNOWN. THE APPROXIMATE FAILURE MILEAGE WAS 37,000.

NHTSA ID

10838602

Incident

Feb 25, 2016

Mileage

37,000 mi

I BOUGHT MY CAR IN 2012. FROM 2013-PRESENT, I'VE HAD TO REPLACE MY BRAKES AND ROTORS AT LEAST 10 TIMES AND NOW I'M BEING TOLD MY CALIPERS NEED TO BE REPLACED. THERE IS NO WAY THAT I SHOULD HAVE TO REPLACE MY BRAKES THAT MANY TIMES. IN THE LAST YEAR ALONE, I'VE HAD TO REPLACE MY BRAKES AND ROTORS 3 TIMES. I CURRENTLY HAVE TO REPLACE MY REAR BRAKE PADS AND ROTORS WHEN I LAST DID IT 3 OR 4 MONTHS AGO. I DON'T HAVE THE MONEY TO KEEP FIXING THIS PROBLEM, HONDA SHOULD BE RESPONSIBLE! ALSO IN JULY 2015, MY AC/HEATER STOPPED WORKING, WE THOUGHT IT WAS THE FUSE, SO WE REPLACED IT BUT ITS STILL NOT WORKING. I AM VERY FRUSTRATED AND UPSET WITH THE PROBLEMS WITH MY CAR, I WILL NEVER BUY ANOTHER HONDA! I HAVE NEVER HAD THIS PROBLEM WITH ANY CAR THAT I'VE OWNED.

NHTSA ID

10810522

Incident

Jan 1, 2013

I AM THE ORIGINAL OWNER OF MY HONDA ACCORD, AND USE MY CAR PRIMARILY FOR PLEASURE DRIVING ON WEEKENDS AND HOLIDAYS. RECENTLY, I TOOK MY CAR TO MY LOCAL SERVICE STATION FOR AN OIL CHANGE AND SAFETY CHECK, AND WAS INFORMED THAT THE REAR DISC BRAKES WERE COMPLETELY WORN AND NEEDED REPLACEMENT, WHEREAS THE FRONT DISC BRAKE LININGS WERE FINE. THIS INFORMATION CAME AS A SURPRISE BECAUSE REAR ARE GENERALLY LAST MORE THAN 70,000- 1000,000 MILES, AND CERTAINLY LONGER THE THAN THE FRONT PADS. THE SERVICE STATION ATTENDANT TOLD ME THAT PREMATURE WEAR ON REAR BRAKE PADS IS A WELL- APPRECIATED DEFECT FOR THE 2009 ACCORD, AND HONDA IS AWARE OF THE PROBLEM AND HAS EVEN SETTLED A CLASS ACTION SUIT IN 2010 RELATING SPECIFICALLY TO THIS MATTER. FOR REFERENCE, A LINK TO A NEW YORK TIMES ARTICLE IS: HTTP://WHEELS.BLOGS.NYTIMES.COM/2010/04/06/HONDA-SETTLES-CLASS-ACTION-SUIT-OVER-BRAKES/?_R=0 SOUND BRAKES ARE NECESSARY FOR VEHICLE SAFETY. I REQUEST THAT THE NTSB DEMAND HONDA ISSUE A RECALL TO REPAIR THE BRAKE DEFECT FOR ACCORD OWNERS WHO WERE UNABLE TO TAKE ADVANTAGE OF THE CLASS SETTLEMENT. THANK YOU FOR YOUR KIND CONSIDERATION OF THIS REQUEST. *TR

NHTSA ID

10747909

Incident

Jul 3, 2015

Mileage

36,800 mi

FROM THE BEGINNING UPON TAKING DELIVERY OF THE VEHICLE, THE REAR BRAKE CALIPERS WERE NOT RELEASING PROPERLY. WE NOTICED A BURNING SMELL ONCE AFTER DRIVING, BUT NO WARNING LIGHTS WERE ON. WE ALSO NOTICED THE EMERGENCY BRAKE WAS NOT ALWAYS RELEASING, AS PER THE WARNING LIGHT. AT A ROUTINE OIL SERVICE IT WAS DETERMINED THAT RIGHT REAR CALIPER WAS NOT FULL DISENGAGING. THE ENTIRE REAR BRAKE ASSEMBLY HAD TO BE CLEANED AND ADJUSTED, THE REAR BRAKE PADS AND ROTORS HAD TO BE REPLACED. BOTH REAR CALIPERS HAD TO BE REPLACED. IN THE PAST, OUR VEHICLES HAVE GONE 90,000 MILES BEFORE REPLACING ONLY THE PADS, AND THEN ONLY THE FRONT. TO REPLACE AN ENTIRE REAR BAKE ASSEMBLY INDICATES SOME SORT OF DEFECT OR ENGINEERING PROBLEM. MA 07/30/15 UPDATED 10/23/2017*CN

NHTSA ID

10725673

Incident

May 12, 2015

Mileage

53,744 mi

2009 HONDA ACCORD EX V6 HAS NUMEROUS PROBLEMS AT 130K...MOST ORIGINATING AT 70-90K. EXCESSIVE OIL CONSUMPTION (1 QT A WEEK)! ROUGH IDLE AND ACCELERATION, 6 LIGHTS LIT UP ON DASH, INCLUDING CHECK ENGINE...COMES ON AND OFF INTERMITTENTLY.....FOULED SPARK PLUGS, TICKING NOISE COMING FROM STEERING WHEEL WHEN TURNING, BRAKES MUST BE REPLACED EVERY 10K MILES, LOUD TICKING NOISE FROM ENGINE, POOR ACCELERATION WITH MISSING/SPUTTERING, SMOKE EMITS FROM TAILPIPES, VSC LIGHT STAYS ON ALONG WITH TPMS! THE LIST GOES ON AND ON...I HAVE BEEN LOYAL TO HONDA SINCE 1993 HAVING OWNED MANY, ESPECIALLY ACCORDS AND THIS ONE TAKES THE CAKE....THE WORST VEHICLE EVER OWNED! DO NOT BUY HONDA...THEY DO NOT CARE ABOUT YOU AND NEVER WILL! I MISSED THE CLASS ACTION LAWSUIT BY A COUPLE OF MONTHS ON THE ENGINE MISFIRE DEAL...JUST RECENTLY WAS MADE AWARE OF IT. NEVER AGAIN HONDA!!!!

NHTSA ID

10717752

Incident

Jan 1, 2013

Mileage

100,000 mi

REAR TIRES OVERHEATED TO THE POINT THAT IT WOULD BURN A HAND THAT TOUCHED IT ON 6-11-2012 (MILEAGE 46,384). SMELLED OF BURNING RUBBER. HAD TO REPLACE THE LEFT REAR BRAKE CALIPER, BRAKE PAD, AND ROTOR. ON 4-18-2013 (MILEAGE 65,922) THE SAME PROBLEM ON RIGHT REAR. THIS REQUIRED REPLACEMENT OF THE RIGHT REAR BRAKE PAD AND ROTOR. ON 6-13-2014 (MILEAGE 93,310) THE SAME OVERHEATING OCCURRED AND REQUIRED REPLACEMENT OF THE REAR BRAKE PADS. THE LATEST OCCURRENCE WAS ON 3-16-2015 (MILEAGE 112,411). WE HAVE AN APPOINTMENT TO HAVE THIS EXAMINED IN TWO DAYS SO DO NOT YET KNOW THE DIAGNOSIS. I AM VERY CONCERNED THAT THIS FAILURE COULD OCCUR WHILE WE ARE DRIVING AND COULD RESULT IN A FIRE, BLOWN TIRE, OR CRASH. *TR

NHTSA ID

10694440

Incident

Jun 11, 2012

Mileage

46,348 mi

I WAS DRIVING MY 2009 ACCORD ON MY SNOW COVERED STREET AND THE VEHICLE STABILITY (VSA) LIGHT FLASHED ON, AS IT SHOULD, WHEN THE VEHICLE LOSES TRACTION. HOWEVER, THE LIGHT STAYED ON AND THE ABS AND BRAKE LIGHTS BOTH APPEARED AS WELL AND ALL 3 STAYED LIT. AT FIRST, I THOUGHT THEY WOULD RESET, BUT AFTER A FEW DAYS, THEY DID NOT. THE VSA AND ANTI-LOCK BRAKE FUNCTIONS WERE NO LONGER WORKING. MY CAR WAS BROUGHT TO A LOCAL DEALERSHIP WHERE THEY PERFORMED A DIAGNOSTIC TEST AND BASED ON THE COMPUTER CODES, DETERMINED THAT THE ABS MODULATOR NEEDED TO BE REPLACED. THE COST FOR THIS REPAIR WAS OVER $1300! AT THAT TIME, I DECIDED NOT TO COMPLETE THE REPAIR BECAUSE I WANTED TO CALL AMERICAN HONDA TO SEE IF THEY COULD PROVIDE A DISCOUNT FOR THIS VERY IMPORTANT AND EXPENSIVE SAFETY COMPONENT. AFTER MORE THAN A WEEK, THEY DID FINALLY OFFER A DISCOUNT AND THE REPAIR WAS COMPLETED FOR $800. MY RESEARCH HAS INDICATED THAT THIS PART HAS HAD A HISTORY OF PROBLEMS IN SOME HONDA VEHICLES MANUFACTURED AROUND 2009. THE ABS MODULATOR SHOULD NOT HAVE FAILED ON MY HONDA ACCORD WITH SUCH LOW MILEAGE. I BELIEVE THAT IT MUST HAVE BEEN A MANUFACTURING DEFECT WITH 2009 HONDA VEHICLES. *TR

NHTSA ID

10691797

Incident

Feb 16, 2015

Mileage

48,164 mi

THE BRAKES SQUEAL. AS THE BRAKES HEAT UP THE NOISE GETS UNBEARABLE. *TR

NHTSA ID

10683666

Incident

Jan 22, 2015

Mileage

31,000 mi

REPLACED REAR BRAKES TWICE IN 15MONTHS WITH LESS THAN 15000 MILES ON CAR. *TR

NHTSA ID

10683072

Incident

Oct 14, 2013

I TOOK MY HONDA IN FOR A ROUTINE OIL CHANGE AND WAS TOLD THAT MY BRAKE PADS WHERE VERY LOW AND HAD TO BE REPLACED. I WAS SHOCKED TO FIND THIS OUT WITH ONLY 17,660 MILES ON THE CAR. THIS COULD HAVE BEEN A DANGEROUS PROBLEM AND OTHER OWNERS OF THIS MODEL SHOULD BE AWARE. *TR

NHTSA ID

10669539

Incident

Dec 31, 2014

Mileage

17,660 mi

TL* THE CONTACT OWNS A 2009 HONDA ACCORD. THE CONTACT STATED THAT WHILE MAKING A SLIGHT RIGHT TURN, THE STEERING WHEEL SEIZED. IN ADDITION, THE CONTACT STATED THAT THE BRAKES SEIZED AND THE VEHICLE VIOLENTLY JERKED FORWARD. AS A RESULT, THE CONTACT DROVE OVER A CURB AND CRASHED INTO A STOP SIGN AND A GRAVEL ROAD. A POLICE REPORT WAS NOT FILED AND THERE WERE NO INJURIES REPORTED. THE VEHICLE WAS TOWED TO A COLLISION CENTER. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 120,000.

NHTSA ID

10648203

Incident

Oct 12, 2014

Mileage

120,000 mi

TL* THE CONTACT OWNS A 2009 HONDA ACCORD. THE CONTACT INDICATED THAT THE REAR BRAKES BECAME WORN PREMATURELY. THE DEALER STATED THAT THE REAR BRAKE LINE AND REAR BRAKE PADS NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 15,000.

NHTSA ID

10641183

Incident

Jan 1, 2014

Mileage

15,000 mi