2025 Honda ADV160 Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2025 Honda ADV160, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Engine685.7%
- Fuel system114.3%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Engine
Reports naming the engine itself — including stalling, misfires, oil consumption, cooling and internal engine components.
From owner reports, verbatim
The contact owns a 2025 Honda ADV160. The contact stated that while riding approximately 20-25 MPH, the engine made an abnormal whining sound and the motorcycle stalled. No warning light was illuminated. The contact was able to pull over to the side of the road, and the motorcycle was towed to the residence. The motorcycle was later towed to the dealer, where it was diagnosed that a cylinder was damaged and the cylinder seal was fractured. The manufacturer was contacted and referred the contact to the dealer for assistance. The motorcycle was repaired out-of-pocket. The failure mileage was approximately 2,739.
The contact owns a 2025 Honda ADV160 Scooter. The contact stated that while riding at 30 MPH, there was an abnormally loud sound coming from the motorcycle. The scooter was pulled over to the shoulder of the road. The contact stated that while inspecting the scooter, there was oil leaking down the side of the scooter onto the ground. The scooter was taken to the dealer and repaired under NHTSA Campaign Number: 25V195000 (Engine and Engine Cooling); however, the failure reoccurred. The contact was advised to take the scooter back for an inspection. The manufacturer was made aware of the failure, and a case was filed. The contact was advised to take the scooter back to the dealer for assistance. The contact stated that the scooter was unsafe to ride because the drivetrain might fail while riding. The failure mileage was approximately 20.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Fuel system
Reports naming fuel storage or delivery — tanks, pumps, lines, injectors and fuel leaks.
From owner reports, verbatim
I’m filing a complaint regarding a serious safety recall on my 2025 Honda ADV160 (Recall #25V195), which involves a defective oil pump driven gear. This recall can lead to engine seizure and cause the rear wheel to lock, risking crash or injury. I’ve called multiple dealerships to get this resolved, but I’ve been told either the recall doesn’t exist or that I need to “wait for a letter in the mail” and that no parts are available. In the meantime, I’m forced to continue riding this vehicle, which is my daily transportation. This is unacceptable for a known safety issue. I’m concerned about the lack of urgency from Honda, the risk of being injured, and the fact that I am unable to safely operate a brand-new motorcycle I just purchased. I want this issue escalated please, and I’m seeking a solution as soon as possible. I am also considering filing under California lemon law if this continues to go unresolved.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .