2006 Honda Element Body & structure Problems

The check engine light indicated a "gas cap" code, and the "side airbag off" light was illuminated. Upon diagnosis, the technician identified significant rust and cracked transmission components, resulting in fluid leakage. The service department assessed the vehicle as unsafe for operation, waived the diagnostic fees, and replenished the transmission fluid to prevent the risk of being stranded due to a lack of fluid on the return trip. Honda Service Department took the attached photos and documented the vehicle's safety violations.

NHTSA ID

11632315

Incident

Dec 24, 2024

These cars have severe issues with their frames and they rot. There are TONS of recalls in Canada and I am wondering why the same recalls are not in the US - this is equally dangerous regardless of location - especially upstate NY where the climate is extremely similar to Canada. I have had TWO LIFE THREATENING INCIDENTS recently - one with the front axel completely breaking several months ago, and yesterday when the frame and rear axel fell apart. Fortunately both times, I was barely moving or I would likely not be here to be typing this. My frame is so rusted, it is disintegrating and beyond repair. I was advised by my local Sheriff to check on the recalls in Canada and there are so many, basically the whole frame is recalled - I am writing to report that I am in several Honda Element groups here in the US, and there are hundreds of life threatening posts in these groups regularly. This should absolutely be addressed. It is clearly a problem. As you can see in my attachments, otherwise the vehicle is in amazing condition. This is really devastating - and I have a vehicle that I cannot sell or trade-in. There is no value whatsoever and it is beyond repair.

NHTSA ID

11537675

Incident

Aug 9, 2023

The contact owns a 2006 Honda Element. The contact stated that while HIS son was driving approximately 55 MPH, the driver heard a loud clunking sound, and the rear of the vehicle suddenly became unstable. The driver stopped and inspected the vehicle, and it was discovered that the driver’s side rear wheel was turned outward, and the rear driver’s side trailing arm had detached from the frame of the vehicle due to severe rust. The vehicle was later towed to a welding shop. The vehicle was not yet repaired. The local dealer and manufacturer were notified of the failure, but no assistance was offered. The failure mileage was 123,000.

NHTSA ID

11527326

Incident

May 1, 2023

Mileage

123,000 mi

I AM LOCATED IN OHIO AND THE REAR TRAILING ARM HAS RUSTED OUT TO THE POINT THAT IT IS ON THE VERGE OF BREAKING OFF ON THE PASSENGER SIDE. THIS WAS FOUND OUT BECAUSE I WAS DRIVING AND THE CAR WOULD SWAY BACK AND FORTH IN THE REAR EVERY TIME I HIT A BUMP IN THE ROAD. I WENT TO MY NEAREST TIRE SHOP THINKING IT COULD BE A WHEEL ALIGNMENT ISSUE AND THEY BROUGHT ME TO THE BACK AND SHOWED ME THE ISSUE. IT IS BEING HELD BY ABOUT 4-5 INCHES OF THE FRAME. THEY ADVISED ME TO HAVE THE CAR TOWED AS IT WAS NOT SAFE FOR ME TO DRIVE HOME. I HAVE SINCE NOT BEEN DRIVING THE VEHICLE AND HAVE IT PARKED IN MY GARAGE. I'M AWARE THAT THIS IS A RECALL BY HONDA IN CANADA WHICH IS A NEIGHBORING BORDER TO MY STATE AND A VERY COMMON ISSUE WITH A LOT OF US NORTHERN STATES IN THE U.S. PLEASE ADVISE WHAT CAN BE DONE AS I LOVE THIS VEHICLE BUT IT IS UNSAFE TO DRIVE ON THE ROAD.

NHTSA ID

11403002

Incident

Jan 3, 2021

Mileage

163,000 mi

RIGHT BACK SEAT WINDOW BROKE

NHTSA ID

11217681

Incident

May 31, 2019

WE GOT A LETTER IN THE MAIL ABOUT THE RECALL ON THE AIRBAGS. AIR BAG LIGHT ALWAYS ON. WE HAVE A KNOCKING SOUND IN THE ENGINE ,THE DRIVER DOOR GETS STUCK, WE HAVE NO A/C , ONE FAN UNDER THE HOOD WORK,SHOCKS MISSING UP TIRES, BATTERY DIE ALL THE TIME, AND HAVE HAD PROBLEMS WITH THE CAR JUST CUTTING OFF AT LIGHTS OR WHEN STOPED BY ITSELF.

NHTSA ID

11129519

Incident

Jul 10, 2018

I HIT A DEER LAST DECEMBER AND THE ONLY REASON THE INSURANCE COMPANY DID NOT TOTAL IT WAS BECAUSE THE AIR BAGS DID NOT DEPLOY. THERE WAS JUST ABOUT $10,000 WORTH OF DAMAGE TO MY CAR. AFTER WAITING A MONTH AND A HALF, TRAVELING 18 HOURS & SPENDING AN EXTRA $200 FOR TRAVEL TO GO GET MY CAR I FINALLY GOT IT BACK. ALSO, MY CAR DOES NOT IDLE LIKE IT SHOULD. IT WILL ALSO GO DEAD WHEN I COME TO A STOP. IT DOESN'T HAPPEN ALL THE TIME BUT IT WILL HAPPEN IN THE MIDDLE OF TRAFFIC AND I WILL BE STUCK THERE FOR A FEW MINUTES. *TR

NHTSA ID

10606014

Incident

Dec 27, 2013

Mileage

96,000 mi

I WAS DRIVING APPROXIMATELY 25 MPH VEHICLE IN FRONT SUDDENLY STOPPED I REAR ENDED VEHICLE CAUSING DAMAGE TO FRONT BUMPER, HOOD AND DRIVER SIDE PANEL, THERE WAS NO INJURIES THANK GOD DRIVER AIR BAGS DID NOT DEPLOY ALSO PASSENGER ON REAR SIDE SEAT BELT SNAPPED THIS WAS MY SECOND FENDER BENDER IN THREE YEARS WHERE FRONT AIR BAGS DID NOT DEPLOY, THIS IS A MAJOR CONCERN BECAUSE MY FAMILY'S SAFETY IS MY PRIORITY AND HONDA SHOULD LOOK INTO THIS SERIOUSLY BEFORE MAJOR INJURIES OR DEATHS OCCURS. *TR

NHTSA ID

10543812

Incident

Sep 1, 2013

Mileage

161,000 mi

TL*THE CONTACT OWNS A 2006 HONDA ELEMENT. THE CONTACT STATED THAT THERE IS A HOLE IN THE VEHICLE'S DRIVER SIDE DOOR GASKET. THE DEALER HAS REPLACED THE GASKET. THE CURRENT MILEAGE IS 2,400 AND FAILURE MILEAGE WAS 1,500.

NHTSA ID

10190397

Incident

Sep 9, 2006

Mileage

1,500 mi

VEHICLE SUSTAINED MULTIPLE DENTS THROUGHOUT THE ROOF AND HOOD FROM "SIMPLE" ACORNS FALLING FROM A TREE. DAMAGE IS UNACCEPTABLE AND WAS BASICALLY TOLD BY HONDA MOTOR CORP. THAT I "SHOULDN'T" PARK UNDER TREES THAT DAMAGE MY CAR. THE CAR PARKED NEXT TO MINE SUSTAINED "NO" DAMAGE. NO OTHER CARS SEEM TO SUSTAIN THIS KIND OF DAMAGE. ABSOLUTELY UNACCEPTABLE STRUCTURAL "INTOLERANCE" ON THIS VEHICLE. MY SEVEN PREVIOUS CARS NEVER SUSTAINED "ANY" DAMAGE FROM ACORNS. I WOULD NEVER HAVE PURCHASED THIS VEHICLE, HAD I KNOWN IT HAD SUCH THIN METAL ON ITS EXTERIOR. I WAS LEFT HIGH & DRY BY HONDA CASE MANAGEMENT AS WELL AS BY HONDA OF DANBURY SERVICE DEPARTMENT. I AM VERY DISAPPOINTED WITH HOW THEY WERE UNWILLING TO HELP ME WITH MY SITUATION. *NM

NHTSA ID

10172773

Incident

Nov 6, 2006

DT*: THE CONTACT STATED THE INSTRUMENT PANEL ON THE VEHICLE WAS SET TOO FAR INTO THE DASH TO SEE THE GAUGES EFFECTIVELY DURING DAYLIGHT HOURS. THE MANUFACTURER WAS NOTIFIED, AND A CASE WAS OPENED. THE VEHICLE WAS NOT TAKEN IN FOR SERVICE. UPDATED 10/04/06. *JB

NHTSA ID

10166220

Incident

Aug 22, 2006

Mileage

8,079 mi