2025 Honda Pilot Visibility Problems

I am writing to formally report a potential safety-related defect involving the front windshield of my 2025 Honda Pilot. The windshield has demonstrated what I believe to be an abnormal susceptibility to cracking and chipping under what appear to be normal driving conditions, including ordinary interstate highway travel. The damage has occurred from relatively minor road debris and/or without a significant impact that would reasonably explain the severity or rapid progression of the cracking. I contacted Honda regarding this issue and requested assistance with the windshield repair/replacement as well as further investigation into whether there may be a defect involving the windshield glass, its installation, mounting, or related vehicle components. Honda declined to provide assistance or initiate any further investigation. My concern is not simply that windshield glass can occasionally be damaged by road debris. Rather, I am concerned that the windshield may be unusually susceptible to cracking under conditions that should reasonably be expected during normal operation of the vehicle. A windshield is a critical safety component, and repeated or unusually easy cracking could potentially affect driver visibility and the structural integrity of the windshield. I am also aware of other reported complaints involving windshield cracking on 2025 Honda Pilot vehicles. The existence of similar reports raises additional concern that this may not be an isolated incident and that the issue may warrant further investigation. I respectfully request that Honda: 1. Review the circumstances surrounding this windshield failure; 2. Determine whether similar windshield complaints have been reported for the 2025 Honda Pilot; 3. Investigate whether there may be a defect involving the windshield glass. Because the windshield is an essential safety component, I believe this matter deserves more than a determination that the damage is simply ordinary road debris.

NHTSA ID

11756542

Incident

Aug 3, 2026

When driving on the highway vehicle suddwnly brakes on its own when it detects cars on side lane not directly in front of me creating a noticeable slowdown being somewhat unsafe. The wiper blades dont come up they hit the hood of the car which i believe shouldnt be this way. The seatbelt sensors go off in back row even if no one unbuckles then the car starts making loud noise to let you know and a side unbuckled light comes on and also the x marking which seat but it continues making loud beeping noise that can cause distraction and even an accident i drove 45 minutes with it doing this to me on and off mostly on the only way to get it to stop is if someone doesnt sit on marked spot. So now i dont know if this will happen on all seats as for now its obly on the third row passenger right side seat. I have about 3 weeksnoticing this but it was less now its more so i made apptment to take im to get checked but the sound is very anboying and distracting

NHTSA ID

11748206

Incident

Jun 12, 2026

four cracked windshields while driving from debris hitting windsheild

NHTSA ID

11740152

Incident

May 26, 2026

I am reporting a safety-related driver visibility concern involving a 2025 Honda Pilot. I also observed substantially similar behavior on a 2026 Honda CR-V loaner vehicle and another Honda Pilot provided by Koons Honda. The issue involves the front driver and passenger windows and their interaction with the outer window seals/belt moldings. During rainy, snowy, foggy, or wet conditions, lowering and then raising the windows leaves significant moisture, streaking, fog residue, or debris on the glass surface. Current image shows fog residue, however, the same results occurred with snow where visibility was impaired after cycling the front driver and passenger windows. The outer window seals do not adequately clear the windows during normal operation. This results in impaired visibility around and through the side view mirrors, especially during lane changes, merging, and monitoring adjacent lanes. The condition is repeatable and occurs during ordinary use. I documented video evidence showing: •the issue on my 2025 Honda Pilot, •another Honda Pilot, •and the same/similar issue on a separate 2026 Honda CR-V loaner vehicle from Koons Honda. I presented the evidence to dealership personnel. However, the service manager refused to document that side mirror visibility was impaired, reportedly because such wording would imply a safety condition. This concern may involve: •ineffective window seal/belt molding performance, •excessive water retention on side windows, •impaired driver visibility, •and a potential safety defect affecting multiple Honda vehicles. The issue can create unsafe driving conditions because drivers may be unable to clearly observe adjacent traffic through side mirrors after operating the windows in wet conditions. Furthermore, similar reports are found online with different newer models. The date below reflects today's interaction with the dealership, however, this is an ongoing issue since we received the vehicle last year.

NHTSA ID

11739003

Incident

May 20, 2026

The contact owns a 2025 Honda Pilot. The contact stated that upon returning to the vehicle while the vehicle was parked and unoccupied, the sunroof front glass panel had shattered without impact. The contact was able to slowly drive to the residence. The contact then contacted a mobile auto glass technician who cleaned the vehicle and covered the sunroof with plastic. Additionally, the contact was informed that the sunroof glass panel was not available. The dealer was notified of the failure and informed the contact that the repair was not covered because the VIN was not under recall. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 7,350.

NHTSA ID

11730017

Incident

Apr 6, 2026

Mileage

7,350 mi

The contact owns a 2025 Honda Pilot. The contact stated that while driving approximately 65 MPH, there was an abnormally loud popping sound coming from the vehicle, and the sunroof glass shattered, and glass fell into the cabin. The contact was not hurt by the glass shards from the sunroof. The vehicle was taken to the local dealer, who repaired the sunroof. The contact was not provided a cause for the sunroof to shatter. The manufacturer was informed of the failure. The failure mileage was approximately 17,000.

NHTSA ID

11725486

Incident

Mar 5, 2026

Mileage

17,000 mi

The contact owns a 2025 Honda Pilot. The contact stated that the front windshield was cracked. The contact stated that a rock or stone had most likely hit the windshield. The vehicle was taken to the auto glass center, and the windshield was replaced. After the repair, the contact noticed that the windshield was cracked at its base. The contact noticed that the lower half of the windshield was cracked, and the crack expanded from one inch to three inches rapidly. The vehicle was taken to the auto glass center, where the contact was informed that the glass needed to be replaced. The vehicle was taken to the local dealer, who declined to take responsibility and referred the contact to the insurance company because the VIN was included in a related recall. The vehicle was not repaired. The manufacturer was not contacted. The failure mileage was approximately 5,000.

NHTSA ID

11707585

Incident

Mar 29, 2025

Mileage

5,000 mi

The rear windshield on our 2025 Honda Pilot spontaneously shattered. We have owned it approximately 2 months.

NHTSA ID

11703611

Incident

Nov 29, 2025

My 2025 Honda Pilot (purchased Oct 2024) has experienced three windshield cracks, all starting in the same lower driver-side corner near the inspection stickers. 1st crack – July 2025: A long horizontal crack appeared overnight while parked, with no impact point at all. Dealer claimed “impact damage” and refused warranty. 2nd crack – August 2025: After paying for an OEM replacement and Honda Sensing calibration, the new windshield cracked on the drive home from a very small road debris impact. The star-shaped crack spread rapidly to the edge. Glass shop staff informally said the first crack looked like a stress crack. They replaced the glass again with OEM and calibrated, offering their labor for free. Dealer declined to pay even for only glass itself and told us to talk to Honda USA. We contacted Honda USA by phone, received a case number, and were told to “deal with the dealer.” The dealer then told us to contact Honda USA again. Neither party investigated, and both said the windshield is “not covered.” 3rd crack – November 2025: A tiny debris impact again caused a crack in the same exact corner. The impact chip was extremely small, but the crack still spread more than normal. All photos attached with repair invoices. We paid out of pocket as our insurance does not cover OEM glass. The repeated cracking in the identical corner, including one with no impact, suggests a possible structural stress point, mounting issue, or overly thin/brittle OEM glass. I also found another NHTSA complaint from June 2024 reporting similar cracking on a 2025 Pilot. These repeated failures pose a visibility and safety risk on a new vehicle.

NHTSA ID

11700497

Incident

Jul 23, 2025

The rear view mirror popped off the base. Result is driving without rear view mirror until repaired. This is a faulty design with the mirror hex base attached to the windshield and the mirror neck having a spring clip.

NHTSA ID

11661260

Incident

May 13, 2025

Ripples in windshield cause distortion when viewing the road. This is only present in the passenger side on my vehicle.

NHTSA ID

11613677

Incident

Sep 1, 2024

Poor back-up camera resolution at night. Almost hit pedestrian due to poor visibility from camera

NHTSA ID

11612401

Incident

Sep 1, 2024

My Honda Pilot 2025 vehicle's windshield cracked while driving on the interstate. The crack is on the driver side of the windshield, about 6 inches from the top.The crack begins as a single straight line before branching out into another curving line in the letter "L" shape. A passing vehicle kicked up rock or debris, which formed the crack. There was no collision or major impact on the vehicle. The vehicle was inspected by the manufacturer, but they were unable to assist me in any way because they did not have any windshields available or would be created in the near future for this vehicle. Recognizing the signs of poor-quality windshield, I believe the windshield quality was compromised to its structural integrity. I see it as very major issue in terms of the safety of the driver and passengers.

NHTSA ID

11592458

Incident

May 30, 2024