2006 Honda VFR800 Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2006 Honda VFR800, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Fuel system342.9%
- Electrical228.6%
- Engine228.6%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Fuel system
Reports naming fuel storage or delivery — tanks, pumps, lines, injectors and fuel leaks.
From owner reports, verbatim
MY MOTORCYCLE ENGINE STOPPED OPERATING FOUR TIMES, TWICE IN TRAFFIC AND I WAS UNABLE TO RESTART THE ENGINE. I COULD NOT RESTART THE ENGINE UNTIL I PLAYED WITH FUSES, AND NOTICED MAIN FUSE B (FUEL INJECTION SYSTEM) WAS EXTREMELY HOT. ONCE HOME, I NOTICED THAT THE WIRE COMING OUT OF MAIN FUSE B WAS SMALLER GAUGE THAN THE WIRE IT WAS CONNECTED TO, AND IT WAS BAKED FROM OVER HEATING SO BAD IT WAS TURNED BROWN WITH A TAN STRIPE INSTEAD OF RED WITH WHITE STRIP IT WAS SUPPOSED TO BE.
DRIVING DOWN STATE ROAD DOING APPROX 40 MPH WHEN BIKE SUDDENLY LOST POWER AND DIED. PULLED OVER AND AFTER A FEW ATTEMPTS IT RESTARTED. THIS HAPPENED 3 MORE TIMES IN MY 14 MILE COMMUTE TO WORK AT VARIOUS SPEEDS INCLUDING ONCE WHEN TURNING ACROSS TRAFFIC. AFTER FINDING A AFE PARKING LOT I DISCOVERED MY MAIN FUSE AND WIRES HAD MELTED AND WAS DAMAGED. MY STARTER RELAY CONNECTION WAS ALSO MELTED. THIS WAS A KNOWN FLAW FOR THESE BIKES AND HONDA HAS IGNORED THIS SAFETY ISSUE.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Electrical
Reports naming the electrical system — wiring, battery, charging, control modules, infotainment and electrical accessories.
From owner reports, verbatim
MY MOTORCYCLE ENGINE STOPPED OPERATING FOUR TIMES, TWICE IN TRAFFIC AND I WAS UNABLE TO RESTART THE ENGINE. I COULD NOT RESTART THE ENGINE UNTIL I PLAYED WITH FUSES, AND NOTICED MAIN FUSE B (FUEL INJECTION SYSTEM) WAS EXTREMELY HOT. ONCE HOME, I NOTICED THAT THE WIRE COMING OUT OF MAIN FUSE B WAS SMALLER GAUGE THAN THE WIRE IT WAS CONNECTED TO, AND IT WAS BAKED FROM OVER HEATING SO BAD IT WAS TURNED BROWN WITH A TAN STRIPE INSTEAD OF RED WITH WHITE STRIP IT WAS SUPPOSED TO BE.
DRIVING DOWN STATE ROAD DOING APPROX 40 MPH WHEN BIKE SUDDENLY LOST POWER AND DIED. PULLED OVER AND AFTER A FEW ATTEMPTS IT RESTARTED. THIS HAPPENED 3 MORE TIMES IN MY 14 MILE COMMUTE TO WORK AT VARIOUS SPEEDS INCLUDING ONCE WHEN TURNING ACROSS TRAFFIC. AFTER FINDING A AFE PARKING LOT I DISCOVERED MY MAIN FUSE AND WIRES HAD MELTED AND WAS DAMAGED. MY STARTER RELAY CONNECTION WAS ALSO MELTED. THIS WAS A KNOWN FLAW FOR THESE BIKES AND HONDA HAS IGNORED THIS SAFETY ISSUE.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Engine
Reports naming the engine itself — including stalling, misfires, oil consumption, cooling and internal engine components.
From owner reports, verbatim
MY MOTORCYCLE ENGINE STOPPED OPERATING FOUR TIMES, TWICE IN TRAFFIC AND I WAS UNABLE TO RESTART THE ENGINE. I COULD NOT RESTART THE ENGINE UNTIL I PLAYED WITH FUSES, AND NOTICED MAIN FUSE B (FUEL INJECTION SYSTEM) WAS EXTREMELY HOT. ONCE HOME, I NOTICED THAT THE WIRE COMING OUT OF MAIN FUSE B WAS SMALLER GAUGE THAN THE WIRE IT WAS CONNECTED TO, AND IT WAS BAKED FROM OVER HEATING SO BAD IT WAS TURNED BROWN WITH A TAN STRIPE INSTEAD OF RED WITH WHITE STRIP IT WAS SUPPOSED TO BE.
DRIVING DOWN STATE ROAD DOING APPROX 40 MPH WHEN BIKE SUDDENLY LOST POWER AND DIED. PULLED OVER AND AFTER A FEW ATTEMPTS IT RESTARTED. THIS HAPPENED 3 MORE TIMES IN MY 14 MILE COMMUTE TO WORK AT VARIOUS SPEEDS INCLUDING ONCE WHEN TURNING ACROSS TRAFFIC. AFTER FINDING A AFE PARKING LOT I DISCOVERED MY MAIN FUSE AND WIRES HAD MELTED AND WAS DAMAGED. MY STARTER RELAY CONNECTION WAS ALSO MELTED. THIS WAS A KNOWN FLAW FOR THESE BIKES AND HONDA HAS IGNORED THIS SAFETY ISSUE.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .