1990 Hyundai Excel Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 1990 Hyundai Excel, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Engine816.3%
- Electrical816.3%
- Fuel system510.2%
- Transmission510.2%
- Visibility48.2%
- Other / unspecified36.1%
- Interior & seats24.1%
- Brakes24.1%
- Heating & air conditioning24.1%
- Driver assistance24.1%
- Powertrain (other)24.1%
- Suspension24.1%
- Body & structure12.0%
- Tires & wheels12.0%
- Airbags12.0%
- Seat belts12.0%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Engine
Reports naming the engine itself — including stalling, misfires, oil consumption, cooling and internal engine components.
From owner reports, verbatim
ENGINE SPUTTERED, STOPPED RUNNING, CAUGHT FIRE. *AK
WHILE PROCEEDING UP A SLIGHT INCLINE DURING THE COMMUTING HOUR, THE CAR LOST ALL POWER AND I CAME CLOSE TO BEING HIT IN THE REAR. AFTER ABOUT 30 SECONDS I REGAINED SOME POWER AND WAS ABLE TO PROCEED. THE CAR WAS IDLING ROUGH AND I HAD TO KEEP MY FOOT ON THE ACCELERATOR AT ALL TIMES TO KEEP IT RUNNING. I HAD IT TURNED UP AND IT RAN BETTER BUT STILL A LACK OF POWER. I HAD TO HAVE IT INSPECTED AND IT FAILED INSPECTION BECAUSE THE POLLUTION WAS AT 1200. I THEN HAD IT TUNED UP AGAIN (FULLY) AND IT FAILED AGAIN. I HAD IT CHECKED OUT AT A STATION AND FOUND OUT THAT CYLINDER 3 DID NOT HAVE ANY PRESSURE AT ALL. I ALSO FOUND OUT THAT TO GET IT FIXED IT WOULD COST AROUND $1,000. IT STILL IS NOT FIXED.
Electrical
Reports naming the electrical system — wiring, battery, charging, control modules, infotainment and electrical accessories.
From owner reports, verbatim
ELECTRICAL PROBLEM, TROUBLE OPENING DRIVERS SIDE DOOR, AND FUEL PUMP FAILED.
DURING VEHICLE OPERATION THE VEHICLE STALLS WITHOUT WARNING. THIS HAS BEEN A CONTINUOUS PROBLEM. *AK
Fuel system
Reports naming fuel storage or delivery — tanks, pumps, lines, injectors and fuel leaks.
From owner reports, verbatim
ELECTRICAL PROBLEM, TROUBLE OPENING DRIVERS SIDE DOOR, AND FUEL PUMP FAILED.
VEHICLE DOES NOT CONFORM TO LATER IMPACT PORTION OF FEDERAL MOTOR VEHICLE SAFETY STANDARD 301, FUEL SYSTEM INTEGRITY. (93V192000) *DSH
Too few reports in this category for a page of its own — they appear in the full complaint list.
Transmission
Reports naming the automatic or manual transmission, including shifting behaviour, shudder, slipping and transmission control modules.
From owner reports, verbatim
THE CLUTCH FORK BROKE, JAMMING THE TRANSMISSION. ALSO, CAUSING THE CLUTCH TO BECOME INOPERABLE. PLEASE GIVE ANY FURTHER DETAILS. *AK
CLUTCH ASSEMBLY FAILED. *AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Visibility
Reports naming windshields, glass, wipers, defrosters and mirrors.
From owner reports, verbatim
THE BACK SEAT SIDE WINDOW EXPLODES TWICE IN TWO YEARS ONE WAS IN COLD WEATHER PARKED OUTSIDE SECOND ONE WAS PARKED IN GARAGE IN HOT WEATHER AND EXPLODED . TT
REAR SIDE WINDOWS EXPLODED, CAUSING INJURY. *SD
Too few reports in this category for a page of its own — they appear in the full complaint list.
Other / unspecified
Reports whose component NHTSA recorded as unknown, or that do not map to one of the categories above.
From owner reports, verbatim
ALL FOUR RIMS ARE CRACKED DUE TO DESIGN. *AK
WHEN REPLACING TIRES FOUND ALL (4) WHEELS WERE CRACKED. (2) WHEELS ARE SPLIT FROM RIM TO BOLT HOLES. OTHER (2) WHEELS ARE SHOWING CRACKS AND SIGNS OF SPLITTING. *AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Interior & seats
Reports naming seats, latches, locks, linkages and interior fittings.
From owner reports, verbatim
REPLACED COMPUTER. *AK
DRIVER'S SEAT BROKE DURING COLLISION, CAUSING DRIVER TO SLIDE OUT OF SEAT BELT AND THROUGH BACK WINDOW, CAUSING INJURY. (CONSULTING ENGINEER FOR CLIENT). *SKD
Too few reports in this category for a page of its own — they appear in the full complaint list.
Brakes
Reports naming service brakes, the antilock braking system, brake hoses, master cylinders or the parking brake.
From owner reports, verbatim
DURING RAPID ACCELERATION, WHILE STOPPING, BRAKES REQUIRED EXCESSIVE PRESSURE, AND COULD FEEL "CHATTERING" IN BRAKES & THEN A LOSS OF BRAKING POWER. VEHICLE WOULD NOT STOP LIKE IT SUPPOSE TO; SLOW RESPONSE TIME. *AK
WHILE DRIVING ON THE ROAD SMOKE WAS COMING FROM THE BACK OF THE CAR AND THE BRAKES WOULD NOT WORK AND THE CAR BLEW UP AND DRIVER WAS INSIDE. LOST BRAKES BEFORE.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Heating & air conditioning
Reports naming the heating, ventilation and air-conditioning system.
From owner reports, verbatim
AIR CONDITIONER FAILURE. *AK
AIR CONDITIONER HOSE REPLACED. *SD
Too few reports in this category for a page of its own — they appear in the full complaint list.
Driver assistance
Reports naming forward-collision avoidance, lane keeping, back-over prevention, cruise control and related electronic driver-assistance systems.
From owner reports, verbatim
AIR CONDITIONER HOSE REPLACED. *SD
AUTO-TRANSMISSION; VEHICLE JUMPED INTO GEAR AND ACCELERATED. PLEASE DESCRIBE DETAILS. TT
Too few reports in this category for a page of its own — they appear in the full complaint list.
Powertrain (other)
Powertrain reports that are not specifically the engine or transmission — driveshafts, axles, transfer cases and differentials.
From owner reports, verbatim
CV BOOTS FAILED FIVE TIMES.
SLAVE CYLINDER REPLACED.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Suspension
Reports naming suspension components — springs, struts, shocks, control arms and related hardware.
From owner reports, verbatim
CV BOOTS FAILED FIVE TIMES.
REPLACED COMPUTER. *AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Body & structure
Reports naming the vehicle structure, frame, body panels, doors, hood and trim.
From owner reports, verbatim
ELECTRICAL PROBLEM, TROUBLE OPENING DRIVERS SIDE DOOR, AND FUEL PUMP FAILED.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Tires & wheels
Reports naming tires, wheels, hubs, or the tire-pressure monitoring system.
From owner reports, verbatim
AIR CONDITIONER HOSE REPLACED. *SD
Too few reports in this category for a page of its own — they appear in the full complaint list.
Airbags
Reports naming the air-bag system — deployment behaviour, inflators, sensors and warning lights.
From owner reports, verbatim
WHILE DRIVING ABOUT 40 MPH ANOTHER VEHICLE CROSSED CONSUMER'S VEHICLE AND CONSUMER CRASHED INTO IT. UPON IMPACT, DRIVER'S AIR BAG DID NOT DEPLOY. *AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Seat belts
Reports naming seat belts, buckles, retractors and pretensioners.
From owner reports, verbatim
THE SEATBELTS LOCK ALL THE TIME AND CAN'T GET OUT OF VEHICLE. PLEASE DESCRIBE FURTHER. TT
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .