2026 Hyundai Ioniq 5 Electrical Problems

Control box on main battery (iccu)

NHTSA ID

11750575

Incident

Jul 12, 2026

An AVRIDE vehicle made a right-hand turn from a middle lane. It did not use the appropriate lane for right-hand turns.

NHTSA ID

11744301

Incident

Jun 15, 2026

My car would no longer charge after testing various chargers at home and different public charging stations. If this had happened away from home, and without cell service, I might have been stranded. I took I into the Hyundai service center, and they said the ICCU had failed. They replaced if after waiting a week for the part.

NHTSA ID

11734126

Incident

Apr 17, 2026

ICCU and fuse broken

NHTSA ID

11733677

Incident

Apr 18, 2026

Upon delivery of a brand new 2026 Hyundai Ioniq 5 with 13 miles on the odometer, the washer fluid warning illuminated the next day. Reservoir was refilled on 3/29 and was completely empty by 3/30. Vehicle was brought to the authorized dealer on 3/31. The technician confirmed via repair order that the washer fluid hose was actively spouting directly above the ICCU — Integrated Charging Control Unit — a safety-critical high voltage component. Washer fluid was confirmed present in the ICCU floor pan. The cause was a nail severing the washer fluid line. The dealer confirmed the vehicle sat on their lot approximately 70 days before the 3/23/26 delivery date and that washer fluid is factory pre-filled. This indicates the leak was active for approximately 70 days before delivery, during which washer fluid leaked above the ICCU and surrounding electronics. Repair required complete interior disassembly — seats, carpet, center console, floor trim — on a 156-mile brand new vehicle. A full floor wire harness was replaced under Hyundai Techline authorization. Soaked carpet and insulation were salvaged outside rather than replaced. Hyundai Motor America declined to proactively replace the ICCU despite documented fluid exposure above it and denied an extended warranty request covering affected electronics. Safety concern: internal corrosion from extended fluid exposure may not present immediately but can cause sudden loss of drive power — a known ICCU failure mode on this platform subject to multiple prior recalls. Loss of drive power at highway speed poses serious safety risk.

NHTSA ID

11732290

Incident

Mar 23, 2026

The wiring for the air bag system under the driver's seat is exposed and unprotected which has led to disconnection and or damage to the wiring harness which then results in a disabled air bag system. This is a manufacturer design flaw and a serious safety issue. Other owners who have experienced damage to their wiring harness here have had disabled air bag systems for prolonged periods and costly repairs that Hyundai had refused to cover under warranty despite the fact that it is an obvious design flaw and a serious safety issue. See attached photos for evidence of how exposed this wiring harness is and suscebtible to damage as well as an example of damage which can occur which other owners have reported. Damage to this unit due to poor design results in compromised driver and passenger safety and extremely costly repairs ($10,000) which it appears Hyundai is refusing to cover under warranty. We request that this be recalled in order replace the design so this wiring harness is protected properly.

NHTSA ID

11727218

Incident

Mar 26, 2026

Every 7 minutes of driving electrical failure , happens, which results in Check driver assistance system warning. Once vehicle is turned off, driving 7 minutes error pops again. Due to this all systems : Adaptive Cruise Control , Automatic Emergency Braking , Blind Spot Warning , Forward Collision Warning , Lane Departure Warning , Lane Keeping Assistance , Parking Collision Warning , Rear Cross Traffic Warning gets disabled. This creates a huge risk driving.

NHTSA ID

11725393

Incident

Mar 14, 2026

The contact owns a 2026 Hyundai Ioniq 5. The contact stated that while charging the vehicle at the workplace, the vehicle started flashing a message "Charging was Unsuccessful". The contact was able to drive the vehicle to the residence; however, the door locks were making clicking sounds. The contact stated that the vehicle was parked in the driveway and the key fob failed to unlock or lock the doors. The contact called the local dealer, who advised her not to drive the vehicle. The vehicle was towed by the dealer to be diagnosed, and the dealer informed the contact that the Integrated Charging Control Unit (ICCU) had failed and needed to be replaced. The vehicle was not yet repaired. The manufacturer was not informed of the failure. The failure mileage was approximately 160.

NHTSA ID

11722093

Incident

Feb 23, 2026

Mileage

160 mi

My BRAND NEW car is suffering an ICCU issue. I first noticed the screens going completely black while driving. I then noticed that I can’t charge at all on Lvl 1 and Lvl2 chargers (AC), but I went to the dealership and the helped me charge on lvl 3 DC fast charging. This is an incredibly dangerous problem, if this results in my 12V battery dying, I could be stranded while driving.

NHTSA ID

11714591

Incident

Jan 30, 2026