2023 Hyundai Kona Electric Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2023 Hyundai Kona Electric, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Electrical342.9%
- Brakes114.3%
- Driver assistance114.3%
- Fuel system114.3%
- Steering114.3%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Electrical
Reports naming the electrical system — wiring, battery, charging, control modules, infotainment and electrical accessories.
From owner reports, verbatim
The horn has been replaced multiple times for failing without ANY warning. The service department at the Hyundai dealer said that this is a known problem for the horns. The horns short out because moisture builds up and damages the wiring, causing them to fail without warning. At this time, Hyundai does not have a "fix" nor does it have any horns available to replace my failed horn. Hyundai has not offered a loaner vehicle. This vehicle is currently leased from Hyundai and I am current on my lease payments. This vehicle is due for inspection in May 2025 and it will not pass without a horn. I have had several near-miss situations in which I had to brake hard to avoid pedestrians - a horn would have alerted the pedestrians to my presence. Because this is an electric vehicle it runs very quietly and pedestrians need to be alerted with a horn.
Car has only 3000 miles and already has a bad battery. Code DTC P1AA600
Too few reports in this category for a page of its own — they appear in the full complaint list.
Brakes
Reports naming service brakes, the antilock braking system, brake hoses, master cylinders or the parking brake.
From owner reports, verbatim
In damp weather the brake rotors corrode overnight. This causes the brakes to lock up when the brake pedal is touched gently. The car then stops quickly and unexpectedly. This could result in the car being rear ended in traffic. This problem has occurred 7 times since I bought the car.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Driver assistance
Reports naming forward-collision avoidance, lane keeping, back-over prevention, cruise control and related electronic driver-assistance systems.
From owner reports, verbatim
While driving at 60 miles per hour on an interstate, the car's steering system took control of the car and made a quick "S" maneuver. It took all of my strength to maintain control of my car. This incident lasted for just a second or two but it was potentially very dangerous to me (the driver of the car) and to nearby cars (and their drivers). The vehicle is available for inspection. I just reported the incident to to Hyundai and haven't heard back from them. There seemed to be some kind of red warning message on the computer screen, but I couldn't read it because I was so busy fighting the steering wheel for control of the car.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Fuel system
Reports naming fuel storage or delivery — tanks, pumps, lines, injectors and fuel leaks.
From owner reports, verbatim
Car has only 3000 miles and already has a bad battery. Code DTC P1AA600
Too few reports in this category for a page of its own — they appear in the full complaint list.
Steering
Reports naming the steering system — racks, columns, power-steering assist and steering linkage.
From owner reports, verbatim
While driving at 60 miles per hour on an interstate, the car's steering system took control of the car and made a quick "S" maneuver. It took all of my strength to maintain control of my car. This incident lasted for just a second or two but it was potentially very dangerous to me (the driver of the car) and to nearby cars (and their drivers). The vehicle is available for inspection. I just reported the incident to to Hyundai and haven't heard back from them. There seemed to be some kind of red warning message on the computer screen, but I couldn't read it because I was so busy fighting the steering wheel for control of the car.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .