2014 Hyundai Santa Fe Sport Problems

On June 20, 2026, while the 2014 Hyundai Santa Fe Sport was being driven on Richardson Highway near Mile 155 in Alaska, smoke and flames developed from the engine compartment without any collision. The driver stopped and both occupants exited before the vehicle became fully engulfed. The fire created an immediate risk of serious injury or death and blocked the northbound lane. There were no known prior drivability problems, warning lamps, or other symptoms before the incident. The exact failed component is UNKNOWN. Potential areas requiring investigation include the engine, electrical system, ABS/HECU brake module, multi-fuse, fuel system, and other engine-compartment components. Alaska Department of Public Safety responded. Its report states that there was no obvious cause, but that the fire appeared to have originated in the engine compartment. The vehicle was towed and preserved for the manufacturer. Hyundai inspected the vehicle and confirmed that the inspection was completed on July 11, 2026. Hyundai later stated orally that it did not find an engine defect, but it has not provided the complete inspection report, testing methods, photographs, technical findings, or a written origin-and-cause determination. Hyundai has not explained whether the ABS/HECU, electrical system, multi-fuse, fuel system, or other potential fire sources were separately examined. The vehicle sustained catastrophic damage and was a total loss. Both occupants escaped, but experienced severe ongoing psychological distress after the fire. I request that NHTSA evaluate whether the fire involved an engine, electrical, ABS/HECU, fuel-system, recall-remedy, or other safety defect. The vehicle was available for Hyundai's inspection. Its current availability for further inspection is UNKNOWN. The vehicle remains preserved and is currently available for further inspection upon request.

The contact owns a 2014 Hyundai Santa Fe Sport. The contact stated that while driving at undisclosed speeds, the vehicle started to lose power while depressing the accelerator pedal, with black smoke coming from the engine compartment. The oil, check engine, and battery warning lights were displayed on the instrument panel. The contact pulled over and discovered black smoke coming from under the hood. Due to the failure, the vehicle was towed to an independent mechanic, and the engine was replaced. Two weeks after the replacement, the starter failed to operate as needed, and the vehicle was towed back to the independent mechanic, where the starter was replaced. Upon investigation, the mechanic discovered NHTSA Campaign Number: 17V226000 (ENGINE AND ENGINE COOLING); and associated the vehicle with the recall. The contact was referred to the NHTSA Hotline to report the failure. The vehicle remained with the independent mechanic and was not repaired. The manufacturer was not notified of the failure. The failure mileage was 120,577.

On June 20, 2026, while the 2014 Hyundai Santa Fe Sport was being driven on Richardson Highway near Mile 155 in Alaska, smoke and flames developed from the engine compartment without any collision. The driver stopped and both occupants exited before the vehicle became fully engulfed. The fire created an immediate risk of serious injury or death and blocked the northbound lane. There were no known prior drivability problems, warning lamps, or other symptoms before the incident. The exact failed component is UNKNOWN. Potential areas requiring investigation include the engine, electrical system, ABS/HECU brake module, multi-fuse, fuel system, and other engine-compartment components. Alaska Department of Public Safety responded. Its report states that there was no obvious cause, but that the fire appeared to have originated in the engine compartment. The vehicle was towed and preserved for the manufacturer. Hyundai inspected the vehicle and confirmed that the inspection was completed on July 11, 2026. Hyundai later stated orally that it did not find an engine defect, but it has not provided the complete inspection report, testing methods, photographs, technical findings, or a written origin-and-cause determination. Hyundai has not explained whether the ABS/HECU, electrical system, multi-fuse, fuel system, or other potential fire sources were separately examined. The vehicle sustained catastrophic damage and was a total loss. Both occupants escaped, but experienced severe ongoing psychological distress after the fire. I request that NHTSA evaluate whether the fire involved an engine, electrical, ABS/HECU, fuel-system, recall-remedy, or other safety defect. The vehicle was available for Hyundai's inspection. Its current availability for further inspection is UNKNOWN. The vehicle remains preserved and is currently available for further inspection upon request.

I am reporting a severe safety failure on my 2014 Hyundai Santa Fe Sport that perfectly matches the safety defect described in Recall 21V-303 / Campaign 205. This happened even though I had the dealer perform the official recall fuse fix back in 2024. The problem started after I left the car parked for about 3 to 4 hours. When I came back, I heard a motor (not the motor) loudly running under the hood even though the ignition was completely off. It stayed on even after starting and turning the car off. The battery in the vehicle had drained so bad it was deemed bad when hooked up to a tester at the auto parts store. After getting a new battery and trying to drive the car, the electrical system went haywire. The dashboard lit up with every brake warning light on, the speedometer stopped working, miles to empty being erratic, and the exterior rear brake lights kept flickering erratically after the car was turned off. The steering was acting abnormal and unnatural, not crisp and easy to turn as usual. There were absolutely no warning lights or symptoms before I parked the vehicle. I had it towed to my local Hyundai dealership, and their diagnostic scan confirmed major brake and chassis issues, specifically code C2402 for an ABS Pump Motor Circuit Malfunction and codes C1200, C1203, and C1206 for a loss of wheel speed data. The vehicle has not been inspected by police or insurance representatives, but it is currently sitting at the dealership waiting for a resolution from a Hyundai customer care case manager. The 2024 recall remedy only involved dropping the fuse amperage to mitigate fire intensity; it did not replace the module housing or prevent the internal brake fluid leak from eventually destroying the system. The defect has seemingly now fully manifested, knocking out primary braking indicators and power steering assist, presenting an ongoing safety and fire hazard while driving and parked.

On June 20, 2026, while the 2014 Hyundai Santa Fe Sport was being driven on Richardson Highway near Mile 155 in Alaska, smoke and flames developed from the engine compartment without any collision. The driver stopped and both occupants exited before the vehicle became fully engulfed. The fire created an immediate risk of serious injury or death and blocked the northbound lane. There were no known prior drivability problems, warning lamps, or other symptoms before the incident. The exact failed component is UNKNOWN. Potential areas requiring investigation include the engine, electrical system, ABS/HECU brake module, multi-fuse, fuel system, and other engine-compartment components. Alaska Department of Public Safety responded. Its report states that there was no obvious cause, but that the fire appeared to have originated in the engine compartment. The vehicle was towed and preserved for the manufacturer. Hyundai inspected the vehicle and confirmed that the inspection was completed on July 11, 2026. Hyundai later stated orally that it did not find an engine defect, but it has not provided the complete inspection report, testing methods, photographs, technical findings, or a written origin-and-cause determination. Hyundai has not explained whether the ABS/HECU, electrical system, multi-fuse, fuel system, or other potential fire sources were separately examined. The vehicle sustained catastrophic damage and was a total loss. Both occupants escaped, but experienced severe ongoing psychological distress after the fire. I request that NHTSA evaluate whether the fire involved an engine, electrical, ABS/HECU, fuel-system, recall-remedy, or other safety defect. The vehicle was available for Hyundai's inspection. Its current availability for further inspection is UNKNOWN. The vehicle remains preserved and is currently available for further inspection upon request.

*"I am filing a complaint against Hallmark Hyundai in [XXX] regarding an active safety recall on my vehicle's ABS (Anti-lock Braking System) module.My vehicle was brought to the dealership on XXX. As of today, XXX, the dealership has held my car for 27 days without completing the safety remedy. The dealership continues to give me conflicting stories, refuses to provide an expected repair date, and is denying me manufacturer-funded alternative transportation while my vehicle is grounded for this safety defect.I am reporting this because the dealership is failing to provide a timely remedy for a critical braking safety hazard, leaving me without a safe vehicle." The warning lights came on on XXX every light on my dash is flashing. Hallmark Hyundai inspected my vehicle and said it was the abs module I have been without transportation for a whole month with no answers on when my car will be ready for pick. The advisor Devita keep telling me lie after lie I need my car immediately no way it takes a whole month to fix a recall repair I need my car I have lost my job due to this I’ve missed important dr appointments do to my car being held for a month with no answers INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I am reporting a severe safety failure on my 2014 Hyundai Santa Fe Sport that perfectly matches the safety defect described in Recall 21V-303 / Campaign 205. This happened even though I had the dealer perform the official recall fuse fix back in 2024. The problem started after I left the car parked for about 3 to 4 hours. When I came back, I heard a motor (not the motor) loudly running under the hood even though the ignition was completely off. It stayed on even after starting and turning the car off. The battery in the vehicle had drained so bad it was deemed bad when hooked up to a tester at the auto parts store. After getting a new battery and trying to drive the car, the electrical system went haywire. The dashboard lit up with every brake warning light on, the speedometer stopped working, miles to empty being erratic, and the exterior rear brake lights kept flickering erratically after the car was turned off. The steering was acting abnormal and unnatural, not crisp and easy to turn as usual. There were absolutely no warning lights or symptoms before I parked the vehicle. I had it towed to my local Hyundai dealership, and their diagnostic scan confirmed major brake and chassis issues, specifically code C2402 for an ABS Pump Motor Circuit Malfunction and codes C1200, C1203, and C1206 for a loss of wheel speed data. The vehicle has not been inspected by police or insurance representatives, but it is currently sitting at the dealership waiting for a resolution from a Hyundai customer care case manager. The 2024 recall remedy only involved dropping the fuse amperage to mitigate fire intensity; it did not replace the module housing or prevent the internal brake fluid leak from eventually destroying the system. The defect has seemingly now fully manifested, knocking out primary braking indicators and power steering assist, presenting an ongoing safety and fire hazard while driving and parked.

As I would be driving down the road, most of the time when getting up to speeds of either 25-30mph or 55-60mph is when the dash board lights up check BSD detection system failure, then it will rev out rpm’s to 5,000-6,000 then lose power to accelerator. I also notice on the dash board where the panel for your selected gear displays is blank and doesn’t show whether you are in park,drive neutral, ECT. After this occurs I can not drive it any longer until I safely stop the car (most of the time on a busy highway or country road Highway where once this happens it becomes dangerous due to the power loss in the accelerator) and put it in park, I’ve tried to put the vehicle in park, once fully stopped, and try to put it back into drive but the shifter is locked into park and will not let me shift the vehicle, I then have to shut the vehicle completely off and open the driver door to get the backup power cut off as-well to have zero power to the vehicle. Once that is completed I then Re-Start the vehicle where it operates normally again, this situation happens at least twice a week if not 3-4. It sometimes has put my passengers and myself at risk of getting into accidents or struck by other vehicle on the road. my vehicle is still under a warranty through the dealership I purchased it from, but when I ask them about it they say that because there is no prompt on the dash once I get there that they cannot do anything about it, nor do they allegedly know why it’s happening, I’ve asked a few other mechanics I know and they say that they have seen this malfunction before with this vehicle and usually it is a transmission sensor? Or a transmission speed sensor issue? I then relay this message back to the dealer ship and they still act like they don’t know what it is, I truly believe that the dealership just doesn’t want to deal with the issue and I only have 2-3000 miles left under their warranty, I do enjoy the vehicle and respect Hyundai for their great customer service.

Engine code p1326. The engine went into limp mode it was only able to drive about 15 miles then check engine light came popped on and the vehicle stopped and I had the get the vehicle towed. Yes Route 60 of Hyundai in Vero Beach was aware of the issue and also I took the vehicle to Hyundai in Fort pierce where they also was well aware of the engine issue. When I received a recall letter in the mail and brought my vehicle into Route 60 Hyundai of Vero Beach. My vehicle was also apart of the Theta 2 issue class act litigation.

As I would be driving down the road, most of the time when getting up to speeds of either 25-30mph or 55-60mph is when the dash board lights up check BSD detection system failure, then it will rev out rpm’s to 5,000-6,000 then lose power to accelerator. I also notice on the dash board where the panel for your selected gear displays is blank and doesn’t show whether you are in park,drive neutral, ECT. After this occurs I can not drive it any longer until I safely stop the car (most of the time on a busy highway or country road Highway where once this happens it becomes dangerous due to the power loss in the accelerator) and put it in park, I’ve tried to put the vehicle in park, once fully stopped, and try to put it back into drive but the shifter is locked into park and will not let me shift the vehicle, I then have to shut the vehicle completely off and open the driver door to get the backup power cut off as-well to have zero power to the vehicle. Once that is completed I then Re-Start the vehicle where it operates normally again, this situation happens at least twice a week if not 3-4. It sometimes has put my passengers and myself at risk of getting into accidents or struck by other vehicle on the road. my vehicle is still under a warranty through the dealership I purchased it from, but when I ask them about it they say that because there is no prompt on the dash once I get there that they cannot do anything about it, nor do they allegedly know why it’s happening, I’ve asked a few other mechanics I know and they say that they have seen this malfunction before with this vehicle and usually it is a transmission sensor? Or a transmission speed sensor issue? I then relay this message back to the dealer ship and they still act like they don’t know what it is, I truly believe that the dealership just doesn’t want to deal with the issue and I only have 2-3000 miles left under their warranty, I do enjoy the vehicle and respect Hyundai for their great customer service.

Car randomly dies. Constantly needing oil due to it leaking. Check engine light on

Gas is purging from the top of the fuel pump

The passenger-side doors do not latch properly and may open after closing. This creates a safety risk while driving. The issue occurs continually and has worsened over time. Vehicle has approximately 106,265 miles. this causes the auto door locks no to work.

The stationary glass that is in front of the panoramic sunroof shattered for no reason. I found that this has happened to many other people's vehicle like mine. In several incidents, the glass chips fell on passengers in the car when they opened the sunroof. I had a glass repair shop look at it. It will cost $400.00 out of pocket and I don't really want to file a claim to insurance. Can you offer any help?

The contact owns a 2014 Hyundai Santa Fe Sport. The contact stated while driving 10 mph and making a turn, he heard an abnormal cracking sound coming from the steering wheel. There were no warning lights illuminated. The vehicle was taken to a dealer, where it was diagnosed with the power steering needing to be replaced. The contact stated that the vehicle was repaired however, the failure recurred while turning. The manufacturer was not made aware of the failure. The approximate failure mileage was 33,000.

TL* THE CONTACT OWNS A 2014 HYUNDAI SANTA FE SPORT. WHILE DRIVING AT ANY SPEED AND MAKING A TURN, THE STEERING MADE A CLICKING SOUND AND THE VEHICLE SHOOK WITHOUT WARNING. THE VEHICLE WAS TAKEN TO WORLD HYUNDAI (877-340-8037, LOCATED AT 5337 MILLER CIRCLE DR, MATTESON, IL 60443) WHERE AN UNKNOWN ENGINE RECALL REPAIR WAS PERFORMED EARLIER IN THE YEAR. THE DEALER SERVICED THE VEHICLE FOR ONE WEEK AND INFORMED THE CONTACT TO DRIVE THE VEHICLE FOR THIRTY DAYS TO ALLOW THE CLICKING TO STOP. THE CONTACT DID NOT BELIEVE THAT THE VEHICLE WAS REPAIRED AND DID NOT RETRIEVE THE VEHICLE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND THE CONTACT WAS NOT CALLED BACK. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS APPROXIMATELY 69,000. THE VIN WAS UNKNOWN.

THE TRUCK SMELL LIKE BURN AND IS NOT GIVE POWER AND FEELS LIKE SHAKING AND PUSHING

THE CAR WILL NOT STAY ALIGNED. EVERY 1,000 MILES OR SO, THE STEERING GETS WILDLY OUT OF ADJUSTMENT AND CAUSES THE CAR TO DRIFT ALL OVER THE ROAD. IT IS FRIGHTENING TO DRIVE, ESPECIALLY IN DENSE TRAFFIC AT HIGHWAY SPEED. IT IS IMPOSSIBLE TO MAINTAIN A STRAIGHT LINE WITH THE CAR. AT TIMES, THE STEERING WHEEL MUST BE AIMED FAR TO THE LEFT TO GO STRAIGHT. MOMENTS LATER, WITH NO WARNING, THE CAR DIVES TO THE LEFT AND THE WHEEL MUST BE HELD TO THE RIGHT. 'STRAIGHT' ON THE STEERING WHEEL IS NEVER STRAIGHT ON THE ROAD. THIS CONDITION IS HIGHLY INCONSISTENT AND SEEMS IRREPARABLE. THE VEHICLE HAS BEEN ALIGNED 8+ TIMES BY DIFFERENT SHOPS AND IT CONTINUES TO 'RESET ITSELF' BACK TO THIS NEARLY UNDRICEABLE CONDITION. THE FIRST INSTANCE WAS AT 4,100 MILES. THE VEHICLE NOW HAS 51,000 MILES. THE CONDITION IS THE SAME REGARDLESS OF THE SPEED, ROAD SURFACE, ROAD TYPE, OR CROWN IN THE ROADWAY. YOU CAN HEAR MANY CREAKS AND SOUNDS AND FEEL THE BODY OF THE VEHICLE FLEXING SIGNIFICANTLY AS YOU DRIVE. IT IS MY BELIEF THAT THERE IS A STRUCTURAL DEFECT MAKING THE CAR UNSAFE TO OPERATE BOTH FOR THE STEERING AND SUSPENSION SYMPTOMS AND ALSO REGARDING ITS CRASHWORTHINESS.

The contact owns a 2014 Hyundai Santa Fe Sport. The contact stated that she noticed a trail of fluid leak on the driveway. The vehicle was taken to the dealer, where it was diagnosed that no issues were found. However, the failure persisted. Additionally, the contact stated while driving 65-70 MPH, the traction control, the hill start assists, and the ABS warning lights illuminated. Additionally, the contact smelled an abnormal burning odor. The vehicle was taken to the dealer, where it was diagnosed that the rear wheel speed sensor had failed and needed to be replaced. The vehicle was not repaired. The contact related the failure to Hyundai Technical Service Bulletin Number: 17-01-009-2. The manufacturer was not notified of the failure. The failure mileage was approximately 21,703.

NOTICED A VIBRATION WHEN DRIVING ON THE FREEWAY, STOPPED AT A LES SCHWAB AND THE TIRE BELTS ON TWO OF THE FOUR TIRES HAD SEPARATED. WE WERE TOLD THAT WE COULDN'T LEAVE WITHOUT REPLACING ALL FOUR TIRES.

Seat belt has been fraying for years and has not return to original position on the I-beam when not being used. Repair shops say it’s normal for vehicle.

The contact owns a 2014 Hyundai Santa Fe Sport. The contact stated there was a defect with the driver's side seat belt. There were no warning lights illuminated. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 85,000.

SE COMPR EL VEHCULO HA TENIDO DOS RECALL SE HA LLEVADO A TODOS LOS MANTENIMIENTOS RUTINARIOS AHORA AIRBAG LIGHT SUPUESTAMENTE NO SURVEN LOS AIRBAGS AND A /C PRENDE CUANDO LE DA LA GANA YA ESTAMOS CANSADO DE AGUANTAR LOS MALOS SERVICIOS DE LA HYUNDAI

I HAVE RECENTLY RECEIVED A SAFETY RECALL NOTICE FROM HYUNDAI FROM NATIONAL TRAFFIC AND MOTOR VEHICLE SAFETY ACT FOR THE HYUNDAI SANTE FE SPORT 2014, SUV. THE PROBLEM ON THE LETTER STATES THERE ARE PROBLEMS IN THE MANUFACTURING OF THE ENGINE, PRE-MATURE BEARING WEAR IN THE MOTOR AND THE BEARING CAN FAIL, AND VEHICLE COULD STALL WHILE IN MOTION, INCREASING RISK OF CRASH. I AM TAKING THE VEHICLE TO HYUNDAI DEALERSHIP TODAY. THE VEHICLE IS MAKING A KNOCKING NOISE FROM THE ENGINE THAT INCREASES IN FREQUENCY AS THE ENGINE RPM INCREASES. I DRIVE THE VEHICLE ON THE HIGHWAY SO THIS IS VERY DANGEROUS AND JUST STARTED TO HEAR IT LAST NIGHT. IT HAS STARTED TO REDUCE POWER WHEN GAS IS ACCELERATED AND RPM INCREASE AND HESITATION OF VEHICLE MOVING FORWARD WHEN PUSHING DOWN ON GAS PEDAL. THIS VEHICLE HAS BEEN UNSAFE TO DRIVE AND I AM A MOTHER OF A 4 YEAR OLD SON, WE BOUGHT THE CAR ORIGINALLY FOR SAFETY. I AM DISSAPOINTED IN THIS VEHICLE AS IT WAS UNSAFE FOR ME AND MY FAMILY TO DRIVE IN. I ALSO UTILIZE THE VEHICLE FOR WORK AND IT IS UNSAFE TO DRIVE. I WILL ALSO HAVE TO DEAL WITH FIGURING OUT TRANSPORTATION WHEN DEALING WITH HYUNDAI DEALERSHIP. I AM UNCLEAR OF THE OUTCOME AT THIS MOMENT, BUT VERY DISSATISFIED WITH THIS VEHICLE.

SE COMPR EL VEHCULO HA TENIDO DOS RECALL SE HA LLEVADO A TODOS LOS MANTENIMIENTOS RUTINARIOS AHORA AIRBAG LIGHT SUPUESTAMENTE NO SURVEN LOS AIRBAGS AND A /C PRENDE CUANDO LE DA LA GANA YA ESTAMOS CANSADO DE AGUANTAR LOS MALOS SERVICIOS DE LA HYUNDAI