2015 Hyundai Santa Fe Sport Brakes Problems

For a few months- the ABS light, Downhill assist light, and Slippery road light have all been on. Read it could be due to a bad sensor. Then on Saturday July 4th, I turned the car on and the Ebrake light was on but my ebrake was NOT initiated. Car was making a low humming noise on front passenger side of vehicle as well. I read the ebrake light could come on due to low brake fluid, so I wanted to drive it around the block to further try and diagnose the issue. My car then made a pop noise and started smoking from where the ABS pump is located and my tail lights all started flickering like Christmas lights. I instantly turned the car off and disconnected the battery to prevent an electrical fire. UPON researching- there is a recall for 2015 Santa Fe’s for this exact issue except mine isn’t on the list. I need to talk to someone who has seniority upon this situation because I have called Hyundai Customer service and my local dealership and nothing is being done or nobody cares to resolve this situation. My car is currently at a trusted local garage awaiting repair- I can not tow it back and forth between the garage and a dealership. I rely on my car for my children and work.. I can’t play around waiting for them to inspect it weeks from now. This is a serious issue as my children were also in the car. Everything is VERY similar to the recall on other 2015 Santa Fe’s..

NHTSA ID

11749067

Incident

Jul 4, 2026

FHW Garage used car dealer [XXX], sold this Hyundai Santa fe 2015 knowing the vehicle is defective. It Stalls and stops in the middle of the road in High Traffic. This Hyundai Santa Fe 2015 Lock up the Steering Wheel, Lock up the breaks, Lock up the gas. it Stalls and stops without Warning then after it freeze and stop it flashes all of the Warning Lights on the dash board. FHW Garage is Falsely Advertising this vehicle in Excellent Condition. Its Advertised on Craigs List, and [XXX]. I was almost in a Serious Accident. [XXX] keeps getting his people in the workshop to Machanically Rig the Vehicle to run and drive until someone gets killed when this vehicle is in a terrible Accident. The Gas Cap dont screw on properly. Fhw Garage [XXX] sold me this Vehicle with full knowlege of the Mechanical Defects, and refuses to give my money back. I paid $5,400 Cash plus traded my car. The Hyundai Santa fe was $6,900. Deceptive Practices Fraud, and Title Jumping. FHW still have the two cars after I purchased them. I would like to see FHW Dealer License Suspended or Revoked. Give my money back and return my car. I will be filing a complaint Affidavit with the FLHSMV. [XXX] lied on the Bill of Sales how much I paid and he put $900 in his pocket. I will also file a complaint to FHW [XXX]. For defrauding me, Misrepresentation saying the Vehicle is in Excellent Condition when its Mechanically Defective, and Dangerous should not be on the road to kill someone. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID

11747002

Incident

Jun 27, 2026

Put in reverse to move backwards 5 feet or so the vehicle kept going and moving faster I applied the brake and hitting the brakes as well I didn't wonna hit the parked cars behind me so I put in park thinking that will also help stop the vehicle nothing worked it only stopped after hitting my other car that was parked on the street I tried everything to stop it it just took off I came out a beautiful morning to change the radiator it was dripping from the bottom I purchased a new one I put the car front wheels on ramps to look underneath to see what sockets I needed I got in vehicle just to lower off ramps backing down slow foot covering brake once the car touch ground it accelerated not fast but wouldn't stop it happened so fast but I applied the emergency brake its moving faster applying the brake as well im looking in the mirror at wants behind me as well I put in park thinking that would stop the vehicle but it was accelerating didnt stop until it hit the car parked on the street that's also mine it was dangerous and scary and im thankful it wasnt a tragedy normally my grandkids would be playing out there i could killed them I cant stop thinking about the what could been driving 42 years I consider myself a good driver defensive driving course never had a chargeable accident drove professional also for 32 years I did all I could think of in that little bit of time it just accelerated again backing tapping brakes 2 or 3 times coming down off ramps front maybe 4 or 5 inches off ground lowering to ground it take off something worth looking into thank you last thing my wife was coming to bring me a flashlight the fence hit her 30 more seconds she probably would been hit or killed so this is really affecting me

NHTSA ID

11691791

Incident

Oct 5, 2025

Driving on freeway and noticed smoke. Realized I needed to pull over and brakes weren’t working. Off ramp was at an incline so car came to a stop just in time to get toddler and myself out of vehicle. Car was on fire.

NHTSA ID

11678091

Incident

Jul 31, 2025

I bought the 2015 Hyundai Santa Fe yesterday evening. Upon leaving the dealership I promptly broke for a car in front of me. Immediately the vehicle turned off completely. I put the vehicle in the park and attempted to start the vehicle back up. The vehicle would not start up and begin leaking a prominent scent. Following this, white smoke with the same pungent smell was coming from the engine. I propped the hood and saw the smoke continue to release. I then motioned away from the vehicle and called for a tow truck. The car is now being inspected by the dealership I purchased it from the same day. I believe this is related to the NHTSA recall on 2010-2015 Hyundai Santa Fe, recall date 09/22/2023, recall number 21V303000, and Hyundai Safety Recall 251s Anti-Lock Braking System Fuse Replace. This issue is not listed under my vehicle VIN number but it’s apparent to be the case and issue and is being inspected further by the dealership.

NHTSA ID

11676337

Incident

Jul 25, 2025

The contact owns a 2015 Hyundai Santa Fe Sport. The contact stated he took the vehicle to the dealer to be serviced under NHTSA Campaign Number: 21V303000 (Service Brakes, Hydraulic). The contact stated that while his daughter was driving 45 MPH, the vehicle failed to accelerate with the check engine warning light illuminated. The vehicle was towed to the dealer and the contact was informed that the knock sensor detected a failure and shifted the vehicle into SAFE mode. The manufacturer was contacted by the dealer. The dealer was asked to continue performing tests on the vehicle. The vehicle was not repaired. The failure mileage was 71,000.

NHTSA ID

11479954

Incident

Jul 30, 2022

Mileage

71,000 mi

The contact co-owns a 2015 Hyundai Santa Fe. The contact received notification of NHTSA Campaign Number: 17V358000 (Latches/Locks/Linkages) and 21V303000 (Service Brakes, Hydraulic) and requested to be removed from the recall distribution list. The local dealer and manufacturer were not contacted.

NHTSA ID

11465337

Incident

May 19, 2022

The contact owns a 2015 Hyundai Santa Fe Sport. The contact received notification of NHTSA Campaign Number: (21V303000) (Service Brakes, Hydraulics) and would like to be removed from the recall distribution list. The local dealer and manufacturer were not contacted.

NHTSA ID

11464576

Incident

May 13, 2022

The contact owns a 2015 Hyundai Santa Fe Sport. The vehicle had previously been serviced at the dealer under NHTSA Campaign Number: 21V303000 (Service Brakes, Hydraulic) however, after the recall repair was performed, the ABS warning light illuminated. The contact stated that the dealer was made aware of the failure but informed her that she needed to pay out-of-pocket for the diagnostic test. The vehicle was not repaired. The manufacturer was made aware of the failure but provided no assistance. The failure mileage was 84,882.

NHTSA ID

11463617

Incident

Jul 22, 2021

Mileage

84,882 mi

The contact owns a 2015 Hyundai Santa Fe Sport. The vehicle had previously been serviced by the dealer under NHTSA Campaign Numbers: 20V520000 (Service Brakes, Hydraulic) and 21V303000 (Service Brakes, Hydraulic) however, after the recalls were repaired, the Anti-lock Brake System (ABS) warning light illuminated. The dealer was made aware of the failure and advised the contact to park the vehicle outside as a precaution. The dealer informed the contact that they would call back to schedule an appointment. The manufacturer was made aware of the failure and informed the contact that there was no open recall associated with the VIN. The vehicle was not repaired. The failure mileage was approximately 49,000.

NHTSA ID

11451521

Incident

Feb 11, 2022

Mileage

49,000 mi

The contact owns a 2015 Hyundai Santa Fe Sport. The contact stated that the ABS warning light was illuminated. The vehicle was taken to the local dealer to be diagnosed. The contact was informed that the ABS module needed to be replaced. The vehicle was repaired. The manufacturer was not contacted or informed of the failure. The failure mileage was 58,646

NHTSA ID

11440465

Incident

Nov 2, 2021

Mileage

58,646 mi

The contact owns a 2015 Hyundai Santa Fe. The contact received a notification for NHTSA Campaign Number: 21V303000 (Service Brakes, Hydraulic). The dealer had been notified twice about the recall however, the contact was informed that the dealer was unaware of the recall. The manufacturer had been notified twice about the recall and provided a case number each time. The contact had not experienced a failure. Parts distribution disconnect.

NHTSA ID

11431588

Incident

Dec 1, 2020

TL* THE CONTACT OWNS A 2015 HYUNDAI SANTA FE SPORT. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 21V303000 (SERVICE BRAKES, HYDRAULIC) HOWEVER, THE PART TO DO THE RECALL REPAIR WAS NOT YET AVAILABLE. THE CONTACT STATED THAT CIOCCA HYUNDAI OF WILLIAMSPORT LOCATED AT 202 LYCOMING MALL DR, MUNCY, PA 17756, (570) 567-2000, HAD EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.

NHTSA ID

11415541

Incident

May 3, 2021

TL* THE CONTACT OWNS A 2015 HYUNDAI SANTA FE SPORT. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 20V520000 (SERVICE BRAKES, HYDRAULIC). THE VEHICLE WAS TAKEN TO KEN GARFF HYUNDAI DOWNTOWN (717 SW. TEMPLE, SALT LAKE CITY, UT 84101, (801) 257-3200) FOR THE RECALL REPAIR HOWEVER, THE DEALER STATED THAT THE EQUIPMENT NEEDED TO SERVICE THE RECALL WAS DOWN. THE CONTACT WAS INFORMED THAT HE WOULD RECEIVE A CALLBACK ONCE THE EQUIPMENT WAS BACK UP AND RUNNING. THE CONTACT HAD NOT YET RECEIVED A CALLBACK. SEVERAL ATTEMPTS WERE MADE TO REACH THE DEALER BUT WAS UNSUCCESSFUL. THE CONTACT STATED THAT THE MANUFACTURER HAD EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT STATED THAT HE EXPERIENCED A FAILURE RELATED TO THE RECALL AND THE FRONT AND REAR BRAKES WERE REPLACED. THE FAILURE MILEAGE ON THE VEHICLE IS 67,000.

NHTSA ID

11414189

Incident

Jan 13, 2021

Mileage

67,000 mi

TL* THE CONTACT OWNS A 2015 HYUNDAI SANTA FE SPORT. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 20V520000 (SERVICE BRAKES, HYDRAULIC) HOWEVER, THE PART TO DO THE RECALL REPAIR WAS NOT YET AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER HAD EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. AN UNKNOWN DEALER WAS CONTACTED AND CONFIRMED THAT THE PARTS WERE NOT YET AVAILABLE. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. PARTS DISTRIBUTION DISCONNECT.

NHTSA ID

11384564

Incident

Dec 22, 2020

TL* THE CONTACT OWNS A 2015 HYUNDAI SANTA FE. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 20V520000 (SERVICE BRAKES, HYDRAULIC) HOWEVER, THE PART TO DO THE RECALL REPAIR WAS NOT YET AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE CONTACT CALLED JENKINS HYUNDAI OF JACKSONVILLE (11107 ATLANTIC BLVD, JACKSONVILLE, FL 32225) AND WAS INFORMED THAT THE PART WAS NOT YET AVAILABLE. THE CONTACT STATED THAT WHILE DEPRESSED, THE BRAKE PEDAL FELT A LITTLE MUSHY. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE FAILURE MILEAGE WAS APPROXIMATELY 31,333. PARTS DISTRIBUTION DISCONNECT.

NHTSA ID

11382823

Incident

Sep 8, 2020

Mileage

31,333 mi

TL* THE CONTACT OWNS A 2015 HYUNDAI SANTA FE. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 20V520000 (SERVICE BRAKES, HYDRAULIC) HOWEVER, THE PART TO DO THE RECALL REPAIR WAS UNAVAILABLE. THE CONTACT HAD NOT CONTACTED A DEALER. THE CONTACT STATED THAT THE MANUFACTURER HAD EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS NOT MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

NHTSA ID

11376289

Incident

Aug 1, 2020

TL* THE CONTACT OWNS A 2015 HYUNDAI SANTA FE SPORT. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 20V520000 (SERVICE BRAKES, HYDRAULIC) HOWEVER, THE PART TO DO THE RECALL REPAIR WAS NOT YET AVAILABLE. THE LOCAL DEALER CRAFT HYUNDAI LOCATED AT 2625 LAKESIDE DR, LYNCHBURG, VA 24501, (434) 455-7060 WAS CONTACTED AND IT WAS CONFIRMED THAT THE PART WAS NOT YET AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER HAD EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

NHTSA ID

11375258

Incident

Sep 1, 2020

TL* THE CONTACT OWNS A 2015 HYUNDAI SANTA FE SPORT. THE CONTACT RECEIVED NOTIFICATION OF NHTSA RECALL NUMBER: 20V520000 (SERVICE BRAKES, HYDRAULIC) HOWEVER, THE PART TO DO THE RECALL REPAIR WAS NOT YET AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE DEALER LEHIGH VALLEY HYUNDAI (675 STATE AVENUE, EMMAUS, PA 18049, (610) 967-6500) WAS CONTACTED AND CONFIRMED THAT PARTS WERE NOT YET AVAILABLE. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE AND PROVIDED THE CONTACT WITH A CASE NUMBER HOWEVER, NO FURTHER ASSISTANCE WAS PROVIDED. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

NHTSA ID

11366982

Incident

Aug 27, 2020

TL* THE CONTACT OWNS A 2015 HYUNDAI SANTA FE SPORT. THE CONTACT STATED WHILE DRIVING AT VARIOUS SPEEDS, THERE WAS AN ABNORMAL SQUEAKING SOUND WHILE DEPRESSING THE BRAKE PEDAL. THE CONTACT THEN RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 20V520000 (SERVICE BRAKES, HYDRAULIC) HOWEVER, THE PART TO DO THE RECALL REPAIR WAS NOT YET AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER HAD EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE FAILURE MILEAGE WAS UNKNOWN. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

NHTSA ID

11366675

Incident

Oct 27, 2020

TL* THE CONTACT OWNS A 2015 HYUNDAI SANTA FE SPORT. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 20V520000 (SERVICE BRAKES, HYDRAULIC) HOWEVER, THE PART TO DO THE RECALL REPAIR WAS NOT YET AVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER HAD EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. AN UNKNOWN DEALER WAS CONTACTED AND CONFIRMED THAT PARTS WERE NOT YET AVAILABLE. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.

NHTSA ID

11366485

Incident

Oct 26, 2020

PURCHASED A CPO CAR FROM DEALERSHIP. 32K MILES. DROVE APPROXIMATELY 150 MILES WHEN DRIVING UP A MAJOR HIGHWAY AT 60MPH, ENGINE STARTING SEVERE KNOCKING, IN LESS THEN 1/2 MILE, ENGINE FAILED. ELECTRICAL WORKED, PUT ON HAZARD LIGHTS. BRAKES WERE UNUSABLE. COASTED TO EMERGENCY LANE AND PUSHED INTO PARK. CAR WAS TOWED BACK TO DEALERSHIP WHERE IT WAS DETERMINED THAT THE CAR ENGINE THREW A ROD. ENTIRE ENGINE NEEDED TO BE REPLACED. THIS CAR WAS "CERTIFIED". CAR WAS RETURNED TO DEALERSHIP WHERE A FULL REFUND WAS OBTAINED. I HAVE VIDEO OF THE ENGINE SOUND.

NHTSA ID

11081581

Incident

Mar 18, 2018

Mileage

32,820 mi

PUSH TO START DOES NOT WORK. BRAKE IS NOT REGISTERING

NHTSA ID

11075363

Incident

Feb 27, 2018

Mileage

38,667 mi