1999 Hyundai Sonata Problems

AFTER REMOVING THE DRIVERS FRONT WHEEL I NOTICED THE CONTROL ARM ATTACHMENT POINT SEVERELY RUSTED, & THE SUB FRAME CRACKED READY TO BREAK. I KNOW ABOUT THE RECALL. UNFORTUNATELY NEBRASKA ALONG WITH OTHER STATES WERE NOT INCLUDED. THIS CAR WAS WELL MAINTAINED BY THE ORIGINAL OWNER, & DRIVEN VERY LITTLE IN SALT/ SNOW CONDITIONS. SHE PURCHASED @ APPROX. 80 YEARS OF AGE. NHTSA SHOULD TAKE A LOOK AT THIS AGAIN. WATER BEING TRAPPED IN THE SUB FRAMES IS THE REAL PROBLEM, SALT MAY HAVE ONLY MADE THE FAILURE HAPPENED A BIT SOONER. I HAVE TALKED WITH HYUNDAI CUSTOMER ASSISTANCE, & WAS TOLD THE CAR WOULD NOT BE COVERED BY THE RECALL. I LIVE 8 MILES AWAY FROM IOWA, WHICH IS COVERED BY THE RECALL. OMAHA DOES USE SALT ON THE STREETS. 14 -15 YEARS FOR A SUB FRAME TO ROT AWAY SEEMS QUITE SHORT. THE PROBLEM IS A DESIGN DEFECT NOT ALLOWING THE WATER TO GET OUT. NO STATES SHOULD HAVE BEEN LEFT OUT! WHO DOESN'T WASH THEIR CAR REGULARLY? HOW MANY 1999-2004 MODELS OF THIS CAR ARE STILL ON THE ROAD? FORTUNATELY FOR OUR FAMILY WE NOTICED THE STEERING WHEEL SIGNIFICANTLY OUT OF POSITION, & BOTH FRONT WHEELS LEANING IN AT THE TOP. SEPARATION OF THE CONTROL ARM FROM THE FRAME WOULD NOT PRETTY AT A HIGHER RATE OF SPEED. PEOPLE THAT HAVE LOOKED AT THE PICTURES I TOOK OF BOTH SIDES ON THIS CAR SEEM TO AGREE, WE WERE PROBABLY ONLY A FEW MORE CHUCK HOLES AWAY! WILL HYUNDAI NOTIFY CURRENT OWNERS OF ANY OF THESE CARS REGARDLESS OF WHICH STATE & REMEDY CORRECTLY?? WILL HYUNDAI, OR GOVERNMENT PUT OUT TSB'S OR PSA'S ALERTING ANY CURRENT OWNERS OF THE POTENTIALLY CATASTROPHIC CONDITION WHICH MAY COST SOMEONE THEIR LIFE? *TR

THE SUB FRAME/K FRAME ON MY 99 HYUNDAI SONATA RUSTED OUT CAUSING MY DRIVER SIDE REAR TIRE AND PASSENGER SIDE REAR TIRE TO FACE OUTWARDS ALMOST COMING OFF AND DAMAGING MY LEFT CONTROL ARM. I HEARD A LOUD POP AND COULDN'T FIGURE OUT WHAT IT WAS THEN REALIZED THE STEERING WHEEL WAS COCKED AT 180. I HAD TO DRIVE IT HOME WHICH WAS LUCKILY ONLY 2 MINUTES DOWN THE ROAD, I HAD TO DRIVE 10MPH SMELLING BURNING RUBBER. *TR

L WAS STOPPED ON TRAFFIC ON HIGH WAY ,AND SOME ONE, HIT ME ON THE BACK ,THE GUY WAS SO FAST PROBLEM MORE THAN 75 MPH ,THAN MY CAR FLOAT 20 FOOT ,AND HIT THE CAR ON MY FRONT AND MY AIR BAGS DID NOT DEPLOY OR OPEN , SO THE QUESTION IS HYUNDAI SONATA 1999 USUALLY HAVE THIS PROBLEM , ???? *TR

I PURCHASED MY 1999 SONATA FROM A USED CAR DEALER & HAVE HAD NUMEROUS PROBLEMS WITH THE CAR, ITS BEEN A NIGHTMARE, ONE PROBLEM AFTER ANOTHER!!!! THE CRANKSHAFT SENSOR HAD TO BE COMPLETELY REPLACED BECAUSE THE COMPONENT HAD SEVERELY MELTED, ISSUES WITH THE TRANSMISSION, ABS/AIRBAG WARNING LIGHT ON, & HAVE HAD TO CHANGE OUT THE HALF SHAFT ON BOTH DRIVERS/PASSENGER SIDE, NUMEROUS TIRES, BRAKES BUT THE MOST SEVERE OF ALL THE PROBLEMS WHICH PUTS MY SAFETY, MY 12 YR OLD SON & FIANCE'S SAFETY, ALONG WITH FAMILY/FRIEND'S SAFETY AT RISK IS THE COMPLETE CORROSION OF THE SUBFRAME I TOO TO A MECHANIC TODAY & HE TOLD ME TO NOT DRIVE THIS CAR FOR ANYTHING BECAUSE IT WILL RESULT IN AN ACCIDENT WHERE I CAN POTENTIALLY END UP HURTING MYSELF OR OTHER INNOCENT BYSTANDERS BECAUSE HYUNDAI MADE A DEFECTIVE SUBFRAME ESPECIALLY FOR US THAT LIVE & DRIVE IN HAZARDOUS CONDITIONS OF THE WINTRY/ICY ELEMENTS FOR 5+MONTHS OUT OF THE YEAR IN UPSTATE NEW YORK!!! I WILL BE CALLING HYUNDAI'S CUSTOMER ASSISTANCE CTR & FUCCILLO HYUNDAI(LOCAL DEALER)& THE ATTORNEY GENERAL FOR NEW YORK. I CANNOT IMAGINE WHAT COULD'VE HAPPENED IF I DROVE OVER A POT HOLE RESULTING IN MY TIRE(S) FALLING OFF ESPECIALLY IF I WAS ON THE EXPRESSWAY DOING 55MPH MY LOVED ONES OR OTHER'S LOVED ONES, & MYSELF COULD'VE BEEN SEVERELY INJURED OR WORSE DEAD DUE TO HYUNDAI USING A SUBFRAME THAT WOULD SEVERELY CORRODE THE SUBFRAME ESPECIALLY IN THE "SNOW BELT" STATES!!!!! I JUST HOPE THAT I DO NOT HAVE A DIFFICULT TIME HAVING HYUNDAI FIX THE PROBLEM IN A SPEEDY FASHION WITHOUT TRYING TO STRONG ARM ME INTO PAYING FOR REPAIRS THAT I AM NOT RESPONSIBLE FOR BECAUSE IT IS AN INCONVENIENCE BEING WITHOUT A VEHICLE NOW UNTIL IT GETS REPAIRED. *TR

I PURCHASED MY 1999 SONATA FROM A USED CAR DEALER & HAVE HAD NUMEROUS PROBLEMS WITH THE CAR, ITS BEEN A NIGHTMARE, ONE PROBLEM AFTER ANOTHER!!!! THE CRANKSHAFT SENSOR HAD TO BE COMPLETELY REPLACED BECAUSE THE COMPONENT HAD SEVERELY MELTED, ISSUES WITH THE TRANSMISSION, ABS/AIRBAG WARNING LIGHT ON, & HAVE HAD TO CHANGE OUT THE HALF SHAFT ON BOTH DRIVERS/PASSENGER SIDE, NUMEROUS TIRES, BRAKES BUT THE MOST SEVERE OF ALL THE PROBLEMS WHICH PUTS MY SAFETY, MY 12 YR OLD SON & FIANCE'S SAFETY, ALONG WITH FAMILY/FRIEND'S SAFETY AT RISK IS THE COMPLETE CORROSION OF THE SUBFRAME I TOO TO A MECHANIC TODAY & HE TOLD ME TO NOT DRIVE THIS CAR FOR ANYTHING BECAUSE IT WILL RESULT IN AN ACCIDENT WHERE I CAN POTENTIALLY END UP HURTING MYSELF OR OTHER INNOCENT BYSTANDERS BECAUSE HYUNDAI MADE A DEFECTIVE SUBFRAME ESPECIALLY FOR US THAT LIVE & DRIVE IN HAZARDOUS CONDITIONS OF THE WINTRY/ICY ELEMENTS FOR 5+MONTHS OUT OF THE YEAR IN UPSTATE NEW YORK!!! I WILL BE CALLING HYUNDAI'S CUSTOMER ASSISTANCE CTR & FUCCILLO HYUNDAI(LOCAL DEALER)& THE ATTORNEY GENERAL FOR NEW YORK. I CANNOT IMAGINE WHAT COULD'VE HAPPENED IF I DROVE OVER A POT HOLE RESULTING IN MY TIRE(S) FALLING OFF ESPECIALLY IF I WAS ON THE EXPRESSWAY DOING 55MPH MY LOVED ONES OR OTHER'S LOVED ONES, & MYSELF COULD'VE BEEN SEVERELY INJURED OR WORSE DEAD DUE TO HYUNDAI USING A SUBFRAME THAT WOULD SEVERELY CORRODE THE SUBFRAME ESPECIALLY IN THE "SNOW BELT" STATES!!!!! I JUST HOPE THAT I DO NOT HAVE A DIFFICULT TIME HAVING HYUNDAI FIX THE PROBLEM IN A SPEEDY FASHION WITHOUT TRYING TO STRONG ARM ME INTO PAYING FOR REPAIRS THAT I AM NOT RESPONSIBLE FOR BECAUSE IT IS AN INCONVENIENCE BEING WITHOUT A VEHICLE NOW UNTIL IT GETS REPAIRED. *TR

TL* THE CONTACT OWNS A 1999 HYUNDAI SONATA. THE CONTACT RECEIVED REPAIRS UNDER NHTSA CAMPAIGN ID NUMBER: 09V124000 (SUSPENSION). THE VEHICLE WAS TAKEN TO A LOCAL MECHANIC BECAUSE THE MOTOR WAS EXCESSIVELY LOUD AFTER THE RECALL REPAIR. IN ADDITION, THE CONTACT STATED THE VEHICLE WOULD SWAY BACK AND FORTH, THE MOTOR WOULD JUMP ABNORMALLY AND THE STEERING WOULD INTERMITTENTLY BECOME HARD. THE CONTACT WAS ADVISED BY THE MECHANIC THAT THE MOTOR MOUNTS WERE LOOSE AND TO TAKE THE VEHICLE BACK TO THE DEALER FOR REPAIRS. THE DEALER ADVISED THAT THE MOTOR MOUNT WAS FRACTURED BUT DID NOT MAKE REPAIRS. ON A SEPARATE OCCASION WHILE DRIVING 40 MPH, THE REAR OF THE VEHICLE BEGAN TO SWAY ABNORMALLY. A VEHICLE CRASHED INTO THE REAR OF HER VEHICLE BUT DID NOT STOP. THERE WERE TWO PASSENGERS THAT SUSTAINED INJURIES TO THE KNEE, NECK AND BACK. A POLICE REPORT WAS AVAILABLE. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 125,633 AND THE CURRENT MILEAGE WAS 130,000.

I WAS DRIVING HOME FROM WORK ON JAN 30TH, 2015 AND THE CAR STARTED PULLING TO THE RIGHT. THE NEXT DAY, SAT THE 31ST, I JACKED UP THE RIGHT FRONT OF THE CAR TO SEE WHY THE CAR STEERED TO THE RIGHT. I FOUND THE LOWER WHEEL ASSEMBLY ATTACHMENT TO THE FRAME HAD COME LOOSE. THAT WAS BECAUSE THE FRAME HAD THREE OF FOUR SIDES RUSTED THRU. THE CONDITION COULD HAVE CAUSED A MORE SEVERE ACCIDENT IF THE ATTACHMENT TO THE FRAME HAD PULLED COMPLETELY APART. I WILL CHECK WITH HYUNDAI TO SEE WHAT THEY CAN DO ABOUT IT. THANKS FOR LISTENING. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

AFTER REMOVING THE DRIVERS FRONT WHEEL I NOTICED THE CONTROL ARM ATTACHMENT POINT SEVERELY RUSTED, & THE SUB FRAME CRACKED READY TO BREAK. I KNOW ABOUT THE RECALL. UNFORTUNATELY NEBRASKA ALONG WITH OTHER STATES WERE NOT INCLUDED. THIS CAR WAS WELL MAINTAINED BY THE ORIGINAL OWNER, & DRIVEN VERY LITTLE IN SALT/ SNOW CONDITIONS. SHE PURCHASED @ APPROX. 80 YEARS OF AGE. NHTSA SHOULD TAKE A LOOK AT THIS AGAIN. WATER BEING TRAPPED IN THE SUB FRAMES IS THE REAL PROBLEM, SALT MAY HAVE ONLY MADE THE FAILURE HAPPENED A BIT SOONER. I HAVE TALKED WITH HYUNDAI CUSTOMER ASSISTANCE, & WAS TOLD THE CAR WOULD NOT BE COVERED BY THE RECALL. I LIVE 8 MILES AWAY FROM IOWA, WHICH IS COVERED BY THE RECALL. OMAHA DOES USE SALT ON THE STREETS. 14 -15 YEARS FOR A SUB FRAME TO ROT AWAY SEEMS QUITE SHORT. THE PROBLEM IS A DESIGN DEFECT NOT ALLOWING THE WATER TO GET OUT. NO STATES SHOULD HAVE BEEN LEFT OUT! WHO DOESN'T WASH THEIR CAR REGULARLY? HOW MANY 1999-2004 MODELS OF THIS CAR ARE STILL ON THE ROAD? FORTUNATELY FOR OUR FAMILY WE NOTICED THE STEERING WHEEL SIGNIFICANTLY OUT OF POSITION, & BOTH FRONT WHEELS LEANING IN AT THE TOP. SEPARATION OF THE CONTROL ARM FROM THE FRAME WOULD NOT PRETTY AT A HIGHER RATE OF SPEED. PEOPLE THAT HAVE LOOKED AT THE PICTURES I TOOK OF BOTH SIDES ON THIS CAR SEEM TO AGREE, WE WERE PROBABLY ONLY A FEW MORE CHUCK HOLES AWAY! WILL HYUNDAI NOTIFY CURRENT OWNERS OF ANY OF THESE CARS REGARDLESS OF WHICH STATE & REMEDY CORRECTLY?? WILL HYUNDAI, OR GOVERNMENT PUT OUT TSB'S OR PSA'S ALERTING ANY CURRENT OWNERS OF THE POTENTIALLY CATASTROPHIC CONDITION WHICH MAY COST SOMEONE THEIR LIFE? *TR

WHILE DRIVING CLOSE TO HOME MY HYUNDAI SONATA 1999 STARTED PULLING TO THE RIGHT , GETTING MORE SEVERE BY THE MINUTE. I DECIDED TO GO HOME. BY THE TIME I GOT HOME THE FRONT RIGHT WHEEL WAS LEANING TOWARDS THE OUTSIDE OF CAR. I TOOK THE WHEEL OFF AND DISCOVERED THAT THE LOWER FRONT CONTROL ARM SEPARATED FROM THE FRAME BECAUSE OF SEVERE CORROSION IN THE SUB FRAME OF CAR. *TR

TL* - THE CONTACT HAS A 1999 HYUNDAI SONATA. THE CONTACT STATED THAT ON 03/22/2007 THE REVERSE GEAR WOULD NOT ENGAGE. SHE SAID THAT IT WOULD GO FORWARD JUST A LITTLE, BUT IT WILL NOT ENGAGE IN REVERSE. THE CONTACT HAD HER VEHICLE TOWED TO A TRANSMISSION SPECIALIST BECAUSE SHE WAS TOLD THAT SHE NEEDED A NEW TRANSMISSION. THE FAILURE MILEAGE WAS 40000 AND THE CURRENT MILEAGE WAS 41000. *AK

DT: CONSUMER OWNED A 1999 HYUNDIA SONATA. CONSUMER HAD TAKEN VEHICLE TO THE DEALER BECAUSE IT WAS OVERHEATING. THEY FLUSHED RADIATOR, CLEANED THE INSIDE AND OUTSIDE, AND REPLACED THE COOLANT. ALSO, PUT A NEW DRAINING PLUG IN THE RADIATOR. THE DEALER SAID THAT THERE WAS NOTHING WRONG WITH THE COOLING FAN. THIRTEEN DAYS LATER ON 6-28-05 WHILE VEHICLE WAS PARKED AT A STORE IT CAUGHT ON FIRE. WHEN THE CONSUMER TOOK IT TO THE DEALER, THEY TOLD HIM THAT ALTHOUGH HE WAS NO EXPERT IT WAS THE BATTERY THAT BLUE OUT. THE CONSUMER BELIEVED THAT IT WAS THE COOLING FAN THAT CAUGHT ON FIRE. THE BATTERY WAS STILL PARTIALLY THERE AND THE COOLING FAN MELTED. HE CONTACTED THE MANUFACTURER, THEY TOLD HIM IT WOULD BE UP TO THE DEALER TO DETERMINE WHAT HAPPENED. THE CONSUMER SAID THAT HE COULD NOT EVEN GET A FIRE MARSHAL TO INSPECT THE DAMAGE. THE VEHICLE IS CURRENTLY AT THE DEALERSHIP. THE FIREMEN THAT CAME TO PUT FIRE OUT DID MAKE A REPORT. TO THE BEST OF THE CONSUMER'S KNOWLEDGE THERE WAS NO DAMAGE TO ANY OTHER VEHICLE. *AK *TT

THE AIR BAG LIGHT STAYS ON. THE DEALER STATED THAT THE WIRING HARNESS WAS DEFECTIVE. *JB

I WAS DRIVING HOME FROM WORK ON JAN 30TH, 2015 AND THE CAR STARTED PULLING TO THE RIGHT. THE NEXT DAY, SAT THE 31ST, I JACKED UP THE RIGHT FRONT OF THE CAR TO SEE WHY THE CAR STEERED TO THE RIGHT. I FOUND THE LOWER WHEEL ASSEMBLY ATTACHMENT TO THE FRAME HAD COME LOOSE. THAT WAS BECAUSE THE FRAME HAD THREE OF FOUR SIDES RUSTED THRU. THE CONDITION COULD HAVE CAUSED A MORE SEVERE ACCIDENT IF THE ATTACHMENT TO THE FRAME HAD PULLED COMPLETELY APART. I WILL CHECK WITH HYUNDAI TO SEE WHAT THEY CAN DO ABOUT IT. THANKS FOR LISTENING. [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR

AFTER REMOVING THE DRIVERS FRONT WHEEL I NOTICED THE CONTROL ARM ATTACHMENT POINT SEVERELY RUSTED, & THE SUB FRAME CRACKED READY TO BREAK. I KNOW ABOUT THE RECALL. UNFORTUNATELY NEBRASKA ALONG WITH OTHER STATES WERE NOT INCLUDED. THIS CAR WAS WELL MAINTAINED BY THE ORIGINAL OWNER, & DRIVEN VERY LITTLE IN SALT/ SNOW CONDITIONS. SHE PURCHASED @ APPROX. 80 YEARS OF AGE. NHTSA SHOULD TAKE A LOOK AT THIS AGAIN. WATER BEING TRAPPED IN THE SUB FRAMES IS THE REAL PROBLEM, SALT MAY HAVE ONLY MADE THE FAILURE HAPPENED A BIT SOONER. I HAVE TALKED WITH HYUNDAI CUSTOMER ASSISTANCE, & WAS TOLD THE CAR WOULD NOT BE COVERED BY THE RECALL. I LIVE 8 MILES AWAY FROM IOWA, WHICH IS COVERED BY THE RECALL. OMAHA DOES USE SALT ON THE STREETS. 14 -15 YEARS FOR A SUB FRAME TO ROT AWAY SEEMS QUITE SHORT. THE PROBLEM IS A DESIGN DEFECT NOT ALLOWING THE WATER TO GET OUT. NO STATES SHOULD HAVE BEEN LEFT OUT! WHO DOESN'T WASH THEIR CAR REGULARLY? HOW MANY 1999-2004 MODELS OF THIS CAR ARE STILL ON THE ROAD? FORTUNATELY FOR OUR FAMILY WE NOTICED THE STEERING WHEEL SIGNIFICANTLY OUT OF POSITION, & BOTH FRONT WHEELS LEANING IN AT THE TOP. SEPARATION OF THE CONTROL ARM FROM THE FRAME WOULD NOT PRETTY AT A HIGHER RATE OF SPEED. PEOPLE THAT HAVE LOOKED AT THE PICTURES I TOOK OF BOTH SIDES ON THIS CAR SEEM TO AGREE, WE WERE PROBABLY ONLY A FEW MORE CHUCK HOLES AWAY! WILL HYUNDAI NOTIFY CURRENT OWNERS OF ANY OF THESE CARS REGARDLESS OF WHICH STATE & REMEDY CORRECTLY?? WILL HYUNDAI, OR GOVERNMENT PUT OUT TSB'S OR PSA'S ALERTING ANY CURRENT OWNERS OF THE POTENTIALLY CATASTROPHIC CONDITION WHICH MAY COST SOMEONE THEIR LIFE? *TR

I PURCHASED MY 1999 SONATA FROM A USED CAR DEALER & HAVE HAD NUMEROUS PROBLEMS WITH THE CAR, ITS BEEN A NIGHTMARE, ONE PROBLEM AFTER ANOTHER!!!! THE CRANKSHAFT SENSOR HAD TO BE COMPLETELY REPLACED BECAUSE THE COMPONENT HAD SEVERELY MELTED, ISSUES WITH THE TRANSMISSION, ABS/AIRBAG WARNING LIGHT ON, & HAVE HAD TO CHANGE OUT THE HALF SHAFT ON BOTH DRIVERS/PASSENGER SIDE, NUMEROUS TIRES, BRAKES BUT THE MOST SEVERE OF ALL THE PROBLEMS WHICH PUTS MY SAFETY, MY 12 YR OLD SON & FIANCE'S SAFETY, ALONG WITH FAMILY/FRIEND'S SAFETY AT RISK IS THE COMPLETE CORROSION OF THE SUBFRAME I TOO TO A MECHANIC TODAY & HE TOLD ME TO NOT DRIVE THIS CAR FOR ANYTHING BECAUSE IT WILL RESULT IN AN ACCIDENT WHERE I CAN POTENTIALLY END UP HURTING MYSELF OR OTHER INNOCENT BYSTANDERS BECAUSE HYUNDAI MADE A DEFECTIVE SUBFRAME ESPECIALLY FOR US THAT LIVE & DRIVE IN HAZARDOUS CONDITIONS OF THE WINTRY/ICY ELEMENTS FOR 5+MONTHS OUT OF THE YEAR IN UPSTATE NEW YORK!!! I WILL BE CALLING HYUNDAI'S CUSTOMER ASSISTANCE CTR & FUCCILLO HYUNDAI(LOCAL DEALER)& THE ATTORNEY GENERAL FOR NEW YORK. I CANNOT IMAGINE WHAT COULD'VE HAPPENED IF I DROVE OVER A POT HOLE RESULTING IN MY TIRE(S) FALLING OFF ESPECIALLY IF I WAS ON THE EXPRESSWAY DOING 55MPH MY LOVED ONES OR OTHER'S LOVED ONES, & MYSELF COULD'VE BEEN SEVERELY INJURED OR WORSE DEAD DUE TO HYUNDAI USING A SUBFRAME THAT WOULD SEVERELY CORRODE THE SUBFRAME ESPECIALLY IN THE "SNOW BELT" STATES!!!!! I JUST HOPE THAT I DO NOT HAVE A DIFFICULT TIME HAVING HYUNDAI FIX THE PROBLEM IN A SPEEDY FASHION WITHOUT TRYING TO STRONG ARM ME INTO PAYING FOR REPAIRS THAT I AM NOT RESPONSIBLE FOR BECAUSE IT IS AN INCONVENIENCE BEING WITHOUT A VEHICLE NOW UNTIL IT GETS REPAIRED. *TR

THE BRAKES ON THIS VEHICLE HAVE SQUEALED SINCE THE FIRST FEW MONTHS AFTER I BOUGHT THE CAR. I HAD LEARNED TO LIVE WITH IT. I KEEP MY WINDOWS UP AND RADIO ON SO I CAN'T HEAR THEM SQUEAL. LATELY, THOUGH, THEY HAVE BECOME LOUDER AND MORE CONSTANT. I HAVEN'T GONE TO THE DEALER WITH A NEW COMPLAINT, BECAUSE THEY ASSURED THE LAST 2 TIMES I COMPLAINED THAT THERE WAS NOTHING WRONG AND "THAT'S JUST HYUNDAI BRAKES. THEY'LL STOP YOU, BUT THEY ARE LOUD!" WHATEVER, SURELY THERE IS SOMETHING THAT CAN BE DONE. I HAVE FRIENDS WITH OTHER TYPES OF HYUNDAI'S AND THEIR BRAKES DON'T DO THIS. MR

I PURCHASED MY 1999 SONATA FROM A USED CAR DEALER & HAVE HAD NUMEROUS PROBLEMS WITH THE CAR, ITS BEEN A NIGHTMARE, ONE PROBLEM AFTER ANOTHER!!!! THE CRANKSHAFT SENSOR HAD TO BE COMPLETELY REPLACED BECAUSE THE COMPONENT HAD SEVERELY MELTED, ISSUES WITH THE TRANSMISSION, ABS/AIRBAG WARNING LIGHT ON, & HAVE HAD TO CHANGE OUT THE HALF SHAFT ON BOTH DRIVERS/PASSENGER SIDE, NUMEROUS TIRES, BRAKES BUT THE MOST SEVERE OF ALL THE PROBLEMS WHICH PUTS MY SAFETY, MY 12 YR OLD SON & FIANCE'S SAFETY, ALONG WITH FAMILY/FRIEND'S SAFETY AT RISK IS THE COMPLETE CORROSION OF THE SUBFRAME I TOO TO A MECHANIC TODAY & HE TOLD ME TO NOT DRIVE THIS CAR FOR ANYTHING BECAUSE IT WILL RESULT IN AN ACCIDENT WHERE I CAN POTENTIALLY END UP HURTING MYSELF OR OTHER INNOCENT BYSTANDERS BECAUSE HYUNDAI MADE A DEFECTIVE SUBFRAME ESPECIALLY FOR US THAT LIVE & DRIVE IN HAZARDOUS CONDITIONS OF THE WINTRY/ICY ELEMENTS FOR 5+MONTHS OUT OF THE YEAR IN UPSTATE NEW YORK!!! I WILL BE CALLING HYUNDAI'S CUSTOMER ASSISTANCE CTR & FUCCILLO HYUNDAI(LOCAL DEALER)& THE ATTORNEY GENERAL FOR NEW YORK. I CANNOT IMAGINE WHAT COULD'VE HAPPENED IF I DROVE OVER A POT HOLE RESULTING IN MY TIRE(S) FALLING OFF ESPECIALLY IF I WAS ON THE EXPRESSWAY DOING 55MPH MY LOVED ONES OR OTHER'S LOVED ONES, & MYSELF COULD'VE BEEN SEVERELY INJURED OR WORSE DEAD DUE TO HYUNDAI USING A SUBFRAME THAT WOULD SEVERELY CORRODE THE SUBFRAME ESPECIALLY IN THE "SNOW BELT" STATES!!!!! I JUST HOPE THAT I DO NOT HAVE A DIFFICULT TIME HAVING HYUNDAI FIX THE PROBLEM IN A SPEEDY FASHION WITHOUT TRYING TO STRONG ARM ME INTO PAYING FOR REPAIRS THAT I AM NOT RESPONSIBLE FOR BECAUSE IT IS AN INCONVENIENCE BEING WITHOUT A VEHICLE NOW UNTIL IT GETS REPAIRED. *TR

TL*THE CONTACT OWNS A 1999 HYUNDAI SONATA. THE VEHICLE HAS FIRESTONE P195 TIRES. WHILE DRIVING 65 MPH, THE FRONT END OF THE VEHICLE BEGAN TO SHAKE. THE CONTACT DECELERATED AND THEN HEARD A LOUD BANG. THE VEHICLE BECAME VERY DIFFICULT TO CONTROL. SHE PULLED TO THE SIDE OF THE ROAD AND CALLED HYUNDAI ROADSIDE ASSISTANCE. THE VEHICLE WAS GOING TO BE TOWED TO THE DEALER; HOWEVER, IT WAS SUNDAY AND THEY WERE CLOSED. THE VEHICLE WAS TOWED TO PEP-BOYS INSTEAD AND THEY REPLACED THE TIRE. THE MECHANIC STATED THAT BOTH FRONT TIRES NEEDED TO BE REPLACED. THE FAILURE AND CURRENT MILEAGES WERE 103,000. UPDATED 09/15/08 *BF UPDATED 09/24/08. *JB

AIR BAG SENSOR LIGHT COMES ON AND STAYS ON. *AK CONSUMER ALSO STATED THE SEATBELT LIGHT AND ENGINE LIGHT STAYED ON FOR 5 DAYS.*JB

SEAT BELT AND HEADLIGTHS COME ON AND STAYS ON. DEALER CONTACTED.*AK

CONSUMER LOSS CONTROL AND HIT A SOLID BARRIER AND NONE OF THE AIRBAGS DEPLOYED. DRIVER SUSTAINED A HEAD INJURY. PRIOR TO THE ACCIDENT THE VEHICLE WAS TAKEN TO THE DEALER BECAUSE THE AIR BAG LIGHT ILLUMINATED. THE DEALER REMOVED AND REPLACED THE PASSENGER SEAT AIR BAG MODULE. THE DEALER ALSO PERFORMED RECALL 02V105000 RELATED TO THE SIDE IMPACT AIR BAG WIRING HARNESS ROUTING. THE REAR DEFOGGER BUTTON FLASHED INTERMITTENTLY AND THE A/C AND DEFOGGER WERE INOPERATIVE. THE DEALER REPLACED THE CONTROL HEAD. THE OUTSIDE REARVIEW MIRRORS WOULD NOT MOVE RIGHT OR LEFT. DEALER FOUND BREAK IN WIRING IN RIGHT KICK PANEL. THE CHECK ENGINE LIGHT ILLUMINATED. THE DEALER REPLACED THE CANISTER PURGE VALVE. * PH *AK *TS

THE DRIVERS SIDE WINDOW FAILED TO ROLL DOWN.*JB

"CHECK ENGINE" LIGHT COMES ON AND OFF, NO ISSUE FOR FEW MONTHS, RECENTLY WHILE STOPPING AT RED LIGHT WITH FOOT ON BRAKE, THE RPM STARTED INCREASING AND VEHICLE TRIED TO MOVE FORWARD, IT TOOK ME BY SURPRISE AND I WAS ABOUT TO CRASH INTO THE VEHICLE IN FRONT OF ME. THIS HAPPENED TO ME FEW TIMES ALREADY, AND EVERYTIME IT IS SCARY. I HAD TO PUSH HARD ON THE BRAKE TO PREVENT THE CAR FROM MOVING. I TIRED TO CHANGE THE GEAR FROM D TO N, AND THAT HELPED PREVENTING THE CAR FROM MOVING BUT THE RPM JUMPED EVEN HIGHER AND THE ENGINE MADE LAUD NOISE. I TOOK THE CAR TO A MECHANIC, THEY CONNECT IT TO THE COMPUTER AND SAID THE COOLANT TEMP SENSOR AND CRANK POSITION SENSOR NEED TO BE REPLACED, THAT IS $140 PARTS PLUS 4 HOURS OF LABOR. TALKED TO HYUNDAI DEALER, THEY SAID NEVER HEARD OF THIS PROBLEM, AND THERE IS NO RECALL ON IT, SO THEY HAVE TO DO THEIR OWN TROUBLESHOOT AND I'M RESPONSIBLE FOR THE BILL. VEHICLE HAS ABOUT 90K MILES ON IT, I DID NOT FIX IT YET, BUT I'M MINIMIZING MY DRIVING ON IT. *TR

ENGINE CHECK LIGHT CAME ON. CONSUMER TOOK VEHICLE TO DEALER, AND THEY COULD NOT FIND THE PROBLEM. A YEAR LATER, ENGINE CHECK LIGHT CAME BACK ON. THIS TIME THERE WAS A GRINDING NOISE WHEN PRESSING GAS. WHILE ON HIGHWAY WITH FOOT ON BRAKE, VEHICLE STARTED TO ACCELERATE. WHEN CHANGING FROM PARK TO DRIVE VEHICLE WOULD REV REALLY HIGH LIKE IT WANTED TO TAKE OFF. PLEASE PROVIDE ANY FURTHER INFORMATION.*AK

SEAT BELT AND HEADLIGTHS COME ON AND STAYS ON. DEALER CONTACTED.*AK

VEHICLE REPAIR LOG OF WINDSHIELD WIPERS DAMAGED. *TT

I PURCHASED MY 1999 SONATA FROM A USED CAR DEALER & HAVE HAD NUMEROUS PROBLEMS WITH THE CAR, ITS BEEN A NIGHTMARE, ONE PROBLEM AFTER ANOTHER!!!! THE CRANKSHAFT SENSOR HAD TO BE COMPLETELY REPLACED BECAUSE THE COMPONENT HAD SEVERELY MELTED, ISSUES WITH THE TRANSMISSION, ABS/AIRBAG WARNING LIGHT ON, & HAVE HAD TO CHANGE OUT THE HALF SHAFT ON BOTH DRIVERS/PASSENGER SIDE, NUMEROUS TIRES, BRAKES BUT THE MOST SEVERE OF ALL THE PROBLEMS WHICH PUTS MY SAFETY, MY 12 YR OLD SON & FIANCE'S SAFETY, ALONG WITH FAMILY/FRIEND'S SAFETY AT RISK IS THE COMPLETE CORROSION OF THE SUBFRAME I TOO TO A MECHANIC TODAY & HE TOLD ME TO NOT DRIVE THIS CAR FOR ANYTHING BECAUSE IT WILL RESULT IN AN ACCIDENT WHERE I CAN POTENTIALLY END UP HURTING MYSELF OR OTHER INNOCENT BYSTANDERS BECAUSE HYUNDAI MADE A DEFECTIVE SUBFRAME ESPECIALLY FOR US THAT LIVE & DRIVE IN HAZARDOUS CONDITIONS OF THE WINTRY/ICY ELEMENTS FOR 5+MONTHS OUT OF THE YEAR IN UPSTATE NEW YORK!!! I WILL BE CALLING HYUNDAI'S CUSTOMER ASSISTANCE CTR & FUCCILLO HYUNDAI(LOCAL DEALER)& THE ATTORNEY GENERAL FOR NEW YORK. I CANNOT IMAGINE WHAT COULD'VE HAPPENED IF I DROVE OVER A POT HOLE RESULTING IN MY TIRE(S) FALLING OFF ESPECIALLY IF I WAS ON THE EXPRESSWAY DOING 55MPH MY LOVED ONES OR OTHER'S LOVED ONES, & MYSELF COULD'VE BEEN SEVERELY INJURED OR WORSE DEAD DUE TO HYUNDAI USING A SUBFRAME THAT WOULD SEVERELY CORRODE THE SUBFRAME ESPECIALLY IN THE "SNOW BELT" STATES!!!!! I JUST HOPE THAT I DO NOT HAVE A DIFFICULT TIME HAVING HYUNDAI FIX THE PROBLEM IN A SPEEDY FASHION WITHOUT TRYING TO STRONG ARM ME INTO PAYING FOR REPAIRS THAT I AM NOT RESPONSIBLE FOR BECAUSE IT IS AN INCONVENIENCE BEING WITHOUT A VEHICLE NOW UNTIL IT GETS REPAIRED. *TR

HI, I BOUGHT MY 1999 HYUNDAI SONATA FROM A PRIVATE PERSON NOV.2007. I WAS DRIVING THE CAR TO THE STORE WHEN ALL OF A SUDDEN THE RIGHT FRONT WHEEL WENT BACK INTO THE WHEEL WELL. I HAD IT TOWED TO A GARAGE TO LIFT IT TO SEE WHAT HAPPENED. THE ENGINE CRADLE WAS SO ROTTED THAT MY HALF SHAFT PULLED OUT AND BROKE. THE CONTROL ARM COMPLETELY ROTTED OFF THE CRADLE. THIS IS WHAT I CAN PLAINLY SEE AS A SAFETY HAZARD. I COULD HAVE HAD A WRECK HAD I BEEN GOING ANY FASTER. *TR

FUEL LEAK AND DEALER FOUND THAT FUEL TANK HAD IMPLODED DUE TO AFTERMARKET GAS GAP NOT SEALING PROPERLY. I BOUGHT A GAS CAP FROM AUTO TRACK THAT MANUFACTURED BY STANT.*AK

MAY 27, 1999: CAR WAS TAKEN IN DUE TO LOW FUEL LIGHT REMAINING ON AT ALL TIMES. SENDING UNIT WAS ORDERED. JULY 8, 1999: SENDING UNIT WAS REPLACED WITH NEW UNIT. LOW FUEL LIGHT CONTINUED TO REMAIN ON AT ALL TIMES. SERVICE DEPARTMENT ORDERED ANOTHER PART (UNSURE OF WHAT THIS PART WAS). JULY 22, 1999: RETURNED CAR TO SERVICE DEPT DUE TO LOW FUEL LIGHT REMAINING ON AT ALL TIMES. DESCRIPTION OF SERVICE ON THIS DATE: BOARD-PRIN, GAUGE ASSY. AFTER THIS SERVICE, LIGHT NO LONGER REMAINS ON AT ALL TIMES, BUT DURING THE NEXT FEW MONTHS, WE NOTICE THE LOW FUEL LIGHT DOES NOT COME ON AT ALL, EVEN WHEN GAS GAUGE FALLS BELOW EMPTY. SEPT 16, 1999: (NEW COMPLAINT) REPORTED THAT BOTH FRONT DOOR SPEAKERS CRACKLE AND POP WHEN RADIO IS ON AND FRONT DOORS ARE OPEN. SERVICE DEPT CHECKS WIRING, BUT PROBLEM CONTINUES UPON PICKING UP THE CAR. WE ALSO REPORT THAT POWER DOOR LOCKS WILL LOCK ON THEIR OWN. THIS PROBLEM IS NOT FIXED. SERVICE DEPT SAYS THEY CANNOT DUPLICATE PROBLEM. DECEMBER 7, 1999: WE REPORT ONCE AGAIN THAT SPEAKER WIRES POP AND CRACKLE MAINLY ON PASSENGER SIDE DOOR WHILE RADIO IS ON. SERVICE DEPT REPORTS THEY TEST DROVE CAR, BUT COULD NOT DUPLICATE PROBLEM. WE ALSO ONCE AGAIN REPORT THAT POWER DOOR LOCKS WILL LOCK ON THEIR OWN WHILE DRIVING. SERVICE DEPT TEST DROVE CAR, BUT COULD NOT DUPLICATE PROBLEM. JULY 3, 2000: REPORT CONTINUED PROBLEM WITH FRONT DOOR SPEAKERS, POWER DOOR LOCKS, AND LOW FUEL LIGHT. PARTS ORDERED. SEPT 12, 2000: SENDING UNIT REPLACED AGAIN, HOWEVER LIGHT STILL DOES NOT COME ON WHEN GAS GAUGE FALLS BELOW EMPTY. SERVICE DEPT REPAIRED SHORT TO GROUND WIRES TO FIX POPPING IN FRONT DOOR SPEAKERS. UPON RETURN HOME, PROBLEM CONTINUES. PROBLEM WITH POWER DOOR LOCKS ALSO CONTINUES.

WHILE DRIVING AT VARIOUS SPEEDS VEHICLE WOULD START TO JERK. WOULD NEED TO DOWNSHIFT TO COMPENSATE FOR JERKING. WOULD STALL OUT INTERMITTENTLY. GUAGES WOULD STOP WORKING. HAVE TAKEN VEHICLE TO DEALERSHIP, AND WAS INFORMED BY MECHANIC COULD NOT LOCATE CAUSE OF PROBLEM. MECHANIC DID NOT TEST DRIVE VEHICLE.*AK

ALTERNATOR WENT OUT WHICH MADE THE ELECTRICAL SYSTEM TO GO OUT. ENTIRE DASHBOARD WAS NOT WORKING, ALSO, ABS BRAKES AND ENGINE CHECK LIGHTS KEPT BLINKING. THERE WAS AN ELECTRICAL SMELL. DEALER REPLACED ALTERNATOR.*AK

THREE OF THE VEHICLE'S WHEEL RIMS CRACKED. *NM THE TECHNICIAN DISCOVERED ONE CRACKED RIM IN AUGUST 2004 AND REPLACED IT. ON DEC 21, 2004 THE CONSUMER HEARD A NOISE IN THE FRONT END AND TOOK THE VEHICLE TO THE DEALER FOR A CHECKUP. THE TECHNICIAN DISCOVERED THAT TWO OTHER RIMS HAD CRACKED. TWO NEW RIMS WERE INSTALL THE FOLLOWING DAY. *NM

VEHICLE REPAIR LOG OF WINDSHIELD WIPERS DAMAGED. *TT

TL*THE CONTACT OWNS A 1999 HYUNDAI SONATA. THE CONTACT WAS EXPERIENCING STEERING WHEEL FAILURE AND WAS INFORMED THAT THE AIR CONDITIONING UNIT LEAKED WATER ONTO THE FRAME AND RUSTED OUT THE STEERING COLUMN. THE FAILURE COULD HAVE RESULTED IN A CRASH. HYUNDAI STATED THAT HER WARRANTY DOES NOT COVER THE FAILURE. WHILE DRIVING FORWARD AT 60 MPH, THE STEERING WHEEL WAS ANGLED TO THE LEFT. THE CURRENT AND FAILURE MILEAGES WERE 95,000. THE CONSUMER STATED THE NEW SUBFRAME WAS INSTALLED AT OWNER'S EXPENSE OF $1,384.55. UPDATED 12/12/07 *TR UPDATED 12/12/2007 *BF