2000 Hyundai Sonata Owner Complaints

Rt passenger side wheel clunks when turning, loud noise when moving took to dealer they found nothing wrong. I returned to dealer again a couple weeks later to confirm my a arm needs repairs, safety issues airbag’s light remaining lit told repairs not available for year and make iwas told to deal with it by dealer even if it was a safety issue, driving car doesn’t matter what speed my back end sounds like it is falling apart and my car will slam out or into gear I have reviewed recalls and safety issues and I have been told that they have been closed even if my car is currently having issues with the vehicle recalls ie..slamming in and out of gear, arm issues and clunky noises on turns and driving,rear end clunk sounds like no shocks or struts

NHTSA ID

11458173

Incident

Jan 5, 2022

STEERING AND STABILITY UNSTABLE. MECHANIC TELLS ME THAT THE REAR SUB FRAME IS RUSTY AND CRACKED. THE ENTIRE FRAME WAS REPLACED AROUND 2010 BECAUSE OF A RECALL. WHEN YOU HIT A BUMP LOSE TRACTION AND BECOMES UNSTABLE. WANT TO KNOW IF THE REPLACEMENT FRAME HAS A WARRANTY. WANT TO KEEP THE CAR STILL RUNS GREAT. 170,000 MILES

NHTSA ID

11185436

Incident

Feb 19, 2018

Mileage

170,000 mi

I UNDERSTAND THERE IS AN AIRBAG RECALL ON SOME MODEL CARS, I DRIVE A 2000 HYUNDAI SONATA GLS THAT HAS AN AIRBAG LIGHT ACTIVATED ON THE DASHBOARD. I DON'T KNOW IF THE AIRBAG IS DEFECTIVE, I SHOULD NOT DRIVE IT, OR WHAT TO DO, PLEASE ADVISE. THIS AIRBAG LITE ON THE DASHBOARD GOES ON AS SOON AS I START THE ENGINE, AND STAYS ON ALL THE TIME THE ENGINE IS RUNNING, THIS AIRBAG LIGHT DOES NOT GO OFF UNTIL I TURN THE ENGINE OFF.

NHTSA ID

11100758

Incident

May 3, 2018

TL* THE CONTACT OWNS A 2000 HYUNDAI SONATA. WHILE DRIVING 5 MPH, THE FRONT PASSENGER SIDE WHEEL DETACHED FROM THE VEHICLE. THE VEHICLE WAS TOWED TO AN AUTO SHOP WHERE THE FAILURE WAS DIAGNOSED AS A CONTROL ARM FAILURE AND RUSTED SUBFRAME. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 140,000.

NHTSA ID

10960047

Incident

Feb 20, 2017

Mileage

140,000 mi

"TAKADA RECALL " TRANSMISSION DON'T SHIFT CHECK ENGINE LIGHT IS ON IT IS SUCK IN 3RD GEAR NEXT TIME START CAR NO CHECK ENGINE LIGHT CAR SHIFTS BUT BANGS HARD IN AND OUT OF NEXT GEAR THEN CHECK ENGINE LIGHT COMES ON AND CAR IS STUCK IN THIRD GEAR.ALSO AIR BAG LIGHT IS ON ALL TIME.

NHTSA ID

10957154

Incident

Feb 12, 2017

Mileage

212,234 mi

WHILE SLOWING DOWN TO MAKE A TURN ON SIDE ROAD, THE LOWER LEFT CONTROL ARM PULLED COMPLETELY OUT OF THE FRAME. INSPECTION AFTER FOUND LARGE HOLE RUSTED COMPLETELY THROUGH THE FRAME RAIL. INSPECTED RIGHT SIDE AND FRAME HAS SAME TYPE OF RUSTED AND MISSING FRAME SEGMENTS. THANKFULLY THIS HAPPENED AT LOW SPEED AND NOT ON THE INTERSTATE WHERE OUTCOME COULD HAVE BEEN VERY BAD. DOING SOME RESEARCH I HAVE FOUND THAT THIS APPEARS TO HAVE BEEN A KNOWN PROBLEM WITH THIS MODEL FOR SEVERAL YEARS BEGINNING WITH 1999 MODEL. *TR

NHTSA ID

10702994

Incident

Mar 31, 2015

Mileage

173,000 mi

2000 HYUNDAI SONATA. CONSUMER WRITES IN REGARDS TO VEHICLE RUSTED REAR CROSS MEMBER. *SMD THE CONSUMER STATED IN DECEMBER 2008, THE FRONT CROSS MEMBER BECAME RUSTED. THE DEALER REPLACED THE FRONT CROSS MEMBER AS IT WAS UNDER RECALL DUE TO RUST. THE CONSUMER STATED THE REAR CROSS MEMBER FRAME RUSTED AND ABOUT TO BREAK APART. WHEN THE CONSUMER WENT TO THE DEALER, HE WAS INFORMED THE REAR CROSS MEMBER WAS NOT UNDER RECALL. AND THE COST TO REPLACE IT, WAS $3,000. *JB

NHTSA ID

10694558

Incident

Dec 1, 2008

THE FUEL TANK ON 2000 HYUNDAI SONATA IS CRACKED AND LEAKING GASOLINE. THERE IS A STRONG GAS ODOR IN THE CABIN. THE FIRE DEPARTMENT AND HAZMAT TEAM RESPONDED. I COULD HAVE BEEN KILLED IN AN EXPLOSION IF THE GAS VAPORS IGNITED. THERE IS A RECALL FOR THE PREVIOUS MODEL YEAR HYUNDAI SONATA. THE FUEL TANK CAN CRACK AND LEAK GASOLINE. THAT IS WHAT HAPPENED TO MY 2000 SONATA. THE CAR IS NOW AT A DEALERSHIP WHERE THEY ARE REPLACING THE SUBRAME BECAUSE IT HAS A RECALL FOR SEVER RUST. THEY DO NOT WANT TO RECALL THE ISSUE WITH THE RUSTED, CRACKED FUEL TANK. *TR

NHTSA ID

10662459

Incident

Dec 4, 2014

Mileage

110,000 mi

AIR BAG LIGHT CAME ON AND STAYED ON. DEALER (TAYLOR HYUNDAI) DENIED THAT THERE WAS AN AIR BAG RECALL ON THIS MODEL. *TR

NHTSA ID

10660127

Incident

Oct 21, 2013

Mileage

53,231 mi

WHEN DRIVING TO WORK THE WHEEL START TO PULL. WHEN I GOT TO WORK I TOOK A LOOK AT THE FRAME THERE WAS A 2 INCH CRACK IN ONE SIDE AND A 1/4 INCH BY 20 INCH CRACK IN THE OTHER SIDE. WHEN I TOUCH IT THE FRAME WAS ROTTEN. *TR

NHTSA ID

10595385

Incident

May 23, 2014

Mileage

16,200 mi

WHEN I TRY TO FILL THE VEHICLE WITH GAS IT STOPS EVERY FEW CENTS, SIMULAR TO WHEN THE GAS TANK IS FULL, EVEN WHEN IT IS ON EMPTY. IT TAKES UPWARDS OF 30-45 MINUTES TO FILL THE GAS TANK. SOMETIMES THE GAS GAUGE IS ON LOW WHEN I TRY TO FILL IT UP BUT IT STOPS FILLING SO OFTEN THAT I HAVE TO CHANGE PUMPS TO BE ABLE TO FILL MY TANK TO FULL. I HAVE ALSO HAD THE GAS SPILL OUT THE TOP OF THE TANK JUST BY TRYING TO PUT ENOUGH GAS IN MY VEHICLE TO MAKE IT HOME. I HAVE DONE QUITE A BIT OF RESEARCH ON THE ISSUE AND HAVE FOUND IT TO BE A COMMON PROBLEM AMONG HYUNDAI VEHICLE. WE BOUGHT THIS CAR TO HAVE A GOOD, RELIABLE VEHICLE FOR OUR DAUGHTER TO DRIVE. I DO NOT FEEL SAFE ALLOWING HER TO GO ON A LONG ROAD TRIP WHEN SHE HAS TO SPEND SO LONG FILLING THE CAR WITH GAS. *TR

NHTSA ID

10561374

Incident

Oct 7, 2013

WHILE DRIVING MY 2000 HYUNDAI SONATA ON GOOD ROAD AND APPROACHING A TRAFFIC LIGHT IN THE LEFT THROUGH-LANE OF A MULTILANE STREET, I MADE A QUICK STOP (NOT AND EMERGENCY STOP) WHEN THE LIGHT TURNED YELLOW. THE ROAD WAS IN GOOD CONDITION AND DRY, AND THE OUTSIDE TEMPERATURE WAS ABOUT ABOUT 80 DEGREES F. UPON MAKING THIS STOP THE CAR PULLED UNUSUALLY SHARPLY TO THE RIGHT - IF THERE HAD BEEN A CAR IN THE RIGHT LANE, I WOULD HAVE HIT IT. AFTER THIS STOP, THE FRONT TIRE(S) MADE UNUSUAL SQUEELING NOISES UPON TURNING, AND THE STEERING FELT UNUSUAL AND SHAKEY. I DROVE THE CAR DIRECTLY (ABOUT A MILE) TO THE PLACE WE WERE VISITING IN LAS VEGAS AND THE NEXT MORNING TOOK THE CAR DIRECTLY TO A HYUNDAI DEALER. UPON INSPECTION THE DEALER FOUND THAT THE FRONT SUSPENSION FRAME CROSSMEMBER (FRONT SUBFRAME) HAD A CORROSION HOLE THROUGH THE FRONT SUBBFRAME AND THE FRONT SUBFRAME HAD FAILED, CAUSING THE RIGHT FRONT (PASSENGER) TIRE TO MOVE OUT OF POSITION AND SITTING AT AN ANGLE. THE DEALER'S ADVICE WAS THAT THIS WAS A SAFETY PROBLEM, AND IT COULD FURTHER FAIL AND RESULT IN LOSS OF STEERING CONTROL. THEY ADVISED THAT I DO NOT DRIVE THE CAR UNTIL THIS THIS FRONT SUBFRAME WAS REPLACED. THIS IS A REPLACEABLE PIECE - WHICH WAS ORDERED, AND REPLACEMENT PLANNED. THE CAR WAS LEFT WITH THE HYUNDAI DEALER, AND NOT DRIVEN FURTHER. THIS SITUATION IS ESSENTIALLY IDENTICAL TO NHTSA REFERENCE NUMBER 13V354000 FOR THE REAL SUSPENSION FOR SOME HYUNDAI VEHICLES THAT LED TO HYUNDAI RECALL CAMPAIGN 113 APPROVED IN SEPT 2013. HYUNDAI RECORDS SHOW THIS CAR WAS PURCHASED IN ILLINOIS (ONE OF THE APPROVED 113-RECALL STATES) AND IT WAS DRIVEN THERE FOR ABOUT 4 YEARS OR SO. I AM THE SECOND OWNER. HYUNDAI HAS ISSUED TECHNICAL SERVICE BULLETIN CAMPAIGN NUMBER 12-01-029 DATED OCTOBER 2012 (SUPERSEDES BULLETIN 09-01-020-2) WHICH ADDRESSES THIS FRONT SUBFRAME PROBLEM, BUT, I AM TOLD, IT IS NOT AN APPROVED RECALL. *TR

NHTSA ID

10547992

Incident

Oct 10, 2013

Mileage

197,700 mi

TL* THE CONTACT OWNS A 2000 HYUNDAI SONATA. THE CONTACT STATED THAT WHILE DRIVING APPROXIMATELY 10 MPH, THE FRONT END OF THE VEHICLE COLLAPSED INTO THE PASSENGER'S SIDE WHEEL. THE CONTACT REFERENCED NHTSA CAMPAIGN ID NUMBER 09V124000 (SUSPENSION) AND CONTACTED THE MANUFACTURER, WHO ADVISED THAT THE VIN WAS NOT INCLUDED IN THE RECALL CAMPAIGN. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 100,000. RETURNED BY USPS ON 10-17-2013. SECOND ATTEMPT ON 10-31-2013 FAILED. *KB

NHTSA ID

10536071

Incident

Aug 18, 2013

Mileage

100,000 mi

TL* THE CONTACT OWNS A 2000 HYUNDAI SONATA. THE CONTACT STATED THAT THE VEHICLE WAS TAKEN TO THE DEALER FOR ROUTINE SERVICE WHEN HE WAS INFORMED THAT THE DRIVER'S SIDE UPPER STRUT MOUNT HAD PENETRATED THROUGH THE MOUNTS. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 25,000. *TR

NHTSA ID

10531558

Incident

Jul 18, 2013

Mileage

25,000 mi

RUST REAR CONTROL ARM BROKE FROM SUBFRAME, MADE NOISE ENOUGH TO TAKE TO MECHANIC WHO FOUND PROBLEM WHY IS IT THAT ONLY FRONT SUBFRAME & FRONT CONTROL ARMS WERE INCLUDED IN RECALL? THE REAR PARTS ARE ALSO RUSTING.... PARTS ARE MADE FROM SAME MATERIAL = SAME PROBLEM ... THE RECALL SHOULD INCLUDE BOTH THE FRONT AND THE BACK. WHY WOULD ONLY ONE SIDE OF THE CAR RUST AND NOT THE OTHER RIDICULOUS!! *TR

NHTSA ID

10524181

Incident

Jul 9, 2013

Mileage

135,136 mi

MY HYUNDAI DEALER HAS REFUSED TO HONOR THEIR 100,000MILES, 10 YEARS WARRANTY" MANY TIMES THAT I BRING THE CAR TO BE FIXED UNDER THE WARRANTY SINCE THE CAR WAS ONLY 8YEARS OLD AND 76,000 MILES SINCE 2008. THEY REFUSE TO FIX THE PROBLEMS THAT I EXPERIENCED BY SAYING MY CAR IS NOT LISTED IN ANY RECALL CAMPAIGN. UNFORTUNATELY THIS YEAR, ON 10/11/12, I TOOK MY CAR FOR AN ANNUAL STATE INSPECTION FOR 2000 HYUNDAI SONATA AND IT FAILS THE SAFETY INSPECTION. HERE IS WHAT IT SAYS: ***VEHICLE MEMO*** VEHICLE IS UNSAFE TO DRIVE...REAR SUB-FRAME HAS HOLE ROTTED THROUGH... DUE TO THE CURRENT FINANCIAL SITUATION, I DON'T KNOW HOW I WILL GET THIS CAR FIXED BECAUSE THE CAR IS NOW 115,000MILES AND 12 YEARS OLD AND I DON'T KNOW IF THEY WILL FIX IT. THEY HAVE CONTINUOUSLY REFUSED TO FIX MY CAR UNDER WARRANTY EVEN WHEN IT WAS CLEARLY WITHIN THE WARRANTY PERIOD AND I WAS LUCKY THEN THAT I HAVE BEEN ABLE TO PAY THE FIXES OUT OF POCKET BUT I DON'T HAVE THE LUXURY OF PAYING OUT OF POCKET THIS TIME. I AM IN NEED OF MIRACLES NOW. *TR

NHTSA ID

10480085

Incident

Oct 11, 2012

Mileage

115,428 mi

WHILE DRIVING OUR 2000 HYUNDAI SONATA MY HUSBAND'S SONATA CAME TO AN SCREECHING HALT IN WHICH HE ALMOST LOST COMPLETE CONTROL OF THE VEHICLE. FORTUNATELY, HE WAS ABLE TO PULL THE VEHICLE OVER TO THE SIDE OF THE ROAD. ONCE OUT OF THE VEHICLE, IT WAS VERY APPARENT THAT THE AXLE HAD BROKEN AND THE DRIVERS FRONT WHEEL HAD DETACHED FROM THE VEHICLE. THE VEHICLE WAS RELOCATED TO THE NEAREST HYUNDAI DEALER. IT WAS DETERMINED THAT THE DAMAGE WAS FROM HYUNDAI'S FRONT SUB FRAME CORROSION TREATMENT (CORROSION CLASS ACTION CC1) GROUP-CAMPAIGN, NUMBER 11-01-038 DATE-OCTOBER, 2011. THE DEALER COULD NOT FIND ANY RECORD THAT THIS RECALL NOTICE WAS SENT TO OUR HOME OF ADDRESS. *TR

NHTSA ID

10474232

Incident

Aug 18, 2012

TL* THE CONTACT OWNS A 2000 HYUNDAI SONATA. THE CONTACT STATED THAT WHILE THE VEHICLE WAS AT A LOCAL MECHANIC FOR TIRE MAINTENANCE, THE FRONT SUBFRAME LOWER CONTROL ARM WAS FOUND TO BE CORRODED. THE MANUFACTURER DENIED ASSISTANCE WITH THE REPAIR, BECAUSE THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 09V124000 (SUSPENSION). THE VEHICLE WAS NOT REPAIRED. THE FAILURE AND THE CURRENT MILEAGE WAS 220,000.

NHTSA ID

10465104

Incident

Jul 10, 2012

Mileage

220,000 mi

GAS LIGHT DON'T WORK, THE ODOMETER DON'T WORK, WHEN IT RAINS THE CAR LIGHTS DIME AND THE CAR ALMOST DIES... *TR

NHTSA ID

10463056

Incident

Mar 19, 2012

Mileage

133,000 mi

I WAS HEADING EASTBOUND GOING ABOUT 40 MPH. AN SUV WAS HEADING WESTBOUND AND ABOUT TO MAKE A LEFT TURN. THE SUV STRUCK MY VEHICLE AND TOTALED THE ENTIRE FRONT OF THE VEHICLE. MY AIRBAGS DID NOT DEPLOY. I AM SUPPOSED TO HAVE SIDE AND FRONT AIRBAGS. I AM LUCKY I WAS WEARING A SEAT BELT BECAUSE OTHER THAN THAT, I HAD NO OTHER PROTECTION. THIS COULD HAVE BEEN FATAL. *TR

NHTSA ID

10460359

Incident

May 30, 2012

Mileage

165,285 mi

TL* THE CONTACT OWNS A 2000 HYUNDAI SONATA. WHILE DRIVING APPROXIMATELY 10- 35 MPH, THE ENGINE STALLED WITH THE ILLUMINATION OF THE CHECK ENGINE WARNING INDICATOR. THE WARNING INDICATOR REMAINED ILLUMINATED UNTIL THE ENGINE WAS TURNED OFF. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO STATED THAT THE MASS AIR FLOW SENSOR WOULD NEED TO BE REPLACED. THE FAILURE RECURRED WHENEVER THE ENGINE WAS IN OPERATION. THERE WAS A RECALL RELATED TO THE DEFECT UNDER NHTSA CAMPAIGN ID NUMBER 00V259001 (ELECTRICAL SYSTEM: WIRING); HOWEVER THE RECALL EXPIRED. THE VEHICLE HAD NOT BEEN REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE DEFECT. THE APPROXIMATE FAILURE MILEAGE WAS 120,000. UPDATED 03/14/12*LJ

NHTSA ID

10435658

Incident

Oct 29, 2011

Mileage

120,000 mi

CAR HAS BAD RUST OUT PROBLEMS. ON THE METAL FRAME AND SUSPENSION PARTS. TOTAL RUST OUT ON REAR FRAME, ALSO THE UPPER CONTROL ARMS. THE FRONT CRADLE FRAME WAS REPAIRED PREVIOUSLY. UPDATED 10/20/11 *BF

NHTSA ID

10431130

Incident

Jan 18, 2011

Mileage

103,780 mi

I HAVE A 2000 HYUNDAI SONATA. I HAVE HAD SEVERAL SENSORS REPLACED IN THIS CAR ALREADY. IT IS SOMETHING ELECTRICAL OR ANOTHER SENSOR, GO FIGURE. MY WIPERS STOPPED WORKING, AND MY WIPER FLUID PUMP ALSO WENT OUT. HAD LOCAL AUTO SHOP REPLACE WIPER FLUID PUMP, THEY TRIED WHATEVER THEY COULD, THEN THE WIPERS WOULD NOT STOP WORKING,SO THEY TOOK OUT THE RELAY SWITCH.THEN MY WIPERS START WORKING AND I CAN TURN THEM OFF/ON WITH OUT THE RELAY SWITCH IN. MY CAR POWER LOCKS ARE NOT WORKING EITHER, WHICH THEY DID BEFORE. THEN MY CAR WOULD NOT START FOR NEXT THREE/FOUR DAYS, HAD TO HAVE IT JUMPED EACH DAY. SO I THOUGHT IT WAS MY BATTERY OR ALTERNATOR, HAD THOSE TESTED, IT IS NOT EITHER OF THEM. THEN MY CAR THE NEXT COUPLE OF DAY STARTS A LITTLE BETTER, BUT STILL BARELY STARTING, AND SOMETIMES WHEN I START MY CAR, THE POWER LOCKS LOCK AUTOMATICALLY. MY RADIO HAS ALWAYS ACTED UP BY TURNING OFF AND ON WHEN IT WANTS AND NOT SAVING THE STATIONS I SAVE EVERYDAY, BUT NOW IT GOES FROM A STATION TO MY CD TURNING ON, JUST BY ITSELF. I HAVE SEEN OTHER COMPLAINTS ABOUT THIS ON THE INTERNET, THERE IS SERIOUSLY SOMETHING WRONG WITH THE ELECTRICAL WIRING OR THE SENSORS OF THIS CAR, THERE NEEDS TO BE A RECALL THIS COULD BE REAL DANGEROUS. YOU NEVER KNOW WHAT IS GOING TO HAPPEN. PLEASE HELP! *TR

NHTSA ID

10386859

Incident

Mar 1, 2011

Mileage

133,500 mi

NO SIGNS OF POSSIBLE PROBLEM PRIOR TO BEING UNABLE TO DRIVE THE VEHICLE. THE DRIVER LOST CONTROL OF THE VEHICLE WHEN DRIVING IN A PARKING LOT AND WAS ABLE TO AVOID ADDITIONAL DAMAGE AND INJURY. THE VEHICLE WAS THEN TOWED TO A LOCAL AUTO REPAIR SHOP THAT DIAGNOSED THE PROBLEM AS A SUBFRAME RUST ISSUE ON THE DRIVER'S SIDE, WHICH DID NOT ALLOW THE CONTROL ARMS TO FUNCTION. *TR

NHTSA ID

10365174

Incident

Nov 8, 2010

Mileage

162,900 mi

TL*THE CONTACT OWNS A 2000 HYUNDAI SONATA. THE CONTACT WAS DRIVING APPROXIMATELY BETWEEN 10-12 MPH ATTEMPTING TO MAKE A LEFT TURN, SUDDENLY THE VEHICLE STOPPED WITHOUT WARNING. THE CONTACT INSPECTED THE VEHICLE AND OBSERVED THAT THE FRONT DRIVER SIDE AXLE COMPLETELY SEPARATED. ALSO, THE SUB-FRAME EXHIBITED EXCESSIVE CORROSION. THE VEHICLE WAS TOWED TO AN AUTHORIZED DEALER FOR DIAGNOSIS. THERE WAS A RECALL ASSOCIATED WITH THE NHTSA CAMPAIGN ID NUMBER 09V124000 (SUSPENSION). THE VIN WAS NOT INCLUDED IN THE RECALL. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 193,165.

NHTSA ID

10359308

Incident

Oct 3, 2010

Mileage

193,165 mi