2008 Hyundai Sonata Interior & seats Problems

Took vehicle to independent Hyundai factory trained technician due to air bag light. Was advised this is due to failure of Occupant Classification System sensor in front passenger seat. This is related to NHTSA Campaign 08V161000, but technician advised my VIN was not listed under this recall. Technician advised me to contact Hyundai due to the recall and inquire if my vehicle could be covered, since leaving unaddressed could cause injury or death during collision. Manufacturer is aware of issue due to previous recall cited above. Spoke with Hyundai customer service phone line on 12/13/2022 and informed of issue, asking if the recall would cover my vehicle even though my VIN was not indicated in the previous recall. Customer service advised this could not be done. Asked customer service to file complaint about known safety issue and was given case #20713402. Customer service advised I could pay for repairs out of pocket and receive refund if recall was later issued. Action requested: expand recall 08V161000 to include additional 2008 Hyundai Sonatas exhibiting same manufacturer defect which is a risk to public safety.

NHTSA ID

11497279

Incident

Dec 13, 2022

WHILE THE CAR WAS PARKED IN THE DRIVEWAY OF MY HOME, I TURNED THE VEHICLE ON AND THE AIRBAGS LIGHTS CAME ON THE DASH. I DROVE IT WORK AND HOPING THE AIRBAG LIGHTS WILL TURN OFF AND IT DID NOT. I TOOK THE PROBLEM TO THE HYUNDAI DEALERSHIP FOR EVALUATION. A LITTLE HISTORY, MY AIRBAG LIGHTS CAME ON BACK IN 2012, CASE #10352554, THE VEHICLE HAD A RECALL FOR IT. THE DEALERSHIP SENT THE FRONT RIGHT PASSENGER SEAT TO CALIFORNIA FOR REPAIRS. THE PROBLEM WAS FIXED. NOW JUMP FORWARD 2017, MY AIRBAGS LIGHT CAME ON AGAIN AND THE DEALERSHIP ADVISED ME THE PROBLEM IS NOT RELATED TO THE RECALL BACK IN 2012. THE DEALERSHIP ADVISED ME THE PROBLEM NOW HAD TO DO WITH THE FRONT PASSENGER SEAT PRESSURE SENSOR (CUSHION) FOR THE AIRBAGS. ACCORDING TO THE DEALERSHIP THEY WOULD HAVE TO REPLACE THE WHOLE FRONT PASSENGER SEAT TO FIX THE PROBLEM IN ORDER FOR MY FRONT PASSENGER SEAT AIRBAG TO DEPLOY PROPERLY DURING AN ACCIDENT. I FEEL THAT THIS IS A DEFECT WITH THIS HYUNDAI VEHICLE AND A SECONDARY PROBLEM RELATED TO THE AIRBAG RECALL. I FEEL THE PROBLEM SHOULD BE INVESTIGATED FURTHER TO PREVENT ANY INJURY OR DEATH.

NHTSA ID

11003945

Incident

Jun 13, 2017

AIR BAG LIGHT WILL NOT GO OFF, DEALERSHIP SAID IT WAS THE PASSENGER SEAT BELT RECEIVER, WHICH I REPLACED WITH A NEW PART, AIRBAG LIGHT IS STILL ON AND NOW I AM TOLD IT IS THE PASSENGER SEAT PRESSURE SENSOR. I SAW THERE HAVE BEEN RECALLS BUT WAS TOLD MY CAR WAS NOT INCLUDED. I AM UNABLE TO INSPECT THE CAR IN THE STATE OF MAINE NOW.

NHTSA ID

10981439

Incident

Jun 1, 2016

Mileage

115,000 mi

IM JUST WRITING BECAUSE IM GETTING ALOT OF ALERTS FROM YOU GUYS AND I DONT LIVE AT THE SAME ADDRESS WHEN I PURCHASED MY CAR. SO IM NOT GETTING MY RECALL LETTERS OR NOTICES. SO WHAT IM WOUNDERING IS WHAT DO I HAVE TO DO TO MAKE SURE MY CAR IS NOT BEING EFFECTIVE BY THESES RECALLS. THANK YOU AND HAVE A NICE DAY.

NHTSA ID

10935937

Incident

Dec 15, 2016

TL* THE CONTACT OWNS A 2008 HYUNDAI SONATA. THE CONTACT STATED THAT THE LATCHES ON THE REAR PASSENGER AND DRIVER SIDE DOORS FRACTURED. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE DOOR LATCHES NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 70,000.

NHTSA ID

10925308

Incident

Nov 20, 2014

TL* THE CONTACT OWNS A 2008 HYUNDAI SONATA. THE CONTACT STATED THAT THE IGNITION SWITCH FAILED TO WORK WHEN ATTEMPTING TO TURN THE KEY OVER. THE VEHICLE FAILED TO START RANDOMLY ON SEVERAL OCCASIONS. IN ADDITION, THE DOOR LATCHES FAILED TO OPEN FROM OUTSIDE AND INSIDE THE VEHICLE. THE DEALER AND AN INDEPENDENT MECHANIC WERE NOTIFIED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE VIN AND FAILURE MILEAGE WERE NOT AVAILABLE.

NHTSA ID

10852964

Incident

Oct 22, 2007

DRIVERS SEAT LUMBAR ADJUSTING CAM BROKE WHILE DRIVING, THIS IS THE SECOND TIME IT HAS BROKEN AND THE LOWER BACK OF THE SEAT PUSHED IN ABRUPTLY. THIS WAS VERY DISTRACTING WHILE DRIVING ON HIGH SPEED TOLL ROAD IN HEAVY TRAFFIC. THE METAL CAM WHICH WAS BROKEN OFF, WAS FOUND BEHIND THE DRIVERS SEAT. THIS IS SUCH A SMALL PIECE OF METAL AND DOES NOT SEEM TO BE STRONG ENOUGH FOR WHAT IS REQUIRED. MY DEFINITION OF THE CAM IS THE MECHANICAL PART THAT ACTUALLY MAKES THE ADJUSTMENT INSIDE OF THE SEAT AND ALSO SUPPORTS THE WEIGHT OF THE DRIVERS LOWER BACK. SIMILAR TO A S CAM OF A BRAKING SYSTEM. *TR

NHTSA ID

10537065

Incident

Aug 20, 2013

Mileage

61,584 mi

DASHBOARD AIR BAG LIGHT HAS COME ON AND OFF INTERMITTENTLY SINCE SEPTEMBER 2012. AT THIS TIME THE AIR BAG LIGHT IS OFF. THE PASSENGER SAFETY BELT LIGHT REMAINS PERMANENTLY ON SINCE SEPTEMBER 2012 AS WELL. CALLED THE DEALER HYUNDAI OF EL PASO AND THEY SAID MY CAR IS NO LONGER UNDER WARRANTY AND IS NOT INCLUDED IN THE RECALL CAMPAIGN. HOW CAN IT BE? *TR

NHTSA ID

10510714

Incident

Sep 22, 2012

Mileage

75,000 mi

BOTH AT A COMPLETE STOP WHILE IN GEAR AND WHILE MOVING AT ABOUT 35 MPH WITH MY WIFE IN THE FRONT PASSENGER SEAT THE AIR BAG LIGHT REMAINED ON. IN THIS VEHICLE THAT LIGHT IS SUPPOSED TO GO OFF WHEN SOMEONE OVER 85LBS SITS IN THE FRONT PASSENGER SEAT. TOOK VIDEO OF THREE INCIDENTS OVER A PERIOD OF TWO DAYS. SPOKE TO JENKINS HYUNDAI, OCALA, FL WHERE WE PURCHASED THE CAR & THEY WERE UNABLE TO PULL A CODE. THEY WERE ALSO UNINTERESTED IN THE VIDEOS AND STATED THAT THE FRONT SEAT SENSOR IS CALIBRATED FOR 115 LBS +/-. AS MY WIFE IS 128 LBS THEY FEEL THAT IT IS WELL WITHIN LIMITS & THAT SOMETIMES THE AIRBAG SENSOR WILL NOT SENSE HER PRESENCE. I THOUGHT THE LIMIT WAS 85 LBS FOR SMALL CHILDREN. IF WE HAVE AN ACCIDENT WITH MY WIFE IN THE FRONT PASSENGER SEAT THE AIRBAGS MIGHT NOT DEPLOY. *TR

NHTSA ID

10504179

Incident

Mar 14, 2013

Mileage

36,500 mi

THE OTHER DAY, I FOUND THE SRS AIRBAG WARNING LIGHT KEEPS ON ON THE INSTRUMENT CLUSTER AND THEN I FOUND THAT THE SEAT BELT WARNING LIGHT IN THE FRONT PASSENGER'S SIDE IS ALSO ON AND THE "PASSENGER AIR BAG OFF" INDICATOR IS TURNED OFF WHEN THERE IS NO PASSENGER OR LUGGAGE ON THE SEAT. I WENT TO THE LOCAL DEALER AND IT TURNED OUT TO BE THAT VEHICLE HAS NO COMMUNICATION FROM OCCUPANT CLASSIFICATION SYSTEM (OCS) MODULE UNDER THE FRONT PASSENGER'S SEAT. *TR

NHTSA ID

10464750

Incident

Jul 5, 2012

Mileage

62,600 mi

TRUNK WAS OPENING ON ITS OWN INTERMITTANTLY. THIS WAS OUR 55000 MILE SCHEDULED SERVICE SO WE REPORTED IT. THEY CHECKED AND FOUND NOTHING WRONG BUT TOLD US THEY GREASED THE TRUNK LATCH AND IT SHOULD BE FIXED. A FEW WEEKS LATER IT IS HAPPENING AGAIN. WE THINK ITS AN ELECTRONIC DEFECT, BUT BY THE TIME THEY FIGURE IT OUT WE'LL BE OUT OF WARRANTY. WE DON'T DARE PUT ANYTHING OF VALUE IN THE CAR. *TR

NHTSA ID

10444056

Incident

Nov 25, 2011

Mileage

55,000 mi

THE PASSENGER SIDE FRONT DOOR LOCK DOES NOT LOCK OR MOVE AND THE DOOR REMAINS OPEN WHILE DRIVING. IT HAPPENED IN THE LAST COUPLE OF WEEKS. NOTICED WHEN DOORS WERE LOCKED REMOTELY AND THE PASSENGER SIDE FRONT WAS ABLE TO BE OPENED, WE SEE THERE ARE A NUMBER OF DOOR LOCK LINKAGE RECALLS AND SERVICE NOTICES. *TR

NHTSA ID

10360852

Incident

Oct 7, 2010

Mileage

88,000 mi