2015 Hyundai Veloster Problems

2015 Hyundai Veloster Turbo (original owner). The vehicle has three severe safety defects: TRUNK/HATCH LATCH FAILURE: The hatchback lift support/latch fails, refusing to stay open. It unexpectedly fell, which has caused repeated, severe impacts to my head and neck, resulting in an injury requiring surgery. I must manually prop it open with a mini ball to load cargo. ENGINE & TURBO FAILURE / OIL CONSUMPTION: History of engine acceleration issues and turbo failures since 4,000 miles. At 44,000 miles, the turbo completely failed, the car started to whine, then rattle, and completely turned off. Dealer (Hyundai Escondido) forced a $2,200 out-of-pocket replacement despite being under warranty, citing a lack of at-home oil change receipts. The vehicle now has a documented, rapid oil leak and excessive consumption issue that the dealer refuses to repair, despite being reported prior to warranty expiration. SEAT BELTS: The front and rear seat belt latches are malfunctioning, intermittently releasing on their own, failing to release properly, or failing to latch securely, compromising the safety of a [XXX] passenger. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I am reporting a safety-related engine defect involving sudden internal engine failure, excessive oil consumption, persistent bearing knock, and overheating of the catalytic converter. The vehicle repeatedly triggered Bank 1&2O2 sensor fault codes due to oil blow-by and thermal overload. A certified mechanic documented the engine is failing internally and that the cat. converter has been damaged as a direct result of engine defect. The failure pattern is consistent with known Hyundai engine defect investigations involving bearing wear, oil consumption, stalling, and fire risk. The overheating cat. converter presents a significant safety hazard, including potential engine seizure. I purchased the vehicle used in March 2025. I am the third owner. Despite maintaining the vehicle responsibly (Regular oil changes), the engine failure progressed rapidly. Hyundai Motor America has denied a goodwill repair solely on the basis of mileage, even though the defect clearly originated long before my ownership and aligns with previously identified safety-related engine issues. Additionally, Hyundai's records show that this vehicle had an engine-related recall active during prior ownership period; the recall was never performed by the Hyundai dealership that sold the vehicle to the previous owner. This raises concerns about improper recall handling and whether the defect should have been corrected before the vehicle was resold. Given the safety implications, the documented defect pattern, and the unresolved recall history, I am requesting NHTSA's review of this matter. The engine failure poses a serious safety risk; Hyundai's refusal to address a known defect, the vehicle is unsafe to operate. Timeline: 2014 Hatchett Hyundai West, KS 17,665 mi.; 2017-H. West serviced vehicle, 58,918; 2019-Engine powertrain alert 83856mi; 2020- Edmund Hyundai, OK-engine power train 100179 mi; 2021- Edmund 145418mi.; Hy. Noblesville, IN 167,603mi.; 2024 - H.N. 171937; 2025 - denied repair 188890.

The climate control fan knob suddenly stopped working. I smelled a burning smell on the interior of the car. I pulled the panel off and noticed that the plug to the climate control harness was burnt. I can no longer utilize the climate control system.

ABS, EPS, check engine light appeared on dashboard then car’s steering wheel stiffed and car lost power. Vehicle’s hood smells burnt and has fumes come out after driving for 10-20minutes. My safety and my family’s was endangered as this happened while driving on the road. Not at a stop sign or a red traffic light but while driving. The dealer has refused to inspect/address the issue without having me paid close to $2,500.00 for other repairs.

The contact owns a 2015 Hyundai Veloster. The contact stated that upon starting the vehicle and shifting into gear, the vehicle failed to respond and became inoperable. There was no warning light illuminated. The vehicle was taken to the dealer, and the rear axle was replaced, the transmission fluid was flushed and refilled, and a shift analyzer software update was performed; however, the failure recurred days later. The vehicle was taken back to the dealer, where it was determined that the wheel speed sensor had failed. Upon investigating the failure online, the contact advised the dealer to inspect the crankshaft position sensor; however, the dealer informed the contact that the failure was related to the transmission. The contact was informed that the failure could not be duplicated. The vehicle was not diagnosed or repaired, and the contact was advised to retrieve the vehicle. The manufacturer was notified of the failure and covered the cost of the rear axle replacement under a goodwill assistance program. Several cases were filed, and the contact sent a video of the failure to the manufacturer. The failure mileage was approximately 62,000.

The contact owns a 2015 Hyundai Veloster. The contact stated that the vehicle was taken to a local dealer for a recall repair; however, after leaving the dealer, while driving approximately 30-40 MPH, the vehicle stalled. The vehicle failed to shift into gear. The vehicle sat for two hours before being restarted and slowly driven to the place of employment, and was then driven to the residence. The contact was unable to determine if there were any warning lights illuminated. The contact called the dealer and was provided with information for towing services and a diagnostic test. The vehicle was not repaired. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 176,000.

ABS, EPS, check engine light appeared on dashboard then car’s steering wheel stiffed and car lost power. Vehicle’s hood smells burnt and has fumes come out after driving for 10-20minutes. My safety and my family’s was endangered as this happened while driving on the road. Not at a stop sign or a red traffic light but while driving. The dealer has refused to inspect/address the issue without having me paid close to $2,500.00 for other repairs.

problem with car engine has been recall for several years, brakes have been recall for 2-3 years now my emissions are mess up from recall engine which now i do not have a car to drive, being a heart patient, veteran, it is hard without one and i can't afford a new one i have done all Maintenace and everything on my end to keep it going. engine eats oil, loses compression on road knocking had in shop twice still no fixing the problems my engine light is on i have been told by dealer my car can catch on fire from brakes and engine getting hot in the cabin jerks tried to cut out on me several times afraid to drive it anymore. hyundai is putting everything off until it blows us up i guess. can you help me? i wrote to hyundai corp and sent contacts through the computer no response back wiper doesnt work or gps all broke in it, never use the back wiper but once,also clogged catalytic converters confirm by hyundai dealership

I was on the highway and looked at my speedometer and the mph was at 0. The abs and the brake light warnings came on and I couldn't accelerate and hardly brake. I pulled to the shoulder immediately. Took a couple hundred feet to finally stop. It was a very scary moment thinking my brakes have gone. I put it in park waited a moment turned it off... waited about 5 mins and it turned over just wanted to get it home

Engine blinking and smell burnt while driving, ABS button turn on automatically

Driver entered the car and closed the driver side door. Car was in park in driveway. Driver tried to vent the moon roof and the glass of the moon roof shattered. Glass rained down upon driver and flew all over the driveway and the lawn

Blower motor stops working about every 1.5 years. It was initially reported as a blower motor recall and the dealer replaced it twice but it went out a 3rd time about 2.5 years ago. They searched for the problem after realizing they had replaced the blower motor twice but could not locate the defect, at which point they charged me over $300.00 for their efforts to locate the problem. They wanted to keep looking for the problem but I told them no, just put it back together that I wasn't going to pay them to search for their defect. I have since been told by someone who claimed to be a mechanic for Hyundai that it is a computer chip problem that requires them to pull a lot of things on the dash to replace the chip and it is not cheap. I have a mechanic that is trying to get the chip and install it for me but I won't know for certain that this is the problem until the chip is replaced. I have driven the car for about 2.5 years without heat or air conditioning but can't work when it rains because the windshield fogs up in the rain and I can't see. I also can't drive the car when I can't get the windshield cleared of ice. Now the engine is burning oil but there's no recall for that issue according to your website. The car now has 173,624 mile on it.

problem with car engine has been recall for several years, brakes have been recall for 2-3 years now my emissions are mess up from recall engine which now i do not have a car to drive, being a heart patient, veteran, it is hard without one and i can't afford a new one i have done all Maintenace and everything on my end to keep it going. engine eats oil, loses compression on road knocking had in shop twice still no fixing the problems my engine light is on i have been told by dealer my car can catch on fire from brakes and engine getting hot in the cabin jerks tried to cut out on me several times afraid to drive it anymore. hyundai is putting everything off until it blows us up i guess. can you help me? i wrote to hyundai corp and sent contacts through the computer no response back wiper doesnt work or gps all broke in it, never use the back wiper but once,also clogged catalytic converters confirm by hyundai dealership

15 Warranty repairs with less than 60K mileage that were discovered for the vehicle’s history. To date I have replaced: Catalytic Converter (Discovered this is a common issue with the vehicle) Infotainment Front Struts Rear Shocks Motor mounts Driver Side window motor (Previously repaired by Hyundai Replaced by Hyundai 1/7/2020 at 56k miles, malfunction a 2nd time) Windshield Wiper Motor (Previously repaired by Hyundai Replaced by Hyundai 10/7/2019 at 54K miles, malfunction a 2nd time) a/c motor blower Oxygen Sensor Fuel Injectors (common issue) Driver Side/Passenger Side control arms Windshield Wiper hoses due to dry rot All 4 ignition coils Battery Leads

2015 Hyundai Veloster Turbo (original owner). The vehicle has three severe safety defects: TRUNK/HATCH LATCH FAILURE: The hatchback lift support/latch fails, refusing to stay open. It unexpectedly fell, which has caused repeated, severe impacts to my head and neck, resulting in an injury requiring surgery. I must manually prop it open with a mini ball to load cargo. ENGINE & TURBO FAILURE / OIL CONSUMPTION: History of engine acceleration issues and turbo failures since 4,000 miles. At 44,000 miles, the turbo completely failed, the car started to whine, then rattle, and completely turned off. Dealer (Hyundai Escondido) forced a $2,200 out-of-pocket replacement despite being under warranty, citing a lack of at-home oil change receipts. The vehicle now has a documented, rapid oil leak and excessive consumption issue that the dealer refuses to repair, despite being reported prior to warranty expiration. SEAT BELTS: The front and rear seat belt latches are malfunctioning, intermittently releasing on their own, failing to release properly, or failing to latch securely, compromising the safety of a [XXX] passenger. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

The car was repaired at a Hyundai dealership less than a month prior to the incident. I was driving down a road with no one around besides me and my passenger when all of a sudden Orange sparks start flying out the sides of the car, I slow down and pull over as fast as I could, then I noticed fire on the passenger side and hurried us out the car. It proceeded to burn away until the firefighters came.

The contact owns a 2015 Hyundai Veloster. The contact stated that the steering wheel had become loosened and was shaking while driving at various speeds. There was no warning light illuminated. The vehicle was taken to an independent mechanic where it was discovered that the plastic bushing inside the steering column was defective and needed to be replaced. The contact was informed by the mechanic that there might have been a recall on the vehicle related to the failure. The mechanic referred him to the dealer. The dealer informed him that there were no recalls on the vehicle, and he was then referred to the NHTSA.gov website. The manufacturer was not notified of the failure. The vehicle was not repaired. The failure mileage was approximately 64,000.

STARTED CAR STEERING WAS HARD COULD NOT TURN . RESTARTED STEERING WAS BETTER. DEALER TOLD WIFE BRING TO DEALERSHIP WITH THEM KNOWING STEERING PROBLEM . THEY TOLD HER NEVER HAD THIS PROBLEM AND WILL TAKE TWO MONTHS TO CORRECT. CAR ONLY SEVEN MONTHS OLD. PAID CASH SO I HAVE NO OPTIONS.

15 Warranty repairs with less than 60K mileage that were discovered for the vehicle’s history. To date I have replaced: Catalytic Converter (Discovered this is a common issue with the vehicle) Infotainment Front Struts Rear Shocks Motor mounts Driver Side window motor (Previously repaired by Hyundai Replaced by Hyundai 1/7/2020 at 56k miles, malfunction a 2nd time) Windshield Wiper Motor (Previously repaired by Hyundai Replaced by Hyundai 10/7/2019 at 54K miles, malfunction a 2nd time) a/c motor blower Oxygen Sensor Fuel Injectors (common issue) Driver Side/Passenger Side control arms Windshield Wiper hoses due to dry rot All 4 ignition coils Battery Leads

ALL THE SENSORS ARE CONTINUAL REGISTERING PROBLEM. ELECTRICAL SYSTEM WILL STOP WORKING DAILY. CANNOT HAVE HOOD SHUT WHEN KEY OUT OF THE IGNITION. IF SO ALARM WILL GO OFF. SUSPENSION IS OFF. IT SEEMS LIKE THE CAR IS PULLING A CAMPER ALL THE TIME. THE PROBLEM HAS BEEN CONTINUALLY GETTING WORSE THE PAST 6 MONTHS.

My cars lights (headlights, gage cluster lights, dash lights, radio screen light, etc..) and screen for my radio and back up camera, all turn off by themselves, for maybe 1 second or 2, while driving. This happens randomly, no warning, no special conditions, just out of nowhere, and for no reasons. Since I bought the car in September of 2020 (used, as is) it has done it now 7 or 8 times, with tonight being the most recent occurrence. I don't know how to have it checked or verified by a technician because there's no forewarning before it happens. It's completely random and unexpected. It's very scary, especially with my children in the car.

THE HEADLIGHTS ARE VERY DIM AND VERY LOW VISIBILITY AT NIGHT TIME HAVE TO DOUBLE CHECK THEYRE EVEN ON AND WORKING ESPECIALLY WHEN RAINING AND AT NIGHT TIME I WAS DRIVING HOME TWO NIGHTS AGO TGE WEATHER WAS VERY BAD AND I HAD TO TRY MY HARDEST TO BE ABLE TO STAY IN RIGHT LANE AND AVOID DEBRIS FROM THE WIND AND RAIN AND DRIVE BELOW SPEED LIMIT AS WELL CANT SEE IF THERE IS ANYTHING IN ROAD LIKE POT HOLES DEBRIS ETC

I JUST NOTICED THAT ON MY RIGHT FRONT TIRE THERE IS A BUBBLE ON IT'S SIDE WALL. THE CAR LEASED NEW BACK IN JULY OF THIS YEAR. THE TIRES ARE THE KUMHO SOLUS KH25. I'VE ALSO NOTICED HERE ON THIS SITE, I SEEN A COMPLAINT FOR THE SAME THING. I'M HAVE AN APPOINTMENT ON MONDAY TO SEE WHAT ARE THEY GOING TO TELL ME. AS FOR SPEED CONTROL. THIS CAR CANT GO ABOVE 55MPH - 60MPH WHILE ON HIGHWAY NORMAL CURVES WITHOUT THE REAR SWAYING WHILE RUN OVER DIVIDER LINE ON THE PAVEMENT. LESS SPEED WHEN IT RAINS. I'M REALLY HAVING DOUBTS ABOUT THIS CAR ONCE IT STARTS TO SNOW.

2015 Hyundai Veloster Turbo (original owner). The vehicle has three severe safety defects: TRUNK/HATCH LATCH FAILURE: The hatchback lift support/latch fails, refusing to stay open. It unexpectedly fell, which has caused repeated, severe impacts to my head and neck, resulting in an injury requiring surgery. I must manually prop it open with a mini ball to load cargo. ENGINE & TURBO FAILURE / OIL CONSUMPTION: History of engine acceleration issues and turbo failures since 4,000 miles. At 44,000 miles, the turbo completely failed, the car started to whine, then rattle, and completely turned off. Dealer (Hyundai Escondido) forced a $2,200 out-of-pocket replacement despite being under warranty, citing a lack of at-home oil change receipts. The vehicle now has a documented, rapid oil leak and excessive consumption issue that the dealer refuses to repair, despite being reported prior to warranty expiration. SEAT BELTS: The front and rear seat belt latches are malfunctioning, intermittently releasing on their own, failing to release properly, or failing to latch securely, compromising the safety of a [XXX] passenger. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

I HAVE HAD 3 VELOSTERS BRAND NEW, THEY COME WITH KUMHO SOLUS KH25 AND THEY ALL DEVELOPED SIDEWALL BUBBLES, EACH TIME I CANN FOR A WARRANTY THEY DENY ME SAYING ITS MY FAULT, YET MANY OTHERS HAVE THE SAME ISSUES. MY NEW 2015 VELOSTER RSPEC HAS THEM AND HAS DEVELOPED A SIDEWALL BUBBLE AT 4300 MILES. *TR