2017 Hyundai Veloster Problems

The contact owns a 2017 Hyundai Veloster. The contact stated that while her sister was driving approximately 65 MPH, the vehicle stalled. The driver pulled over to the side of the road. The vehicle was able to be restarted, but made an abnormal knocking sound. The check engine warning light was flashing. The vehicle was towed to the residence. The dealer was contacted and informed that the vehicle needed to be diagnosed to confirm whether it was covered under warranty. The dealer informed the contact that towing assistance would be provided; however, the dealer drove the vehicle to the repair center, where it was diagnosed, and metal debris was found in the oil control solenoid. The vehicle was not repaired. The vehicle was driven back to the residence. A mobile independent mechanic diagnosed the vehicle and recommended either the rod bearings or engine replacement. The manufacturer was notified of the failure and contacted the dealer. The manufacturer then informed the contact that the dealer advised that the vehicle could not be diagnosed or receive a free repair unless unrelated repairs were first performed. The manufacturer denied a Goodwill Assistance. The failure mileage was approximately 161,000.

The engine failed due to suspected rod bearing failure related to Hyundai’s known rod bearing recall issue. The vehicle exhibited a flashing check engine light with diagnostic trouble code P1326, knocking noises, metal debris found in the oil control solenoid, and subsequent secondary damage to the catalytic converter. The engine has not been opened by the Hyundai dealership despite these indicators. The vehicle and affected components are available for inspection upon request. The engine condition poses a serious safety risk. An independent mechanic advised that the rod bearing issue presents a fire hazard and stated the vehicle should not be driven due to the risk of engine failure, fire, loss of life, loss of power while driving. A sudden engine failure or fire could endanger the driver, passengers, and other motorists. Yes. The Hyundai dealership documented secondary engine damage but failed to perform the required open-engine rod bearing clearance test despite recall-related symptoms. An independent mechanic confirmed the issue is consistent with rod bearing failure and advised that the vehicle is unsafe to drive. The vehicle was inspected by an authorized Hyundai dealership and reviewed by Hyundai corporate. Hyundai corporate relied solely on the dealership’s incomplete inspection and denied further investigation or goodwill repair. The vehicle has also been inspected by an independent mechanic who identified the rod bearing issue as a safety hazard. Yes. Prior to the failure, the vehicle experienced a flashing check engine light and stored diagnostic code P1326. The engine produced knocking noises and showed signs of internal metal debris and secondary damages. The absence of early warning indicators prevented earlier detection. However, the extent of internal metal debris and secondary component damage demonstrates a progressive engine failure consistent with known rod bearing defects, rather than a sudden event after the warranty threshold.

The 2017 Hyundai Veloster- Value edition is a Lemon straight from the manufacturer. I purchased mine in July of 2024 with 27,000 miles. When I test drove it I questioned the clicking noises that could be heard while switching gears along with minor "shuddering" at acceleration. I was informed by gentleman at Dealer that it was a normal characteristic of owning a DCT vehicle. One year later 7/2025 I have been experiencing more intense issues with clutch/transmission. I have a great loss of power at acceleration, it will stay bogged at 1,000-1,500 RPM'S before it engages and revs with a jolt forward. It is unsafe to pull out or lane change on highway. It also is shuddering upon every acceleration from a dead stop. The clicking noises are now accompanied by clicking noises any time it shift gears. I get an intermittent smell of something burning. It is DEFINITELY UNSAFE to drive in any temperature above 75° due to the vehicle not being able to get out of its own way. All issues are intensified. I brought the vehicle to Hyundai service center and all that was recommended was a coolant flush and Dual Clutch Transmission service, which I paid to have done. I am not the original owner so any manufacturer warranty is out the window. Any research done by consumer will show pages and pages of complaints about the 2017 Veloster and DCT problems. Hyundai NEEDS TO MAKE GOOD on the unsafe garbage they sold us! Let me inform you that the vehicle I am currently making this complaint about has less than 48,000 miles today 7/9/2025

The contact owns a 2017 Hyundai Veloster. The contact stated while driving at various speeds, the vehicle hesitated while depressing the accelerator pedal before the vehicle surged forward. There was no warning light illuminated. The vehicle was taken to a dealer where the DTC scanner determined that the transmission had failed and needed to be replaced. Prior to the transmission failure, the engine and exhaust system were replaced. The manufacturer was notified of the failure and informed the contact that there were no recalls on the vehicle. The vehicle was not yet repaired. The failure mileage was approximately 160,000.

I bought the vehicle 14 days ago and everything was going well until black smoke started to come out of the exhaust and it started to smell burnt. I brought a mechanic to my house and he told me that the engine had already died

The vacuum pump had an internal mechanical failure, resulting in complete failure of the airbag control module, electronic stability control system, power steering, ABS, and speedometer. These were all shown as warning lights on the dashboard, starting with the ESC, then sporadic airbag light, sporadic steering light, etc.. In the event of a crash, the airbags would not have deployed. In the event of low-traction conditions, the car would not have been able to maintain control and I could have crashed. In the event of turning across traffic, my steering could have failed and I could have crashed. Due to the speedometer malfunction, I could have been going too fast and put myself and others at risk for high-speed collision. This problem has been confirmed and repaired by a Hyundai Dealership. The repairs would have been covered under warranty, but the vehicle is no longer under warranty. The dealership specified that there was nothing I could have done to prevent this failure. Occurred at 78,000 miles on March 18, 2022.

Paint peeling issue on hood. Filed for Hyundai to repair last 12/24, Hyundai denied claim 12/20/2024, without detailed reasons. Secondary extended warranty is suppose to be for 10 years regardless of mileage.p Hyundai case# [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

White paint peeling on hood.

Today the vehicle was hesitant to start but did. After two stops I turned car off, went into a business. When I came out the car would start but would not go forward or backwards but rev up. I nearly slammed into a curb in the process. I have a video of this.

MY BLUE LINK CONNECTED CARE HAS SENT ME 3 MONTHLY HEALTH REPORTS OF MY VEHICLE AND HAVE ALL SAID AIR BAG PROBLEM NEED SERVICE IMMEDIATELY BUT I HAVE NO LIGHT TURNED ON IN MY TACHOMETER, I BARELY GOT THIS CAR 3 MONTHS IT'S TOO SOON TO HAVE A PROBLEM LIKE THIS AND ALSO HAVE TOOK IT TO GET IT SERVICED . I'M ONLY CONCERNED BECAUSE IF IT DOES COME DOWN TO A ACCIDENT WILL MY AIR BAGS WORK?

Occasionally when traveling at speeds under 30 mph and you depress the accelerator the engine will hesitate to respond for several seconds.

VERY SLUGGISH NO POWER IT OVER REVS THE ENGINE AND DOESN'T SHIFT RIGHT THROWS RPM WAY TO HIGH THIS HAPPENS EVERY TIME I DRIVE IT NOT JUST SOME TIMES BUT EVERY TIME

I bought the vehicle 14 days ago and everything was going well until black smoke started to come out of the exhaust and it started to smell burnt. I brought a mechanic to my house and he told me that the engine had already died

VEHICLE STALLS WHEN TAKING FOOT OFF THE BRAKE. WON'T PROPERLY DRIVE

The contact owns a 2017 Hyundai Veloster. The contact stated while manually washing the vehicle, the contact observed that there was corrosion coming from under the paint of all four rims. The vehicle was taken to the dealer where all four rims were replaced with the manufacturer's original rims. The contact stated that the corrosion from under the paint looked like splotches and there was a clear coat that kept the corrosion from breaking through the surface. The contact stated that the failure recurred. The vehicle was taken to the dealer where the cause of the corrosion was unknown. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 5,000.

TL* THE CONTACT OWNS A 2017 HYUNDAI VELOSTER. WHILE DRIVING 58 MPH, THE VEHICLE FISHTAILED AND CRASHED INTO A FENCE. THE AIR BAGS DID NOT DEPLOY. A POLICE REPORT WAS FILED. THERE WERE NO INJURIES. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC WHERE THE VEHICLE WAS DEEMED DESTROYED; HOWEVER, THE INSURANCE COMPANY STATED THAT THE VEHICLE WAS ABLE TO BE REPAIRED. THE VEHICLE WAS NOT TAKEN TO A DEALER OR INDEPENDENT MECHANIC FOR DIAGNOSTIC TESTING OR REPAIRS. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE VIN WAS NOT AVAILBLE. THE FAILURE MILEAGE WAS APPROXIMATELY 35,000.

The vacuum pump had an internal mechanical failure, resulting in complete failure of the airbag control module, electronic stability control system, power steering, ABS, and speedometer. These were all shown as warning lights on the dashboard, starting with the ESC, then sporadic airbag light, sporadic steering light, etc.. In the event of a crash, the airbags would not have deployed. In the event of low-traction conditions, the car would not have been able to maintain control and I could have crashed. In the event of turning across traffic, my steering could have failed and I could have crashed. Due to the speedometer malfunction, I could have been going too fast and put myself and others at risk for high-speed collision. This problem has been confirmed and repaired by a Hyundai Dealership. The repairs would have been covered under warranty, but the vehicle is no longer under warranty. The dealership specified that there was nothing I could have done to prevent this failure. Occurred at 78,000 miles on March 18, 2022.

I PURCHASED A NEW 2017 VELOSTER IN MAY 2018. BEGINNING IN MID AUGUST I STARTED TO HAVE PROBLEMS WITH THE CAR NOT STOPPING AND THE STEERING WHEEL LOCKING WHEN ATTEMPTING TO STOP. IT HAPPENED ON 3 DIFFERENT OCCASIONS. ESCALATING EACH TIME. THE FIRST TIME IT HAPPENED I ALMOST HIT SOMEONE IN THE BACK. THE SECOND TIME I ALMOST ENDED UP IN ONCOMING TRAFFIC GOING THROUGH THE STOP LIGHT. THE THIRD TIME I GOT INTO AN ACCIDENT WHILE TRYING TO MAKE A TURN AND THE WHEEL AND BRAKES DID THE SAME THING AGAIN...MAKING MY CAR NOT DRIVEABLE CURRENTLY. MY CAR HAS ABOUT 3000 MILES ON IT. EACH TIME THIS OCCURRED I WAS ON A CITY STREET WITH STOP LIGHTS. AVERAGE SPEED 35-45 .

I PURCHASED A NEW 2017 VELOSTER IN MAY 2018. BEGINNING IN MID AUGUST I STARTED TO HAVE PROBLEMS WITH THE CAR NOT STOPPING AND THE STEERING WHEEL LOCKING WHEN ATTEMPTING TO STOP. IT HAPPENED ON 3 DIFFERENT OCCASIONS. ESCALATING EACH TIME. THE FIRST TIME IT HAPPENED I ALMOST HIT SOMEONE IN THE BACK. THE SECOND TIME I ALMOST ENDED UP IN ONCOMING TRAFFIC GOING THROUGH THE STOP LIGHT. THE THIRD TIME I GOT INTO AN ACCIDENT WHILE TRYING TO MAKE A TURN AND THE WHEEL AND BRAKES DID THE SAME THING AGAIN...MAKING MY CAR NOT DRIVEABLE CURRENTLY. MY CAR HAS ABOUT 3000 MILES ON IT. EACH TIME THIS OCCURRED I WAS ON A CITY STREET WITH STOP LIGHTS. AVERAGE SPEED 35-45 .

MY ACCIDENT THE AIR BAG DID NOT DEPLOY HITTING ANOTHER VEHICLE IT DEPLOYED AFTER HITTING A CURB WHICH WOULD HAVE BEEN 2 ND IMPACT TO DEPLOY IT SHOULD HAVE COME OUT THEN, THE BAR IN THE HEAD REST CAME OUT WHICH CUT MY HEAD AND I RECEIVED STAPLES IN MY HEAD. WHAT THE OTHER METAL THINGS THAT FLEW OUT OF THE STEERING I DON'T KNOW BUT THEY CUT AND BURNED MY ARM VERY BAD. I WAS GOING STRAIGHT ON A TWO LANE STREET. WHEN THE CAR BACKED INTO TO THE INTERSECTION IT DID NOT COME FROM MY RIGHT OR MY LEFT. I WAS 3/4 OF THE WAY ACROSS THE INTERSECTION WHEN THIS CAR APPEARED BACKING UP. I COULD NOT STOP IN TIME AND HIT IT IN THE REAR OF THEIR CAR.*DT

ON TUESDAY, APRIL 10, 2018 JUST AFTER 7P THE SUNROOF EXPLODED - WITHOUT WARNING - WHILE I WAS DRIVING AT 70 MPH ON INTERSTATE 10 JUST EAST OF HOUSTON. IT HAD NOT BEEN STRUCK BY AN OBJECT AND THE HIGHWAY SURFACE IS SMOOTH CONCRETE. GLASS SHOWERED DOWN ON MY AND FLEW OFF THE ROOF OF MY CAR - STRIKING MY PAINT AND SPOILER ON THE REAR OF THE VEHICLE. I'M THANKFUL THAT I DID NOT WRECK AND KILL MYSELF OR SOMEONE ELSE. WHEN IT EXPLODED, THERE WAS A LOUD POP THAT SOUNDED LIKE A GUNSHOT. MY HEART SKIPPED A BEAT AS GLASS SHOWERED DOWN ON ME. FOR A MOMENT, I THOUGHT I HAD BEEN SHOT AT BY A SNIPER - WHAT ELSE WOULD CAUSE A SUNROOF TO EXPLODE WITH NO WARNING AND WITHOUT THE VEHICLE STRIKING ROAD DEBRIS?