2002 Ic 3000 Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2002 Ic 3000, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Electrical133.3%
- Engine133.3%
- Fuel system133.3%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Electrical
Reports naming the electrical system — wiring, battery, charging, control modules, infotainment and electrical accessories.
From owner reports, verbatim
THE FUEL HEATER WIRING ON 7.3L DIESEL ENGINES HAS HAD AN ELECTRICAL FIRE ON 3 OF OUR VEHICLES OUT OF THE 28 IN OPERATION WITH THIS ENGINE. THE CONNECTOR IS A PUSH ON SPADE WITH A RUBBER SURROUND TO HOLD IT IN PLACE. ONE FIRE THAT WAS SEEN IN PERSON WAS SMALL (FEW INCHES) THE OTHERS WERE FOUND AFTER THE FIRE HAD OCCURRED. THE FIRE THAT WAS VIEWED OCCURRED WHEN THE VEHICLE WAS PARKED, FIRST START OF THE DAY AND LESS THAN 10 MINUTES IDLE TIME. I BELIEVE THE RUBBER SURROUND DOES NOT PROPERLY SUPPORT THE TERMINAL AND CREATES A LOOSE CONNECTION THAT ARCS AND OVERHEATS THE RUBBER, THEN IGNITING THE SMALL FIRE.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Engine
Reports naming the engine itself — including stalling, misfires, oil consumption, cooling and internal engine components.
From owner reports, verbatim
THE FUEL HEATER WIRING ON 7.3L DIESEL ENGINES HAS HAD AN ELECTRICAL FIRE ON 3 OF OUR VEHICLES OUT OF THE 28 IN OPERATION WITH THIS ENGINE. THE CONNECTOR IS A PUSH ON SPADE WITH A RUBBER SURROUND TO HOLD IT IN PLACE. ONE FIRE THAT WAS SEEN IN PERSON WAS SMALL (FEW INCHES) THE OTHERS WERE FOUND AFTER THE FIRE HAD OCCURRED. THE FIRE THAT WAS VIEWED OCCURRED WHEN THE VEHICLE WAS PARKED, FIRST START OF THE DAY AND LESS THAN 10 MINUTES IDLE TIME. I BELIEVE THE RUBBER SURROUND DOES NOT PROPERLY SUPPORT THE TERMINAL AND CREATES A LOOSE CONNECTION THAT ARCS AND OVERHEATS THE RUBBER, THEN IGNITING THE SMALL FIRE.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Fuel system
Reports naming fuel storage or delivery — tanks, pumps, lines, injectors and fuel leaks.
From owner reports, verbatim
THE FUEL HEATER WIRING ON 7.3L DIESEL ENGINES HAS HAD AN ELECTRICAL FIRE ON 3 OF OUR VEHICLES OUT OF THE 28 IN OPERATION WITH THIS ENGINE. THE CONNECTOR IS A PUSH ON SPADE WITH A RUBBER SURROUND TO HOLD IT IN PLACE. ONE FIRE THAT WAS SEEN IN PERSON WAS SMALL (FEW INCHES) THE OTHERS WERE FOUND AFTER THE FIRE HAD OCCURRED. THE FIRE THAT WAS VIEWED OCCURRED WHEN THE VEHICLE WAS PARKED, FIRST START OF THE DAY AND LESS THAN 10 MINUTES IDLE TIME. I BELIEVE THE RUBBER SURROUND DOES NOT PROPERLY SUPPORT THE TERMINAL AND CREATES A LOOSE CONNECTION THAT ARCS AND OVERHEATS THE RUBBER, THEN IGNITING THE SMALL FIRE.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .