RoadVitals

2009 Innovative Sds-42

Recalls, owner-reported complaints, investigations and safety data

Data refreshed

Owner complaintsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
1
Latest Aug 24, 2009
Safety recallsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
1
Latest Feb 23, 2009
InvestigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
0
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
0

Overview

Our database contains 1 NHTSA owner-reported complaint for the 2009 Innovative Sds-42, most frequently naming the powertrain (other) category. 1 safety recall has been issued covering this model year.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

What owners report

Complaints grouped by the component NHTSA recorded

  • Powertrain (other)1100.0%

Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.

Safety recalls

1 campaign cover this model year

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
09V067000

POWER TRAIN:AXLE HUBS

Feb 23, 2009
4 units potentially affected
The defect: INNOVATIVE IS RECALLING 4 MY 2008 SFS-45, SDS-45 AND MY 2009 SDS-42 BUSES EQUIPPED WITH ARVINMERITOR AXLE ASSEMBLIES. THE WHEEL END STUDS MAY HAVE BEEN IMPROPERLY TEMPERED RENDERING THEM BRITTLE AND SUSCEPTIBLE TO FRACTURE. IF ONE WHEEL STUD FRACTURES, THE REMAINING WHEEL STUDS ARE REQUIRED TO CARRY MORE LOAD. IF LEFT IN THIS CONDITION, THE REMAINING WHEEL STUDS MAY ALSO FRACTURE EVEN IF THEY ARE PROPERLY MANUFACTURED.
The risk: FRACTURED WHEEL STUDS COULD RESULT IN A VEHICLE CRASH.
The remedy: INNOVATIVE IS WORKING WITH ARVINMERITOR WHO WILL REPLACE ANY AFTERMARKET REPLACEMENT STUD FREE OF CHARGE (PLEASE SEE 08E038). OWNERS MAY CONTACT ARVINMERITOR AT 1-248-435-8793 OR INNOVATIVE AT 903-832-6684.
INNOVATIVE ENGINEERINGView on NHTSA.gov

Recent owner complaints

Reports submitted to NHTSA, shown in the owner's own words

Powertrain (other)
Filed Aug 24, 2009

TL*THE CONTACT OWNS A 2009 RANCE RRES8166TA . HE STATED THAT WHILE DRIVING APPROXIMATELY 30 MPH HE FELT EXCESSIVE VIBRATION . HE PULLED OVER TO THE SIDE OF THE ROAD AND NOTICED THAT THE FRONT AXLE WAS FRACTURED WHICH CAUSED THE PASSENGER TIRE TO FAIL. HE MADE A TEMPORARY REPAIR TO THE VEHICLE SO THAT HE COULD MAKE IT TO A SECURE AREA. HE IS IN THE PROCESS OF HAVING THE VEHICLE INSPECTED TO DETERMINE THE CAUSE OF THE FAILURE. HOWEVER HE SPECULATES THE FAILURE IS CAUSED BY ERRONEOUS SPATIAL CORRELATIONS/DESIGNS OF THE AXLES. HE CONTACTED THE MANUFACTURER IN WHICH HE FILED A COMPLAINT. THE FAILURE AND CURRENT MILEAGES WERE NOT APPLICABLE. BL

NHTSA ID
10281520
Incident
Aug 15, 2009