RoadVitals

2001 International Harvester 4300 Recalls

Safety recall campaigns filed with NHTSA that cover this model year

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
Recall campaignsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
7
Newest Jun 30, 2004
Carrying an NHTSA advisoryCampaigns where NHTSA told owners not to drive the vehicle, or to park it outside, until the repair is done.
0
Open investigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
0
1 investigation on file

Recall campaigns

7 campaigns cover this model year — what the defect is, what it could cause, and what the remedy is

04V306000

ELECTRICAL SYSTEM:12V/24V/48V BATTERY:CABLES

Jun 30, 2004
18,545 units potentially affected
The defect: ON CERTAIN HEAVY DUTY TRUCKS EQUIPPED WITH INTERNATIONAL DT530, CUMMINS, OR CATERPILLAR I-6 ENGINES, THE POSITIVE BATTERY CABLE BETWEEN THE BATTERIES AND THE STARTER MAY RUB AGAINST AN ELECTRICAL GROUND CABLE BETWEEN THE STARTER AND FRAME RAIL.
The risk: THIS COULD CAUSE AN ELECTRICAL SHORT AND/OR FIRE.
The remedy: DEALERS WILL INSPECT FOR ANY CHAFING. IF THERE IS NO EVIDENCE OF CHAFING, A SADDLE CLAMP WILL BE INSTALLED. IF THERE IS EVIDENCE OF CHAFING, THE DAMAGED CABLES WILL BE REPLACED AND THE SADDLE CLAMP INSTALLED. THE RECALL BEGAN ON AUGUST 16, 2004. OWNERS SHOULD CONTACT INTERNATIONAL AT 1-800-448-7825.
INTERNATIONAL TRUCK & ENGINE CORPORATIONManufacturer number 04510View on NHTSA.gov
03V317000

SERVICE BRAKES, AIR:SUPPLY:HOSES, LINES/PIPING, AND FITTINGS

Aug 27, 2003
686 units potentially affected
The defect: CERTAIN HEAVY DUTY TRUCKS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 121, "AIR BRAKE SYSTEMS." THE PRIMARY AND SECONDARY AIR SUPPLY HOSES FROM THE FOOT VALVE TO THE PRIMARY AND SECONDARY AIR TANKS WERE IMPROPERLY ROUTED AT THE TANK.
The risk: IF THE PRIMARY AIR CIRCUIT IS DAMAGED, THE BRAKES WILL NOT APPLY WHEN THE BRAKE PEDAL IS DEPRESSED INCREASING THE RISK OF A CRASH.
The remedy: DEALERS WILL INSPECT AND REPAIR VEHICLES. OWNER NOTIFICATION WILL BE COMPLETED BY OCTOBER 3, 2003. OWNERS WHO TAKE THEIR VEHICLE TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT INTERNATIONAL AT 1-800-448-7825.
INTERNATIONAL TRUCK & ENGINE CORPORATIONManufacturer number 03514View on NHTSA.gov
03V161000

VISIBILITY:WINDSHIELD WIPER/WASHER

Apr 29, 2003
15,354 units potentially affected
The defect: CERTAIN HEAVY DUTY TRUCKS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 104, "WINDSHIELD WIPING AND WASHING SYSTEMS." DUE TO THE DESIGN OF THE WINDSHIELD WASHER PUMP MOTOR CIRCUIT, THE SYSTEM'S ABILITY TO FUNCTION IS IMPAIRED WHEN IT IS FULL OF FROZEN WATER AND THE PUMP MOTOR SHAFT IS LOCKED OR FROZEN (CANNOT ROTATE).
The risk: ANY RESULTANT REDUCED VISIBILITY COULD CAUSE A CRASH.
The remedy: DEALERS WILL INSTALL A NEW 10 AMP FUSE IN PLACE OF THE 5 AMP FUSE AND A NEW 10 AMP LABEL WILL BE PLACED OVER THE ORIGINAL 5 AMP DESIGNATION ON THE FUSE PANEL LABEL. OWNER NOTIFICATION BEGAN ON JUNE 27, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT INTERNATIONAL AT 1-800-448-7825.
INTERNATIONAL TRUCK & ENGINE CORPORATIONManufacturer number 01516View on NHTSA.gov
03V062000

SERVICE BRAKES, HYDRAULIC:FOUNDATION COMPONENTS:DISC

Feb 25, 2003
35,074 units potentially affected
The defect: ON CERTAIN SCHOOL AND TRANSIT BUSES BUILT WITH BOSCH ZERO OFFSET PIN SLIDE (ZOPS) HYDRAULIC DISC BRAKES, THE ZOPS HYDRAULIC DISC BRAKES MAY EXPERIENCE CALIPERS STICKING IN THE APPLIED POSITION, WHICH CAN RESULT IN EXCESSIVE OR ABNORMAL HEAT GENERATION AT ONE OR MORE OF THE BRAKES.
The risk: THE COMBINATION OF THE FOLLOWING FACTORS MAY COLLECTIVELY RESULT IN AN UNREASONABLE RISK TO MOTOR VEHICLE SAFETY: POTENTIAL FIRE AT A WHEEL END, HIGH INCIDENT RATES OF STUCK CALIPERS, AND EVACUATION AND CONTAINMENT CONCERNS RELATING TO MULTIPLE PASSENGERS.
The remedy: INTERNATIONAL WILL NOTIFY ITS CUSTOMERS AND REPAIR THE BUSES FREE OF CHARGE. THE RECALL BEGAN OCTOBER 29, 2004.
INTERNATIONAL TRUCK & ENGINE CORPORATIONManufacturer number 03502/04501View on NHTSA.gov
02V174000

POWER TRAIN:CLUTCH ASSEMBLY

Jul 12, 2002
13,052 units potentially affected
The defect: ON CERTAIN HEAVY DUTY TRUCKS EQUIPPED WITH MANUAL TRANSMISSIONS, LOWER CLUTCH RODS WITH TURNBUCKLES ARE FAILING FROM FATIGUE NEAR THE TURNBUCKLE DUE TO BENDING FORCES EXPERIENCED DURING EACH CLUTCH PEDAL CYCLE.
The risk: THE CLUTCH ROD CAN BREAK WITHOUT WARNING AND MAKE IT DIFFICULT TO SHIFT AND IF THE CLUTCH ROD BREAKS WHILE THE VEHICLE IS STOPPED OR DECELERATING, THE VEHICLE COULD LUNGE UNEXPECTEDLY IN THE DIRECTION OF THE SELECTED GEAR, INCREASING THE RISK OF A CRASH.
The remedy: DEALERS WILL REPLACE THE CLUTCH ROD ASSEMBLY WITH A SOLID ROD DESIGN THAT DOES NOT HAVE A TURNBUCKLE. OWNER NOTIFICATION BEGAN JULY 19, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT INTERNATIONAL AT 1-800-448-7825.
INTERNATIONAL TRUCK AND ENGINEManufacturer number 02507View on NHTSA.gov
01V315000

EXTERIOR LIGHTING:HEADLIGHTS:SWITCH

Oct 3, 2001
13,492 units potentially affected
The defect: VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS. THESE VEHICLES COULD EXPERIENCE A LOSS OF THE LOW BEAM HEADLIGHTS, THE HIGH BEAM HEADLIGHTS, OR BOTH. A SOFTWARE PROBLEM WITHIN THE ELECTRICAL SYSTEM CONTROLLER (ESC) CAN CAUSE THE CIRCUIT FOR THE LOW BEAM OR THE CIRCUIT FOR THE HIGH BEAM HEADLIGHTS TO FUSE OR OPEN, RESULTING IN LOSS OF EITHER THE LOW OR HIGH BEAM HEADLIGHTS OR POSSIBLY EVEN BOTH.
The risk: A HEADLIGHT FUSING CONDITION COULD OCCUR WITHOUT WARNING TO THE DRIVER AND POTENTIALLY LEAVE THE DRIVER IN A BLACKOUT SITUATION WHILE OPERATING THE VEHICLE IN THE DARK.
The remedy: DEALERS WILL REPROGRAM THE ESC. OWNER NOTIFICATION IS EXPECTED TO BEGIN OCTOBER 12, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT INTERNATIONAL AT 1-800-448-7825.
INTERNATIONAL TRUCK AND ENGINEManufacturer number 01514View on NHTSA.gov
01V212000

UNKNOWN OR OTHER

Jun 26, 2001
957 units potentially affected
The defect: VEHICLE DESCRIPTION: HEAVY DUTY TRUCKS. THERE IS AN ELECTRICAL PROBLEM WITH A REMOTE POWER MODULE. THESE VEHICLES WERE BUILT WITH THE ABILITY TO ADD SIX REMOTE SWITCHES PER MODULE, WHICH ARE MOUNTED OUTSIDE THE CAB AND ARE USED TO TURN ON AND OFF CIRCUITS THAT PERFORM CUSTOM ELECTRICAL FUNCTIONS. IF TWO OR MORE REMOTE SWITCHES ARE ACTUATED ON WITHIN 100MS OF ONE ANOTHER, ALL SIX OF THE OUTPUTS ON THE REMOTE POWER MODULE WILL TURN ON. IF TWO OR MORE REMOTE SWITCHES ARE ACTUATED OFF WITH 100MS OF ONE ANOTHER, ALL SIX OF THE OUTPUTS ON THE REMOTE POWER MODULE WITH TURN OFF.
The risk: UNINTENTIONAL ACTIVATION OF REMOTE BODY ACCESSORIES COULD CAUSE A CRASH RESULTING IN PROPERTY DAMAGE, PERSONAL INJURY, OR DEATH.
The remedy: DEALERS WILL REPLACE ALL THE REMOTE POWER MODULES. OWNER NOTIFICATION BEGAN JULY 27, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT INTERNATIONAL AT 1-800-448-7825.
INTERNATIONAL TRUCK AND ENGINEManufacturer number 01508View on NHTSA.gov

What a recall is

Safety recall
A safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
Safety investigation
NHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
Manufacturer communication
Manufacturers file copies of the bulletins they send to dealers with NHTSA. These often describe diagnostic or repair procedures for a known condition. They are not recalls: repairs described in a bulletin are usually only free if the vehicle is still under warranty or the manufacturer has extended coverage.

Safety investigations

NHTSA inquiries naming this vehicle. An investigation is not a finding of a defect, and it is not a recall.

EA02034ClosedEngineering Analysis

OVERHEATING FRONT AND REAR BRAKES

Opened Dec 3, 2002
Closed Feb 10, 2004

THIS INVESTIGATION FOCUSED ON INTERNATIONAL MEDIUM DUTY TRUCKSAND SCHOOL BUS CHASSIS WEIGHING UP TO 33,000 POUNDS, EQUIPPED WITH HYDRAULIC BRAKES AND BUILT WITH THE BOSCH ZERO OFFSET PIN SLIDE (ZOPS)BRAKE SYSTEM CALIPERS.INTERNATIONAL USED THE ZOPS CALIPERS FROM APRIL 1997 THROUGH JUNE 2002.ODI WAS CONCERNED ABOUT REPORTS OF THE BRAKE CALIPERS STICKING IN THE APPLIED POSITION, RESULTING IN EXCESSIVE HEAT.AS THE INVESTIGATION PROGRESSED, ODI BECAME AWARE OF WHEEL END FIRES, SOME OF WHICH OCCURRED ON SCHOOL BUSES.DURING THE INVESTIGATION ODI OBTAINED WARRANTY DATA WHICH WAS SORTED AND ANALYZED BY VRTC TEST ENGINEERS AND ODI TO GAIN AN UNDERSTANDING OF THE MAGNITUDE OF THE PROBLEM.AFTER A THOROUGH WARRANTY DATA ANALYSIS, RELATED TESTING AND DOCUMENT REVIEWS, ODI MET WITH INTERNATIONAL, SHARED THE DATA ANALYSIS AND SHORTLY AFTERWARDS, INTERNATIONAL AGREED TO A SAFETY RECALL.FURTHER DETAILS ARE INCLUDED ON PAGES 2 - 4.

SERVICE BRAKES, HYDRAULICLed to recall 03V062000

Elsewhere on this vehicle

Data sources