RoadVitals

2001 International Harvester 5500I

Recalls, owner-reported complaints, investigations and safety data

Owner complaintsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
0
Safety recallsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
1
Latest Jun 7, 2001
InvestigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
0
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
0

Overview

Our database contains no NHTSA owner-reported complaints for the 2001 International Harvester 5500I. 1 safety recall has been issued covering this model year; and 3 manufacturer communications are on file.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

Safety recalls

1 campaign cover this model year

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
01V187000

STEERING:LINKAGES:ARM:IDLER AND ATTACHMENT

Jun 7, 2001
109 units potentially affected
The defect: VEHICLE DESCRIPTION: HEAVY DUTY VEHICLES EQUIPPED WITH A 20,000 POUND RATED DANA I-200 FRONT STEER AXLES. THERE ARE VISIBLE CRACKS IN THE SEAL DIAMETER AND LARGE BEARING DIAMETER ON THE FRONT AXLE KNUCKLES, WHICH CAN REDUCE THE LIFE EXPECTANCY OF THE KNUCKLES.
The risk: IF ONE OF THE SUSPECT STEERING KNUCKLES FAILS, THE WHEEL AT THAT WHEEL END WOULD COMPLETELY SEPARATE FROM THE VEHICLE WITHOUT WARNING AND THE DRIVER WOULD EXPERIENCE A SUDDEN LOSS OF STEERING CONTROL, INCREASING THE RISK OF A CRASH.
The remedy: DEALERS WILL REPLACE THE TWO FRONT STEERING KNUCKLES. OWNER NOTIFICATION BEGAN JULY 20, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT INTERNATIONAL AT 1-800-448-7825.
INTERNATIONAL TRUCK AND ENGINEManufacturer number 01507View on NHTSA.gov

Recent owner complaints

Reports submitted to NHTSA, shown in the owner's own words

No owner complaints recorded for this model year

Either none have been filed with NHTSA, or this vehicle is too new for reports to have accumulated.

Manufacturer communications

A bulletin sent by a manufacturer to its dealers. Not a recall, and repairs are not necessarily free.

IK-0400088

SERVICE BRAKES

INTERNATIONAL: PROCEDURE INFORMATION TO RESOLVE ISSUE OF OVERHEATING AND SMOKING OF LOW MILEAGE, SINGLE WHEEL END BRAKE. *PE UPDATED 11/4/14. *PE UPDATED 1/27/15. *PE UPDATED 1/30/15. *PE

050501

STEERING

CORRECT METHOD TO DETERMINE POWER STEERING RESERVOIR OIL FILL LEVEL FOR INTERNATIONAL MODELS WITH 2002 EMISSION ENGINES AND BUS MODELS BUILT AFTER 3/12/04. *TT

04904

ENGINE AND ENGINE COOLING:EXHAUST SYSTEM:EMISSION CONTROL

FAN BLADE TO FAN SHROUND CONTACT IN 5500I AND 5600I MODELS BUILT BETWEEN NOVEMBER 1, 2002 AND MARCH 31, 2004 WITH POST CUMMINS AND CATERPILLAR EMISSION ENGINES. *MJ

Manufacturers file copies of the bulletins they send to dealers with NHTSA. These often describe diagnostic or repair procedures for a known condition. They are not recalls: repairs described in a bulletin are usually only free if the vehicle is still under warranty or the manufacturer has extended coverage.