RoadVitals

2001 International Harvester 7400

Recalls, owner-reported complaints, investigations and safety data

Owner complaintsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
0
Safety recallsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
3
Latest Jun 30, 2004
InvestigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
0
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
0

Overview

Our database contains no NHTSA owner-reported complaints for the 2001 International Harvester 7400. 3 safety recalls have been issued covering this model year; and 9 manufacturer communications are on file.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

Safety recalls

3 campaigns cover this model year

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
04V306000

ELECTRICAL SYSTEM:12V/24V/48V BATTERY:CABLES

Jun 30, 2004
18,545 units potentially affected
The defect: ON CERTAIN HEAVY DUTY TRUCKS EQUIPPED WITH INTERNATIONAL DT530, CUMMINS, OR CATERPILLAR I-6 ENGINES, THE POSITIVE BATTERY CABLE BETWEEN THE BATTERIES AND THE STARTER MAY RUB AGAINST AN ELECTRICAL GROUND CABLE BETWEEN THE STARTER AND FRAME RAIL.
The risk: THIS COULD CAUSE AN ELECTRICAL SHORT AND/OR FIRE.
The remedy: DEALERS WILL INSPECT FOR ANY CHAFING. IF THERE IS NO EVIDENCE OF CHAFING, A SADDLE CLAMP WILL BE INSTALLED. IF THERE IS EVIDENCE OF CHAFING, THE DAMAGED CABLES WILL BE REPLACED AND THE SADDLE CLAMP INSTALLED. THE RECALL BEGAN ON AUGUST 16, 2004. OWNERS SHOULD CONTACT INTERNATIONAL AT 1-800-448-7825.
INTERNATIONAL TRUCK & ENGINE CORPORATIONManufacturer number 04510View on NHTSA.gov
04V144000

POWER TRAIN:DRIVELINE:UNIVERSAL JOINT

Mar 22, 2004
2,021 units potentially affected
The defect: ON CERTAIN TRUCKS EQUIPPED WITH DT466 OR DT530 1308 STYLE ENGINES AND 4X4 OR 6X6 CAPABILITY, THE UNIVERSAL JOINT BETWEEN THE FRONT DRIVE SHAFT AND DRIVE AXLE COULD COME IN CONTACT WITH THE ENGINE OIL FILTER UNDER CERTAIN BRAKING CONDITIONS.
The risk: THIS COULD CAUSE A LOSS OF COMPLETE ENGINE OIL WHICH COULD RESULT IN THE ENGINE SHUTTING DOWN AND INCREASE THE RISK OF PROPERTY DAMAGE, PERSONAL INJURY, OR A CRASH.
The remedy: DEALERS WILL INSTALL A SHORTER OIL FILTER AND ADAPTER. OWNER NOTIFICATION IS EXPECTED TO BEGIN APRIL 29, 2004. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT INTERNATIONAL AT 1-800-448-7825.
INTERNATIONAL TRUCK & ENGINE CORPORATIONManufacturer number 04504View on NHTSA.gov
03V161000

VISIBILITY:WINDSHIELD WIPER/WASHER

Apr 29, 2003
15,354 units potentially affected
The defect: CERTAIN HEAVY DUTY TRUCKS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 104, "WINDSHIELD WIPING AND WASHING SYSTEMS." DUE TO THE DESIGN OF THE WINDSHIELD WASHER PUMP MOTOR CIRCUIT, THE SYSTEM'S ABILITY TO FUNCTION IS IMPAIRED WHEN IT IS FULL OF FROZEN WATER AND THE PUMP MOTOR SHAFT IS LOCKED OR FROZEN (CANNOT ROTATE).
The risk: ANY RESULTANT REDUCED VISIBILITY COULD CAUSE A CRASH.
The remedy: DEALERS WILL INSTALL A NEW 10 AMP FUSE IN PLACE OF THE 5 AMP FUSE AND A NEW 10 AMP LABEL WILL BE PLACED OVER THE ORIGINAL 5 AMP DESIGNATION ON THE FUSE PANEL LABEL. OWNER NOTIFICATION BEGAN ON JUNE 27, 2003. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT INTERNATIONAL AT 1-800-448-7825.
INTERNATIONAL TRUCK & ENGINE CORPORATIONManufacturer number 01516View on NHTSA.gov

Recent owner complaints

Reports submitted to NHTSA, shown in the owner's own words

No owner complaints recorded for this model year

Either none have been filed with NHTSA, or this vehicle is too new for reports to have accumulated.

Manufacturer communications

A bulletin sent by a manufacturer to its dealers. Not a recall, and repairs are not necessarily free.

IK-0400088

SERVICE BRAKES

INTERNATIONAL: PROCEDURE INFORMATION TO RESOLVE ISSUE OF OVERHEATING AND SMOKING OF LOW MILEAGE, SINGLE WHEEL END BRAKE. *PE UPDATED 11/4/14. *PE UPDATED 1/27/15. *PE UPDATED 1/30/15. *PE

061302

POWER TRAIN:TRANSFER CASE (4-WHEEL DRIVE)

GUIDELINES TO ENSURE SATISFACTORY PERFORMANCE OF MERITOR TRANSFER CASE MODELS MTC-4208, MTC-4210, MTC-4213 IN CERTAIN INTERNATIONAL 7000 HPV MODELS. *TT

061208

ENGINE AND ENGINE COOLING:ENGINE

THE ENGINE TURBOCHARGER CLEAN AIR INTAKE HOSE NIPPLE THAT PROVIDES AIR TO THE AIR COMPRESSOR MAY DISCONNECT FROM THE INTAKE HOSE IN A LIMITED NUMBER OF INTERNATIONAL 7300 MODELS BUILT BETWEEN DECEMBER 01, 2004 WITH INTERNATIONAL I-6 ENGINES. *TT

051206

ENGINE AND ENGINE COOLING:ENGINE

INSTALLING A HEAT SHIELD TO THE EXHAUST MANIFOLD TO PROTECT THE TURBOCHARGER INLET HOSE ON 7000 MODELS BUILT AFTER JULY 1, 2001 WITH DT 466 ENGINE CODES 12NMG, 12NMH, AND 12NMK. INTERNATIONAL. 2001 MODEL 7600 INCLUDED. *TT

050501

STEERING

CORRECT METHOD TO DETERMINE POWER STEERING RESERVOIR OIL FILL LEVEL FOR INTERNATIONAL MODELS WITH 2002 EMISSION ENGINES AND BUS MODELS BUILT AFTER 3/12/04. *TT

041607

EQUIPMENT:APPLIANCE:AIR CONDITIONER

CRITERIA FOR CONDITIONING ACCUMULATOR REPLACEMENT ON HPV MODELS. *TT

Manufacturers file copies of the bulletins they send to dealers with NHTSA. These often describe diagnostic or repair procedures for a known condition. They are not recalls: repairs described in a bulletin are usually only free if the vehicle is still under warranty or the manufacturer has extended coverage.