RoadVitals

2005 International 4200 Problems

Owner-reported complaints filed with NHTSA, grouped by component

Data refreshed

Owner complaintsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
1
Latest Jun 20, 2007
Components namedHow many of our component categories appear on at least one report for this model year. One report can name several.
1
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
0

What this page shows

Everything below is an owner-reported complaint submitted to NHTSA about the 2005 International 4200, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

Reports by component

Ranked by how many owner reports name each component category

  • Brakes1100.0%

Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.

Each component in detail

What the reports in each category say, in the owners' own words

Brakes

Reports naming service brakes, the antilock braking system, brake hoses, master cylinders or the parking brake.

1
report

From owner reports, verbatim

PREMATURE AND EXCESSIVE BRAKE WEAR ON ROTORS AND PADS ON A 2005 4200 INTERNATIONAL TRUCK. IT HAD CRITICAL INNER BRAKE PAD AND ROTOR WEAR ON THE FRONT AND REAR. FRONT LEFT ROTOR AND PAD WEAR WAS DUE TO FAILURE OF CALIPER, CAUSING THE TRUCK TO SNAP INTO ONCOMING TRAFFIC WHEN UNDER BRAKING. RIGHT FRONT WEAR TO BOTH ROTOR AND PAD DUE TO SLIDE PINS ON CALIPER NOT RETURNING PADS TO NORMAL POSITION. TRUCK HAD COMPLETE REAR ROTORS AND PAD DESTROYED DUE TO NONE SLIDING SLIDE PINS. PASSENGER REAR ROTOR INNER BRAKING SURFACE WAS GROUND DOWN TO 1/8 INCH WHILE THE OUTER SURFACE APPEARED TO BE WITHIN NORMAL SPECIFICATIONS. TRUCK ONLY HAS 36,693 MILES. *AK

NHTSA ID 10193849 · filed Jun 20, 2007

Too few reports in this category for a page of its own — they appear in the full complaint list.

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.

Elsewhere on this vehicle

Data sources

Data on this page last refreshed .