2002 International 7400 Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2002 International 7400, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Engine150.0%
- Fuel system150.0%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Engine
Reports naming the engine itself — including stalling, misfires, oil consumption, cooling and internal engine components.
From owner reports, verbatim
TL*THE CONTACT OWNS A 2002 INTERNATIONAL 7400. THE CONTACT STATED THAT THE VEHICLE WAS LEAKING FUEL AND OIL IN THE HIGH PRESSURE FUEL RAIL. ON SEPTEMBER 6, 2006, THE VEHICLE WAS TAKEN IN FOR SERVICE AND THE REPAIR WAS PERFORMED UNDER WARRANTY. THE LEAK RESUMED WHEN THE WARRANTY EXPIRED IN JULY OF 2007. THE FAILURE OCCURS WHENEVER THE ENGINE IS RUNNING AND IS LOCATED DIRECTLY ABOVE THE STARTER NEAR SEVERAL ELECTRICAL PARTS. THE SPEED WAS UNKNOWN. THE CURRENT MILEAGE WAS 23,983 AND FAILURE MILEAGE WAS 23,590.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Fuel system
Reports naming fuel storage or delivery — tanks, pumps, lines, injectors and fuel leaks.
From owner reports, verbatim
TL*THE CONTACT OWNS A 2002 INTERNATIONAL 7400. THE CONTACT STATED THAT THE VEHICLE WAS LEAKING FUEL AND OIL IN THE HIGH PRESSURE FUEL RAIL. ON SEPTEMBER 6, 2006, THE VEHICLE WAS TAKEN IN FOR SERVICE AND THE REPAIR WAS PERFORMED UNDER WARRANTY. THE LEAK RESUMED WHEN THE WARRANTY EXPIRED IN JULY OF 2007. THE FAILURE OCCURS WHENEVER THE ENGINE IS RUNNING AND IS LOCATED DIRECTLY ABOVE THE STARTER NEAR SEVERAL ELECTRICAL PARTS. THE SPEED WAS UNKNOWN. THE CURRENT MILEAGE WAS 23,983 AND FAILURE MILEAGE WAS 23,590.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .