RoadVitals

2007 Itasca Ellipse Recalls

Safety recall campaigns filed with NHTSA that cover this model year

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
Recall campaignsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
5
Newest Oct 26, 2010
Carrying an NHTSA advisoryCampaigns where NHTSA told owners not to drive the vehicle, or to park it outside, until the repair is done.
0
Open investigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
0

Recall campaigns

5 campaigns cover this model year — what the defect is, what it could cause, and what the remedy is

10V525000

EQUIPMENT

Oct 26, 2010
18,461 units potentially affected
The defect: WINNEBAGO IS RECALLING CERTAIN RECREATIONAL VEHICLES EQUIPPED WITH 1200-SERIES NORCOLD REFRIGERATORS. THE POPULATION OF REFRIGERATORS BEING ADDRESSED CONTAINS EITHER A SENSING ALGORITHM OR THERMAL SWITCH TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED IN ORDER TO PREVENT A POTENTIAL FIRE. THE RESPONSE TIMES OF THE SENSOR ALGORITHM AND THERMAL SWITCH DEVICES TO STOP POWER ARE NOT SUFFICIENT.
The risk: THE SENSING ALGORITHM OR THERMAL SWITCH INSTALLED TO SHUT OFF POWER TO THE REFRIGERATOR WHEN HIGH TEMPERATURES ARE DETECTED DUE TO A POSSIBLE HYDROGEN GAS LEAK MAY NOT SHUT OFF IN SUFFICIENT TIME TO PREVENT A FIRE.
The remedy: WINNEBAGO IS WORKING WITH NORCOLD TO IDENTIFY AND NOTIFY ANY AFFECTED OWNERS. OWNERS WILL BE INSTRUCTED TO CONTACT NORCOLD DEALERS TO RECEIVE THE REMEDY FREE OF CHARGE. PLEASE SEE NORCOLD'S DEFECT REPORT 10E-049 FOR ADDITIONAL INFORMATION. THE RECALL BEGAN DURING DECEMBER 2010. OWNERS MAY CONTACT NORCOLD AT 1-800-767-9101 OR WINNEBAGO AT 1-641-585-3535.
WINNEBAGO INDUSTRIES, INC.View on NHTSA.gov
08V223000

STEERING:HYDRAULIC POWER ASSIST SYSTEM

May 19, 2008
1,699 units potentially affected
The defect: WINNEBAGO IS RECALLING 1,699 MY 2005-2009 WINNEBAGO JOURNEY, TOUR AND ITASCA MERIDIAN AND ELLIPSE MOTOR HOMES BUILT ON THE FREIGHTLINER XC CHASSIS. THE CHASSIS CONTAINS STEERING FILTERS THAT CAN PLUG DUE TO FAILURE OF THE SCREEN ADHESION TO THE FILTER HOUSING CAUSING A RISE IN RETURN LINE PRESSURE POTENTIALLY LEADING TO A HOSE SEPARATION FROM THE FILTER OR STEERING GEAR FITTING RESULTING IN A SUDDEN LOSS OF STEERING FLUID AND POWER ASSIST.
The risk: SUDDEN LOSS OF STEERING ASSIST WITHOUT WARNING INVOLVING A MOTOR HOME COULD BE A PROBLEM FOR CERTAIN DRIVERS INCREASING THE RISK OF A CRASH.
The remedy: FREIGHTLINER IS CONDUCTING THIS RECALL AND WILL REPLACE THE AFFECTED FILTERS WITH A LARGER FILTER (PLEASE SEE 07V570). OWNERS MAY CONTACT FREIGHTLINER AT 1-800-547-0712 OR WINNEBAGO AT 1-641-585-3535.
WINNEBAGO INDUSTRIES, INC.View on NHTSA.gov
08V226000

STEERING:LINKAGES:TIE ROD ASSEMBLY

May 19, 2008
306 units potentially affected
The defect: WINNEBAGO IS RECALLING 306 MY 2007-2008 JOURNEY, DESTINATION, TOUR AND ITASCA MERIDIAN, LATITUDE, AND ELLIPSE MOTOR HOMES BUILT ON FREIGHTLINER CHASSIS. THE FASTENERS THAT ATTACH THE STEERING ARM OR TIE ROD ARMS TO THE SPINDLE MAY BE OVER OR UNDER-TIGHTENED.
The risk: INCORRECTLY TIGHTENED STEERING ARM FASTENERS MAY FATIGUE AND FRACTURE WHICH COULD CAUSE A CRASH WITHOUT WARNING.
The remedy: WINNEBAGO IS WORKING WITH FREIGHTLINER TO REPAIR THESE VEHICLES FREE OF CHARGE (PLEASE SEE 07V306). OWNERS MAY CONTACT FREIGHTLINER AT 1-800-547-0712 OR WINNEBAGO AT 1-641-585-3535.
WINNEBAGO INDUSTRIES, INC.View on NHTSA.gov
07V491000

EXTERIOR LIGHTING

Oct 18, 2007
645 units potentially affected
The defect: CERTAIN MOTOR HOMES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 108, 'LAMPS, REFLECTIVE DEVICES, AND ASSOCIATED EQUIPMENT.' THE REAR AND REAR-SIDE RED REFLECTORS ARE LOCATED ABOVE THE 60-INCH HEIGHT LIMIT.
The risk: NON-STANDARD SIDE MARKER AND REFLECTOR LIGHTS COULD REDUCE VISIBILITY OF VEHICLES AND INCREASE THE POTENTIAL FOR A CRASH.
The remedy: DEALERS WILL ADD REFLEX REFLECTORS IN COMPLIANT LOCATIONS FREE OF CHARGE. THE RECALL BEGAN ON DECEMBER 5, 2007. OWNERS MAY CONTACT WINNEBAGO AT 641-585-3535.
WINNEBAGO INDUSTRIES, INC.Manufacturer number 107View on NHTSA.gov
07V390000

ENGINE AND ENGINE COOLING:ENGINE:DIESEL

Aug 29, 2007
108 units potentially affected
The defect: ON CERTAIN MOTOR HOMES BUILT WITH CUMMINS ISL CM850 DIESEL ENGINES, THE CONNECTING ROD CONTAINS A MACHINING DEFECT IN THE WRIST PIN BUSHING OF THE ROD THAT COULD CAUSE A SEIZURE OF THE PISTON PIN.
The risk: IF ALLOWED TO PROGRESS, THIS CAN LEAD TO ENGINE FAILURE WITH THE POSSIBILITY OF THE ROD RUPTURING THE LOCK CAVITY, SPILLING OIL AND DEBRIS ONTO THE ROADWAY INCREASING THE RISK OF A CRASH.
The remedy: WINNEBAGO IS WORKING WITH CUMMINS TO RECALIBRATE THE ENGINE CONTROL MODULE AND ENHANCE THE ENGINE PROTECTION SYSTEM ENABLING IT TO PROVIDE EARLY DETECTION OF THE FAILURE MODE AND AVOID MORE SERIOUS ENGINE DAMAGE AND RESULTANT SAFETY HAZARD. CUMMINS WILL ALSO INSTALL A NEW VALVE COVER WITH A CRANKCASE PRESSURE SENSOR FREE OF CHARGE (PLEASE SEE 07E033). OWNERS MAY CONTACT CUMMINS AT 1-800-343-7357 OR WINNEBAGO AT 641-585-3535.
WINNEBAGO INDUSTRIES, INC.View on NHTSA.gov

What a recall is

Safety recall
A safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
Safety investigation
NHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
Manufacturer communication
Manufacturers file copies of the bulletins they send to dealers with NHTSA. These often describe diagnostic or repair procedures for a known condition. They are not recalls: repairs described in a bulletin are usually only free if the vehicle is still under warranty or the manufacturer has extended coverage.

Elsewhere on this vehicle

Data sources