2016 Jeep Renegade Engine Problems

The contact owns a 2016 Jeep Renegade. The contact stated that while driving at an undisclosed speed, there was an abnormal sound while the cooling fan was in operation. The contact stated that the sound became louder over time. The vehicle was taken to a dealer to be diagnosed. The vehicle was diagnosed with fan bearing and spindle failure. The vehicle was not repaired. The contact stated that after leaving the dealer, the engine started to overheat, and the coolant temperature gauge moved into the red zone. No warning lights were illuminated. The manufacturer was notified of the failure. The approximate failure mileage was 127,000.

NHTSA ID

11744762

Incident

Feb 25, 2026

Mileage

127,000 mi

The contact's son owned a 2016 Jeep Renegade. The contact stated that after his son parked the vehicle in the driveway and turned the vehicle off, the son entered the home and moments later noticed an orange glow coming from outside. The son went outside to investigate and discovered a foot tall flames coming from under the hood of the vehicle. The son attempted to use a fire extinguisher to extinguish the flames, but was unsuccessful. The fire department was called to the scene and extinguished the fire. During the incident, the vehicle was destroyed, and the detached garage was also damaged by the flames. The cause of the failure was not determined. The manufacturer and local dealer were not yet contacted. The failure mileage was 80,000.

NHTSA ID

11721913

Incident

Mar 4, 2024

Mileage

80,000 mi

My car just shut off out of now where while I was driving, tried to turn it on and wouldn’t start, get u I was in the middle of the road bc it just shut off. I left it off for about 10 minutes and finally it turned back on but yet the battery and everything was good on the car, this is definitely a road hazard ⚠️!

NHTSA ID

11684681

Incident

Aug 22, 2025

Vehicle was returning Diagnostic code P0653 and P2138 it was taken to the dealership for servicing on 04/26/2025. Pedal position sensor was identified as the issue. Part was on national backorder for several weeks. and issue was repaired on 05/22/25. Vehicle was driven less than 100 miles and presented with the same issue on 06/26/2025 and was returned to the dealership for servicing. Service department reset the code and drove the vehicle for less than 100 miles, and indicated they could not reproduce the problem. Car was left at the dealership for a week for additional diagnostic. Car was picked up on 07/12/2025 from the dealership and on 07/15/2025 car was returned for third time to repair the issue with the same codes. A case was opened with Stellantis. At this poin car is still being repaired for the same issue. When issue occurs car goes into limp mode, and runs at 50% throttle, and has on occasion completely lost power sometimes causing some safety concerns. Vehicle was able to drive in limp mode first two times, third time required towing to the dealership

NHTSA ID

11675311

Incident

Apr 26, 2025

Summary of Ongoing Issues with Shaver Automotive & Stellantis Regarding W80 Recall -Initial Reporting (December 2018): At 35,104 miles, I first reported engine stalling, performance issues, and excessive oil consumption to Shaver Automotive. -Recall Notification & Incomplete Testing (January 2024): I received a recall letter in January 2024 for the W80 oil consumption test. Shaver Automotive performed the first part of the test but instructed me to return for Part 2—which they subsequently delayed. -Delays & Failed Recall Test (July 2024–January 2025): From July to December 2024, Shaver ignored multiple requests to schedule the second test. In January 2025, part 2 of the test was finally conducted. W80 Recall test failed, prompting a promise of a new engine installation by mid-to-late March 2025. -Dealership Fraud & Negligence (March–June 2025): From March to June 2025, Shaver: -Ignored all follow-up requests for updates. -Falsified service records, including a fabricated appointment on 3/26/25 while I was out of town. -Falsified mileage on my Jeep at said fabricated appointment. -Closed my Stellantis case without notification, obstructing resolution. -Stellantis’ Failure to Intervene (2024–2025): Despite three active case numbers (#93024832, #93352240, #93372613), Stellantis repeatedly directed me back to Shaver Automotive, refusing to escalate or resolve the issue. -Legal & Ethical Violations: Shaver’s misconduct, mileage tampering, falsified documents, and deliberate delays, has left me with an unsafe vehicle for over 18 months, violating: -Consumer protection laws (e.g., Magnuson-Moss Warranty Act). -Recall compliance obligations under NHTSA guidelines. Stellantis’ negligence in overseeing its dealership network exacerbated the harm.

NHTSA ID

11667980

Incident

Jan 1, 2025

No oil change light, no engine light. Excessive Oil consumption engine Metal to metal brakes

NHTSA ID

11667163

Incident

Jun 16, 2025

The engine cooling fan failed. The vehicle was repaired by Firestone, and we have the old parts in case an inspection is needed. This failure put myself and others at risk because had I not been close to home when the engine light came on, the engine would have overheated. My daily commute is over 50 miles, and this could have caused an accident if it had happened on the highway. The problem was confirmed by a service center (Firestone). The entire fan assembly needed to be replaced since the bracket was also broken. The component has not been inspected by the manufacturer, police, insurance representatives or others. The check engine light first came on while I was driving home from the store on 5/31/25. Then, the A/C stopped cooling. I stopped by Advance Auto Parts Store, and they checked the engine code (P0481) and advised me to purchase a fuse. When I arrived home and checked under the hood, I found that there was indeed a blown fuse. After replacing the fuse, I noticed that the fan was shaking and rattling. I then took the vehicle to the local Firestone center and they diagnosed the problem. I searched online to see if other Renegade owners had reported problems with the engine cooling fan and found that there was a recall (Recall Number: V54 - Engine Cooling Fan) for 2015 - 2017 Jeep Renegades for this same issue. However, it seems that my vehicle was not included in the recall. I am requesting that my vehicle be included in the recall so I can be reimbursed for the $1,053 that I spent on this repair.

NHTSA ID

11665433

Incident

May 31, 2025

The jerking, delayed take off reported originally that was supposedly corrected with a motor replacement STILL happens. Spoken with multiple other Renegade drivers and tow truck drivers, the transmission appears to be the issue. Each recorded visit to the dealership has reported transmission ok. My safety is my absolute #1 concern. Want transmission checked, rechecked, repaired, replaced or whatever makes my driving life safe as possible.

NHTSA ID

11646162

Incident

Aug 25, 2017

8/23 I was informed of a recall on my engine due to oil consumption. I took my vehicle to Jeep & completed an oil consumption test being told my car was affected & the engine would be replaced. I was told that there’s a long wait & could be 6mos or more. I started calling after 6mos & was told over & over again the engine hadn’t arrived then referred to the manufacturer for resolution. The manufacturer said nothing was ever reported to them. I went to Autonation to get to the bottom of things & they’re acting like none of this ever happened while asking me what I want them to do about it smirking as if this is funny.

NHTSA ID

11645522

Incident

Sep 29, 2023

On 3 occasions, in the past three weeks, the vehicle has lost power while in motion and display states “shift to park”. Restarting vehicle is required. This occurs while in motion and could be dangerous for driver and passenger. Car repair unable to diagnose issue. Reported numerous codes concerning “communication errors”

NHTSA ID

11638911

Incident

Jan 24, 2025

Complaint #11629826. i also have had safety issues with my 2016 Jeep Renegade. Engine shuts down while driving flashes check engine signs and has to be put in park to be restarted. Currently, engine stops while driving and " emergency brake goes on " I have to restart jeep and drive with emergency brake on because it won't go off even though I have not set the brake on. This is happening frequently and almost was hit on the highway due to Jeep engine stopping while I was driving. I have had it in for service several times and paid for software/connection replacements etc. Problem still exists and very dangerous. Jeep dealership unsure how to fix the problem. Numerous dates of occurrence within the last 2 months-

NHTSA ID

11636082

Incident

Jan 14, 2025

All motor mounts poorly manufactured too light. Need recalled as its a known problem.

NHTSA ID

11630783

Incident

Nov 29, 2024

While driving the car, the wheel locked and we lost acceleration, and a warning light for the electric engine throttle came on. The car is undriveable, and we are extremely lucky that we were not in an accident. We suspect that the W79 recall for other Jeeps is implicated for our car.

NHTSA ID

11624254

Incident

Nov 8, 2024

All motor engine mounts and transmission mounts notoriously gone bad....poorly manufactured. Should be recalled to be replaced on ALL these vehicles

NHTSA ID

11615711

Incident

Sep 20, 2024

On more than one occasion, this car has stalled or stopped, leaving me coasting to the side of the road in active traffic. I was going about 30-35 mph. It has had oil consumption problems since 2021 when I purchased it. It was presented to me at point of sale as gas consumption...it wasn't getting good mileage and would need a tune up. Also misrepresented as having a spare and it did not. On 4 Aug 2024 I completed the most recent oil consumption test and it failed. Leith Jeep refused to provide me with paperwork and said "no charge." But it needed another quart of oil which I added. Before the test was completed it needed a quart of oil. I have all records and will attach here if possible or email under separate emails. Not sure how many doc can be attached. I had recall repairs made. My car is part of the class action lawsuit but is unsafe. I am told to correct I need a new engine which will cost me out of pocket $11,000.00 due to no longer under warranty. But it has had this problem since I bought it and prior, an oil consumption test was done by the dealer in possession then.

NHTSA ID

11613804

Incident

Jul 12, 2021

Was driving with cruise co trip on going about 70 mph. On an interstate. All of a sudden I saw my dash all go out and was pushing down on my accelerator and had no power and car was slowing down. Next it came back on and the the steering wheel light with exclamation showed up. Today 2 days later driving and it states service 4wd and the. When at a stop light it again did the same thing and this time shut down. This is a high priority in my mind I can’t allow younger drivers to drive. I see other complaints like this too.My spouse also observed the first time. Could of cause fatalities and or severe harm.

NHTSA ID

11606883

Incident

Aug 4, 2024

Check engine light on. ECM (engine control computer) malfunction. Dealer first denied any problems with vehicle even with check engine light on. So I took to it to independent service center, which confirm problem. By providing the service center report, the dealer then confirm problem. Problems/symptoms occur 2 days after financing vehicle.

NHTSA ID

11589583

Incident

Jan 3, 2024

Was sitting in a drive through and car started smoking. It stopped after I shut everything down. Then another time it overheated after driving for seven minutes had to stop. Air conditioning doesn’t work . Engine light on. Just bought from dealer with 20000 miles like a lemon. So not right.

NHTSA ID

11585592

Incident

Mar 14, 2024

This vehicle is constantly burning through oil between oil changes. It has stopped several times while driving only to find out it has no oil. It has been on the W80 recall list for 2 years and the dealerships in my area just say the parts are on allocation. I literally have to drive with oil in the car to refill it on the side of the road. I just got another recall notification from Jeep for U90 and they don't have parts to fix that either. I can't get it fixed. I can't sell it and I can't afford to keep it on the road. The low oil warning light does NOT come on.

NHTSA ID

11579541

Incident

Mar 7, 2024

The contact owns a 2016 Jeep Renegade. The contact stated that while driving at an undisclosed speed, the vehicle lost motive power. The contact stated he was able to restart the vehicle and drive to his residence. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The manufacturer was not made aware of the failure. The failure mileage was approximately 91,000.

NHTSA ID

11550117

Incident

Oct 13, 2023

Mileage

91,000 mi

The contact owns a 2016 Jeep Renegade. The contact stated that she had received a manufacturer recall notice, Recall Number: V54 - Engine Cooling Fan (Engine and Engine Cooling). The contact stated that the dealer determined that the cooling fan was working as designed and the fan was not replaced. The contact stated while driving at 30 MPH and various speeds, and while stopped at a traffic light, the engine would overheat. The contact stated that the temperature gauge indicated that the engine was hot. The contact stated that the failure had become a recurring failure. The contact had the vehicle towed to a local dealer, where it was diagnosed and determined that the engine cooling fan needed to be replaced. The vehicle had not been repaired. The manufacturer had been informed of the failure. The failure mileage was 117,143.

NHTSA ID

11536320

Incident

Oct 22, 2022

Mileage

117,143 mi

My customer satisfaction number is W20. I have been waiting since December 2022 to get the catalytic converter replaced. I was told there were 2 people ahead of me. Everytime I called I was told they were still trying to reach the people. They did update the software but now my Jeep is sluggish. I have to force the gas pedal to force the accelerator to the floor to pick up speed. So my gas mileage is very bad. I hope the engine does not go waiting so long to get a defective part replaced. I am in Arkansas now and will be until my Mom gets out of the hospital. I want to get my Jeep fixed now. I am close to Batesville and Jonesboro Arkansas. Please tell me where I can take my Jeep to get it repaired or do I take the recall card to any Jeep dealer. I feel I have waited long enough.

NHTSA ID

11528719

Incident

Dec 1, 2022

Basically I purchased the car dec 3,2023 from drive time . 3 weeks later it needed a new transmission.the warranty fixes the transmission I didn’t have my car for a month .The service dept said there’s a recall on my engine also so they started an oil consumption test after I picked my car up after the transmission installed. Drove the car for 1500 miles and bring it into them they said I need a new engine. I asked them so when can I set appointment for my engine they said they will get back to me . It’s been 2 months and I haven’t heard from them . I want a brand new vehicle. The dealership sold me an lemon

NHTSA ID

11512610

Incident

Feb 13, 2023

My 2016 Jeep Renegade Sport 4WD 2.4L (~87K mileage) never has given me any major issues or shown symptoms of any need for service attention recently. It has been upkept with regular oil changes and servicing as needed. I recently went on vacation and had the vehicle parked for a week and upon returning and trying to turn the vehicle on it would not start. It was not the battery as that was recently changed and the vehicle tried very hard to crank, but nothing was successful on its own we even tried charging the battery and jumping it with our other car. I had AAA finally come and they were able to start it, but as soon as you put it in "drive" to move it the engine would flood and the car would shut off. As the car would run, white smoke would flow out of the tailpipe horribly as well. I had it towed to the AAA car center since they are around the corner and they are stating the head gasket is blown and the engine will need replacement. There was no indication from the vehicle that it needed a oil change or that oil was low. There was no symptoms I encountered prior to all of this happening. It was advised NOT to have the engine machined to fix the gasket due to the mileage and age of the vehicle. I am in shock that this came out of nowhere. Again, I drove the car a few days before leaving it parked in a safe location and it's mainly driven by me and there was absolutely no indication something was even remotely wrong.

NHTSA ID

11504486

Incident

Jan 20, 2023

Same as many other people, Traction Control. When making slow left hand turns Traction Control warning light comes on and complete power loss with engine still running. I have discovered if I lift my foot off gas pedal and quickly return it I regain power. This is dangerous as many other folks have reported. The fear of a side impact is always on my mind. Not confirmed by dealer as it does happen on every turn. Finally yes available for inspection any time.

NHTSA ID

11504206

Incident

Jan 28, 2023