2005 Kawasaki EX250F19 Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2005 Kawasaki EX250F19, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Fuel system360.0%
- Body & structure120.0%
- Engine120.0%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Fuel system
Reports naming fuel storage or delivery — tanks, pumps, lines, injectors and fuel leaks.
From owner reports, verbatim
TL* THE CONTACT OWNS A 2005 KAWASAKI EX250F19. WHILE PARKED, THE CONTACT NOTICED FUEL LEAKING FROM THE FUEL TANK WHERE THE MOUNTING SCREW WAS LOCATED. THE VEHICLE WAS TAKEN TO THE DEALER FOR A DIAGNOSTIC TEST. THERE WAS A RECALL UNDER NHTSA CAMPAIGN ID NUMBER: 07V003000 (FUEL SYSTEM, GASOLINE:STORAGE) THAT MAY BE RELATED TO THE FAILURE. THE TECHNICIAN INSPECTED THE VEHICLE AND STATED THAT THE SCREW HAD NOT PUNCTURED THE FUEL TANK AND REFUSED TO PERFORM THE RECALL REPAIR. THE VEHICLE WAS NOT REPAIRED. THE APPROXIMATE FAILURE MILEAGE WAS 2,700.
MOTORCYCLE HAS A FUEL TANK LEAK AT THE MOUNTING TABS OF THE TANK. GASOLINE POURS OUT FROM AROUND THE WELD AREA OF THE FRONT MOUNTS. IT WAS POURING GASOLINE ALL OVER THE MOTOR. SOME OF THE ROADS AND FREEWAYS I TRAVEL ARE BUMPY. OCCASIONALLY, I MAY HAVE HIT POTHOLES THAT MIGHT HAVE PUT STRESS ON THE MOUNTS. UPPER FAIRING STAY ALSO BROKE, VERY COMMON FAILURE ACCORDING TO OTHER RIDERS ( HTTP://FAQ.NINJA250.ORG/WIKI/MY_UPPER_FAIRING_STAY_IS_BROKEN ), AT LOWER MOUNT AND COULD HAVE PUT STRESS ON THE GAS TANK. I HAVE BEEN RIDING THE MOTORCYCLE FOR THE PAST MONTHS WITH ANOTHER FUEL TANK FROM MY OTHER MOTORCYCLE. I CURRENTLY HAVE THE LEAKING TANK IN MY BACKYARD. *TR
Too few reports in this category for a page of its own — they appear in the full complaint list.
Body & structure
Reports naming the vehicle structure, frame, body panels, doors, hood and trim.
From owner reports, verbatim
MOTORCYCLE HAS A FUEL TANK LEAK AT THE MOUNTING TABS OF THE TANK. GASOLINE POURS OUT FROM AROUND THE WELD AREA OF THE FRONT MOUNTS. IT WAS POURING GASOLINE ALL OVER THE MOTOR. SOME OF THE ROADS AND FREEWAYS I TRAVEL ARE BUMPY. OCCASIONALLY, I MAY HAVE HIT POTHOLES THAT MIGHT HAVE PUT STRESS ON THE MOUNTS. UPPER FAIRING STAY ALSO BROKE, VERY COMMON FAILURE ACCORDING TO OTHER RIDERS ( HTTP://FAQ.NINJA250.ORG/WIKI/MY_UPPER_FAIRING_STAY_IS_BROKEN ), AT LOWER MOUNT AND COULD HAVE PUT STRESS ON THE GAS TANK. I HAVE BEEN RIDING THE MOTORCYCLE FOR THE PAST MONTHS WITH ANOTHER FUEL TANK FROM MY OTHER MOTORCYCLE. I CURRENTLY HAVE THE LEAKING TANK IN MY BACKYARD. *TR
Too few reports in this category for a page of its own — they appear in the full complaint list.
Engine
Reports naming the engine itself — including stalling, misfires, oil consumption, cooling and internal engine components.
From owner reports, verbatim
TL*THE CONTACT OWNS A 2005 KAWASAKI EX250F19. THE CONTACT STATED THAT THE VEHICLE WAS UNDER A RECALL. WHILE DRIVING 65 MPH, THE VEHICLE WAS INVOLVED IN A CRASH IN WHICH THE CONTACT'S SPOUSE SUSTAINED CUTS AND UNDERWENT SURGERY ON HER KNEE. A POLICE REPORT WAS FILED. WHILE THE VEHICLE WAS IN THE SHOP, THE CONTACT TOOK THE FUEL TANK AND THE RECALLED COMPONENT TO THE DEALER FOR REPAIR. HOWEVER, THE DEALER REFUSED TO WORK ON IT AND STATED THAT THEY NEEDED THE ENTIRE VEHICLE PRESENT IN ORDER TO PERFORM THE RECALL REPAIR. THE PURCHASE DATE, ENGINE SIZE, TRANSMISSION TYPE, POWERTRAIN, RECALL NUMBER, AND MILEAGES WERE UNKNOWN.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .