RoadVitals

2005 Kawasaki KL650A Problems

Owner-reported complaints filed with NHTSA, grouped by component

Data refreshed

Owner complaintsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
2
Latest Oct 9, 2014
Components namedHow many of our component categories appear on at least one report for this model year. One report can name several.
1
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
0

What this page shows

Everything below is an owner-reported complaint submitted to NHTSA about the 2005 Kawasaki KL650A, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

Reports by component

Ranked by how many owner reports name each component category

  • Engine2100.0%

Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.

Each component in detail

What the reports in each category say, in the owners' own words

Engine

Reports naming the engine itself — including stalling, misfires, oil consumption, cooling and internal engine components.

2
reports

From owner reports, verbatim

BALANCER CHAIN BEGAN MAKING NOISE ATTEMPTED FACTORY RECOMMENDED ADJUSTMENTS. CONCERN WAS UNRESOLVED. REMOVED STATOR COVER FOUND QUADRANT AND TENSIONER BROKEN. *TR

NHTSA ID 10643472 · filed Oct 9, 2014

ON THE BASIS OF ANECDOTAL INFORMATION I REPLACED THE STOCK BALANCER CHAIN TENSIONER ON MY 2005 KAWASAKI KLR 650 MOTORCYCLE. THESE HAVE BEEN KNOWN TO HAVE PROBLEMS IN THIS AREA, AND SURE ENOUGH THE SPRING THAT IS TO TENSION THE BALANCE CHAIN AS IT WEARS WAS BROKEN AND INOPERATIVE. THIS MEANT THAT IF I HAD NOT REPLACED THE TENSIONER ADJUSTER AND SPRING, THE CHAIN THAT RUNS THE BALANCER WOULD HAVE CONTINUED TO WEAR AND STRETCH TO THE POINT OF POSSIBLE CATASTROPHIC FAILURE. IT IS NICE THAT AMERICANS ARE MAKING A LIVING MAKING THESE PARTS, BUT HOW MANY BIKES DO NOT GET THIS REPAIR. I MENTION THIS AT DEALERSHIPS AND THEY ACT LIKE I AM SPEAKING A FOREIGN LANGUAGE. *TR

NHTSA ID 10279419 · filed Aug 5, 2009

Too few reports in this category for a page of its own — they appear in the full complaint list.

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.

Elsewhere on this vehicle

Data sources

Data on this page last refreshed .