2002 Kawasaki KLR650 Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2002 Kawasaki KLR650, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Engine866.7%
- Powertrain (other)18.3%
- Suspension18.3%
- Tires & wheels18.3%
- Visibility18.3%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Engine
Reports naming the engine itself — including stalling, misfires, oil consumption, cooling and internal engine components.
From owner reports, verbatim
I OWN A 2002 KAWASAKI KLR650 WITH APPROXIMATELY 9500 MILES ON IT. I WAS RIDING AT LOW SPEED ON THE DATE BELOW WHEN I HEARD A LOUD METAL CLANG IN THE ENGINE AND THE MOTORCYCLE CAME TO A SCREECHING HALT. LUCKILY, I WAS ONLY TRAVELING AT 30 MPH AND I WAS NOT IN TRAFFIC. THE CAUSE OF THE INCIDENT WAS NOT IMMEDIATELY KNOWN. WHEN I BROUGHT THE MOTORCYCLE INTO THE REPAIR SHOP, I OBSERVED AFTER THE ENGINE WAS OPENED THAT THE IDLER SHAFT LEVER , A WELDED PIECE OF STEEL, SNAPPED IN HALF, SENDING BOTH BROKEN PIECES INTO THE LOWER END OF ENGINE, AND DISLODGING THE BALANCER CHAIN FROM THE SPROCKET, WHICH CAUSED NEAR-CATASTROPHIC DAMAGE TO THE ENGINE. AFTER SIGNIFICANT TIME AND FINANCIAL INVESTMENT, 40% OF THE TOTAL VALUE OF THE MOTORCYCLE, IT WAS PUT BACK ON THE ROAD HAVING BEEN REPAIRED WITH ONLY KAWASAKI FACTORY PARTS AND RAN FINE FOR A TIME. ABOUT 2000 MILES LATER, I WAS DOING ROUTINE MAINTENANCE WHEN I NOTICED A PIECE OF METAL ATTACHED TO THE MAGNETIC OIL PLUG. AFTER SOME INVESTIGATION I FOUND THIS TO BE A PIECE OF THE NEWLY INSTALLED IDLER SHAFT LEVER. ONCE AGAIN THE PIECE NEEDED TO BE REPLACED. HAD I NOT INSTALLED A MAGNETIC OIL PLUG ANOTHER MAJOR PROBLEM MOST DEFINITELY WOULD HAVE OCCURRED.*AK
KAWASAKI KLR650'S HAVE A PROBLEM WITH AN ENGINE BALANCER LEVER BREAKING. I HAVE A 2002 KLR AND FOUND MY LEVER TO BE BROKEN IN THREE PLACES. ALTHOUGH IT DID NOT CAUSE A CRASH IN THIS CASE, THE BROKEN PIECES COULD EASILY CAUSE AN ACCIDENT (AND HAVE IN THE PAST). YOU CERTAINLY DO NOT WANT THIS PIECE TO BREAK WHILE YOU ON THE HIGH WAY. IT IS WELL KNOWN THAT NEW KLR OWNERS CHANGE THIS PART OUT WITH AN AFTER MARKET PART TO AVOID INJURY. *JB
Powertrain (other)
Powertrain reports that are not specifically the engine or transmission — driveshafts, axles, transfer cases and differentials.
From owner reports, verbatim
I HAVE A 2002 KAWASAKI KLR 650 WITH 6053 MILES I AM TRYING TO SELL IT BUT NO ONE WANTS IT WITH OUT THE BALANCER UPGRADE AKA DOOHICKEY. I DID MINE TODAY AND FOUND THE SPRING BROKEN. THE TAIL END WAS MISSING. I KNOW ALOT OF PEOPLE HAVE BEEN AFFECTED BY THIS BAD PART INC. THE BALANCER ITSELF. I DON'T KNOW WHAT KIND OF DAMAGE THE BROKEN SPRING DID BUT THE BIKE STILL RUNS, AND WITH THE UPGRADE FROM EAGLE IT SOUND ALOT BETTER. I THINK KAWASAKI OWN ME SOME $$ FOR THE PARTS AND DAMAGE. I DOUBT IF I WILL EVER SEE ANY BUT WOULD LIKE TOO. HEIR COULD OF BEEN A FATAL CRASH WHEN THE MOTOR FINALLY JUMPED TIME OR SEIZED DUE TO METAL IN THE VALVES/ENGINE. FIRE OR EVEN DEATH DUE TO A SERIOUS LOCKUP AND CRASH. *TR
Too few reports in this category for a page of its own — they appear in the full complaint list.
Suspension
Reports naming suspension components — springs, struts, shocks, control arms and related hardware.
From owner reports, verbatim
I HAVE A 2002 KAWASAKI KLR 650 WITH 6053 MILES I AM TRYING TO SELL IT BUT NO ONE WANTS IT WITH OUT THE BALANCER UPGRADE AKA DOOHICKEY. I DID MINE TODAY AND FOUND THE SPRING BROKEN. THE TAIL END WAS MISSING. I KNOW ALOT OF PEOPLE HAVE BEEN AFFECTED BY THIS BAD PART INC. THE BALANCER ITSELF. I DON'T KNOW WHAT KIND OF DAMAGE THE BROKEN SPRING DID BUT THE BIKE STILL RUNS, AND WITH THE UPGRADE FROM EAGLE IT SOUND ALOT BETTER. I THINK KAWASAKI OWN ME SOME $$ FOR THE PARTS AND DAMAGE. I DOUBT IF I WILL EVER SEE ANY BUT WOULD LIKE TOO. HEIR COULD OF BEEN A FATAL CRASH WHEN THE MOTOR FINALLY JUMPED TIME OR SEIZED DUE TO METAL IN THE VALVES/ENGINE. FIRE OR EVEN DEATH DUE TO A SERIOUS LOCKUP AND CRASH. *TR
Too few reports in this category for a page of its own — they appear in the full complaint list.
Tires & wheels
Reports naming tires, wheels, hubs, or the tire-pressure monitoring system.
From owner reports, verbatim
MOTORCYCLE IS UNDER 5000 MILES AND ALREADY HAS CHANGED FRONT AND REAR TIRES. DUNLOP TIRE, MODEL 750, SIZE 130/80-1765S, AND PROBLEM STILLRECURRING, TIRE GOT FLAT.*AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Visibility
Reports naming windshields, glass, wipers, defrosters and mirrors.
From owner reports, verbatim
WHILE DRIVING AND WITH NO WARNING SIDEVIEW MIRRORS WILL RESET THEMSELVES DUE TO HEAVY VIBRATION IN MOTORCYCLE. CONSUMER IS UNABLE TO SEE THROUGH SIDE MIRRORS. DEALER NOTIFIED.*AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .