RoadVitals

2019 Kawasaki KLX250 Problems

Owner-reported complaints filed with NHTSA, grouped by component

Data refreshed

Owner complaintsComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
1
Latest Dec 18, 2024
Components namedHow many of our component categories appear on at least one report for this model year. One report can name several.
1
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
0

What this page shows

Everything below is an owner-reported complaint submitted to NHTSA about the 2019 Kawasaki KLX250, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

Reports by component

Ranked by how many owner reports name each component category

  • Brakes1100.0%

Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.

Each component in detail

What the reports in each category say, in the owners' own words

Brakes

Reports naming service brakes, the antilock braking system, brake hoses, master cylinders or the parking brake.

1
report

From owner reports, verbatim

The contact owns a 2019 Kawasaki KLX250. The contact stated while riding 10-20 MPH and depressing the rear brake piston, the motorcycle failed to respond. There was no warning light illuminated. The contact engaged the front brake and the engine brake, and the motorcycle responded as intended. The motorcycle was taken to the dealer, where it was diagnosed that the rear brake piston had failed due to dirt intrusion in the piston's internal plunger, which damaged the pressure seal and rendered the hydraulic unit inoperable. The contact was informed that it was a common failure and that the failure was a factory defect. The dealer determined that the brake piston needed to be replaced; however, the part was not available. The motorcycle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 640.

NHTSA ID 11631371 · filed Dec 18, 2024

Too few reports in this category for a page of its own — they appear in the full complaint list.

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.

Elsewhere on this vehicle

Data sources

Data on this page last refreshed .