RoadVitals

2009 Kawasaki Ninja Zx-10R Recalls

Safety recall campaigns filed with NHTSA that cover this model year

Recalls apply to specific vehicles, not to every vehicle of a model year. Check your VIN with NHTSA or your manufacturer's dealer to confirm whether a recall affects your vehicle.

Check a VIN on NHTSA.gov
Recall campaignsA safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
2
Newest Feb 17, 2012
Carrying an NHTSA advisoryCampaigns where NHTSA told owners not to drive the vehicle, or to park it outside, until the repair is done.
0
Open investigationsNHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
0

Recall campaigns

2 campaigns cover this model year — what the defect is, what it could cause, and what the remedy is

12V064000

ELECTRICAL SYSTEM:12V/24V/48V BATTERY; ELECTRICAL SYSTEM:ALTERNATOR/GENERATOR/REGULATOR

Feb 17, 2012
20,512 units potentially affected
The defect: KAWASAKI IS RECALLING CERTAIN MODEL YEAR 2008-2011 NINJA ZX-10R, AND 2009-2012 NINJA ZX-6R MOTORCYCLES MANUFACTURED FROM DECEMBER 14, 2007 THROUGH JULY 26, 2011. DUE TO A MANUFACTURING ERROR, THE REGULATOR/RECTIFIER MAY INSUFFICIENTLY CHARGE THE BATTERY.
The risk: IF THE BATTERY DISCHARGES, THE MOTORCYCLE MAY STALL WITHOUT WARNING, INCREASING THE RISK OF A CRASH.
The remedy: KAWASAKI WILL NOTIFY OWNERS, AND DEALERS WILL REPLACE THE VOLTAGE REGULATOR, FREE OF CHARGE. THE SAFETY RECALL BEGAN ON FEBRUARY 24, 2012. OWNERS MAY CONTACT KAWASAKI AT 949-770-0400.
KAWASAKI MOTORS CORP., U.S.A.View on NHTSA.gov
09V063000

ENGINE AND ENGINE COOLING

Feb 20, 2009
950 units potentially affected
The defect: KAWASAKI IS RECALLING 950 MY 2009 NINJA ZX10R (ZX1000E9F/E9FA/E9FAL) MOTORCYCLES. THE TIMING INSPECTION CAPS ON THE STARTER CLUTCH COVER MAY COME LOOSE DUE TO IMPROPER TIGHTENING AND FALL OUT, ALLOWING OIL TO LEAK ONTO THE REAR TIRE.
The risk: THIS COULD CREATE A CRASH RESULTING IN INJURY OR DEATH.
The remedy: DEALERS WILL TIGHTEN THE TIMING INSPECTION CAPS FREE OF CHARGE. THE RECALL BEGAN ON FEBRUARY 23, 2009. OWNERS MAY CONTACT KAWASAKI AT 1-866-802-9381.
KAWASAKI MOTORS CORP., U.S.A.View on NHTSA.gov

What a recall is

Safety recall
A safety recall is issued when a manufacturer or NHTSA determines that a vehicle has a safety-related defect or does not comply with a federal motor vehicle safety standard. Recall repairs are free. Whether a specific vehicle is covered depends on its VIN — a recall listed for a model year does not necessarily apply to every vehicle of that year.
Safety investigation
NHTSA opens an investigation to examine whether a safety defect may exist. An open investigation is not a determination that a defect exists, and many investigations close without a recall. Investigations can, however, lead to one.
Manufacturer communication
Manufacturers file copies of the bulletins they send to dealers with NHTSA. These often describe diagnostic or repair procedures for a known condition. They are not recalls: repairs described in a bulletin are usually only free if the vehicle is still under warranty or the manufacturer has extended coverage.

Elsewhere on this vehicle

Data sources