2002 Kawasaki Vulcan 1500 Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2002 Kawasaki Vulcan 1500, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Suspension457.1%
- Engine114.3%
- Powertrain (other)114.3%
- Tires & wheels114.3%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Suspension
Reports naming suspension components — springs, struts, shocks, control arms and related hardware.
From owner reports, verbatim
THE FRONT END OF THE MOTORCYCLE MADE A LOUD NOISE. UPON INSPECTION OF THE MOTORCYCLE BY THE DEALERSHIP, THEY INDICATED THE FRONT WHEEL WAS WOBBLING AND THE SPACER BAR WAS MOBILE ALSO. THE SPACER BAR WAS TIGHTENED, HOWEVER 2 WEEKS LATER, THE FRONT END SEIZED UP AND THE BIKE FLIPPED OVER. *JB THE FRONT TIRE FAILED AND CAUSED THE BIKE TO FALL. THE CONSUMER HAS MADE REPEATED COMPLAINTS ABOUT THE FONT TIRE SINCE PURCHASE. SCC
CONSUMER CALLED COMPLAINING ABOUT HAVING PROBLEM WITH THE DRIVE SHAFT. PLEASE PROVIDE FURTHER INFORMATION. TS
Too few reports in this category for a page of its own — they appear in the full complaint list.
Engine
Reports naming the engine itself — including stalling, misfires, oil consumption, cooling and internal engine components.
From owner reports, verbatim
WHILE DRIVING ABOUT 55 MPH ON THE HIGHWAY MOTORCYCLE STALLED. DRIVER TRIED TO RESTART THE MOTORCYCLE, BUT IT WOULDN'T TURN OVER HE WALKED THE MOTORCYCLE OVER TO THE SHOULDER. THEN IT WAS TOWED TO THE DEALERSHIP. BUT THE MECHANIC COULD NOT DUPLICATE THE PROBLEM. *AK
Too few reports in this category for a page of its own — they appear in the full complaint list.
Powertrain (other)
Powertrain reports that are not specifically the engine or transmission — driveshafts, axles, transfer cases and differentials.
From owner reports, verbatim
WELDING TO DRIVE SHAFT WAS IMPROPERLY DONE RESULTING IN A REAR END CLICK NOISE. *TT
Too few reports in this category for a page of its own — they appear in the full complaint list.
Tires & wheels
Reports naming tires, wheels, hubs, or the tire-pressure monitoring system.
From owner reports, verbatim
THE FRONT END OF THE MOTORCYCLE MADE A LOUD NOISE. UPON INSPECTION OF THE MOTORCYCLE BY THE DEALERSHIP, THEY INDICATED THE FRONT WHEEL WAS WOBBLING AND THE SPACER BAR WAS MOBILE ALSO. THE SPACER BAR WAS TIGHTENED, HOWEVER 2 WEEKS LATER, THE FRONT END SEIZED UP AND THE BIKE FLIPPED OVER. *JB THE FRONT TIRE FAILED AND CAUSED THE BIKE TO FALL. THE CONSUMER HAS MADE REPEATED COMPLAINTS ABOUT THE FONT TIRE SINCE PURCHASE. SCC
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .