1997 Kawasaki Vulcan Classic Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 1997 Kawasaki Vulcan Classic, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Engine350.0%
- Transmission233.3%
- Other / unspecified116.7%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Engine
Reports naming the engine itself — including stalling, misfires, oil consumption, cooling and internal engine components.
From owner reports, verbatim
I HAVE A 1997 KAWASAKI VULCAN 1500 CLASSIC MOTORCYCLE. ON THIS BIKE AND OTHER MODELS, KAWASAKI INSTALLED A PLASTIC GEAR ON THE OIL PUMP. THIS GEAR FAILS CAUSING A LOSS OF OIL PRESSURE AND IN SOME CASES DESTROYS MAJOR COMPONENTS OF THE ENGINE. THE DEALERSHIP IS TELLING ME THAT IT WILL COST ME OVER $8,000.00 IN PARTS TO REPAIR. KAWASAKI IS ONLY WILLING TO REPLACE THE GEAR, PISTON RINGS, GASKETS AND LABOR NEEDED TO REPLACE THOSE PARTS BUT NOT ANY PART THAT WAS DAMAGED BY THE LOSS OF OIL PRESSURE. THIS HAS BEEN A KNOWN PROBLEM FROM THE RESEARCH I HAVE DONE SINCE AT LEAST 1999. THE COST OF THE PARTS FROM THE DEALER IS JUST SHORT OF THE COST TO REPLACE THE BIKE WITH A BRAND NEW MODEL. THIS BEING A MANUFACTURES DEFECT, SHOULDN'T THEY BE LIABLE FOR DAMAGES CAUSED BY THE FAILED GEAR? I JUST PURCHASED THIS BIKE LAST SUMMER. I ONLY LEARNED OF THE DEFECTIVE GEAR AFTER ITS FAILURE. THE DEALERSHIP CONFIRMED IT WAS THE GEAR THAT FAILED SHEARING OFF THE GEAR TEETH. THE INSPECTED THE OIL PUMP AND FOUND IT TO STILL BE SERVICEABLE AND SAID THAT HAD THE GEAR NOT FAILED THAT I WOULD HAVE NOT LOST OIL PRESSURE. I DO NOT KNOW THE SPEED AT THE TIME. THE LAST TIME I RODE THE BIKE PRIOR TO DISCOVERING I HAD NO OIL PRESSURE, I HAD ONLY BEEN RIDING CLOSE TO HOME WHERE THE SPEED LIMIT IS NO MORE THAN 55MPH. *TR
DT*: THE CONTACT STATED WHILE DRIVING 65 MPH, THE OIL AND WATER WARNING LIGHTS ILLUMINATED, THEN WENT OUT. THE BIKE WAS TOWED TO A SERVICE DEALER WHERE THE PROBLEM WAS IDENTIFIED AS AN OIL PRESSURE FAILURE. THE MANUFACTURER WAS CONTACTED.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Transmission
Reports naming the automatic or manual transmission, including shifting behaviour, shudder, slipping and transmission control modules.
From owner reports, verbatim
TL*THE CONTACT OWNS A 1997 KAWASAKI VULCAN CLASSIC. WHILE DRIVING APPROXIMATELY 10 MPH ON NORMAL ROAD CONDITIONS, THE REAR TIRE LOCKED WITHOUT WARNING. THE TRANSMISSION FAILED IMMEDIATELY AFTERWARD. THE CONTACT HAD TO ROLL THE VEHICLE BACK AND FORTH IN POSITION SEVERAL TIMES TO UNLOCK THE TIRE. THE VEHICLE HAS NOT BEEN REPAIRED, IS INOPERABLE, AND IS PARKED AT THE CONTACT'S RESIDENCE. THE CONTACT WAS CONCERNED OF THE SAFETY RISK INVOLVED. THE FAILURE AND CURRENT MILEAGES WERE 25,100. UPDATED 12/22/08. *LJ UPDATED 12/22/08.*JB
TRANSMISSION FAILS UPON EACH SHIFT TO SECOND GEAR.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Other / unspecified
Reports whose component NHTSA recorded as unknown, or that do not map to one of the categories above.
From owner reports, verbatim
TL*THE CONTACT OWNS A 1997 KAWASAKI VULCAN CLASSIC. WHILE DRIVING APPROXIMATELY 65 MPH, THE CONTACT HEARD A RATTLING NOISE. THE LOCAL MECHANIC DIAGNOSED THE AFTERMARKET PART, A FORWARD CONTROL COMPONENT, AS THE CAUSE OF THE TRANSMISSION FAILURE. THE TRANSMISSION WAS REPLACED. THE PURCHASE DATE AND A VALID VIN WERE UNAVAILABLE. THE CURRENT AND FAILURE MILEAGES WERE 12,000.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .