RoadVitals

2005 Kenworth T800 Owner Complaints

Reports submitted to NHTSA by owners and drivers, shown in full

Data refreshed

Complaints on fileComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
3
Latest Oct 22, 2018
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
1
Filed in the last 12 monthsReports filed with NHTSA in the trailing 365 days. Recent volume reflects attention and vehicle age as much as anything else.
0
Reports on file since Aug 24, 2005

What this page shows

Our database holds 3 NHTSA owner-reported complaints for the 2005 Kenworth T800. Each one is a report filed by an owner or driver and published by NHTSA without most of them being verified. A complaint is not a confirmed defect, not a recall and not a manufacturer bulletin. Narratives are shown exactly as filed.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

Complaints, most recent first

Showing 1–3 of 3

Suspension
Filed Oct 22, 2018

TAKARA RECALL- OPERATING DUMP TRUCK ON A LOCAL ROAD AT APPROXIMATELY 25 MPH. DECELERATING TO A STOP AT A RED LIGHT. AS THE VEHICLE SLOWED DOWN, THE LIGHT CHANGED AND AS I ATTEMPTED TO ACCELERATE THE REAR OF THE TRUCK CAME UP OFF THE GROUND. WHEN I GOT OUT TO INSPECT WHAT HAPPENED, THE ENTIRE REAR AXEL DISCONNECTED FROM THE TRUCK AND WAS ON THE GROUND.

NHTSA ID
11141937
Incident
Oct 19, 2018
Mileage
25 mi
Electrical
Filed Aug 29, 2008
Fire reported

TL*THE CONTACT OWNS A 2005 KENWORTH T800. THE CONTACT STATED THAT THE CLAMPS THAT HOLD THE BATTERY CABLES, WHICH LEAD FROM THE BATTERY TO THE STARTER, WERE NOT ADJUSTED PROPERLY. AS A RESULT, THE CABLES WERE CHAFFING. A FIRE IGNITED AND SPREAD THROUGHOUT THE ENGINE AND CAB OF THE VEHICLE. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE. THE INSURANCE ADJUSTER AND VEHICLE RE-BUILDER DIAGNOSED THE SOURCE OF THE FIRE. A POLICE REPORT WAS FILED. THE MANUFACTURER WAS NOT NOTIFIED AND THE VEHICLE HAS NOT BEEN REPAIRED. THE FAILURE AND CURRENT MILEAGES WERE 250,000.

NHTSA ID
10240190
Incident
Aug 18, 2008
Mileage
250,000 mi
Body & structureHeating & air conditioningEngine+1 more
Filed Aug 24, 2005

2004 AND 2005 T800 KENWORTH TRUCKS DEVELOPED A PROBLEM WHEN BACKING UP THERE IS A TWISTING OF THE ENGINE AND FRAME.***NO ANSWER REQUIRED***. *MR THE TWISTING ALSO CAUSED THE COOLING FAN TO STRIKE THE FAN SHROUD CAUSING DETERIORATION OF THE FAN AND LATER, FAILURE ALONG WITH THE RADIATOR. REPEATED FAILURE OF THE A/C CONDENSERS. THERE WERE SEVERAL FAILURES OF THE DRIVE-SHAFT CAUSING THE BOLTS ON THE REAR YOKE TO SHEAR OFF. THE DRIVE SHAFT FELL OFF OF THE VEHICLE WHILE BEING DRIVEN ON THE HIGHWAY. *SC

NHTSA ID
10134551
Incident
Aug 1, 2005

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.

Data sources

Data on this page last refreshed .