RoadVitals

2021 Kia Niro EV Owner Complaints

Reports submitted to NHTSA by owners and drivers, shown in full

Data refreshed

Complaints on fileComplaints are reports submitted to NHTSA by owners and drivers. NHTSA does not verify most reports before publishing them, and a complaint does not establish that a defect exists. Volume is influenced by how many of a vehicle were sold, how long it has been on the road, and how much attention an issue has received.
2
Latest May 28, 2025
Crash or fire reportedComplaints whose submitter recorded that a crash or a fire occurred. These are the reporter's own answers on the NHTSA form, not verified findings.
0
Filed in the last 12 monthsReports filed with NHTSA in the trailing 365 days. Recent volume reflects attention and vehicle age as much as anything else.
0
Reports on file since Jul 30, 2021

What this page shows

Our database holds 2 NHTSA owner-reported complaints for the 2021 Kia Niro EV. Each one is a report filed by an owner or driver and published by NHTSA without most of them being verified. A complaint is not a confirmed defect, not a recall and not a manufacturer bulletin. Narratives are shown exactly as filed.

Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.

Complaints, most recent first

Showing 1–2 of 2

Brakes
Filed May 28, 2025

The rear brake rotors on the vehicle are pitted, as confirmed by a local repair shop. The "incident" is ongoing. Kia refuses to repair or replace them under warranty (25,500 miles on the car), claiming they are wear item. However, pitting is not wear, in fact quite the opposite. My analysis (30+ yrs in the auto business): As an EV, regenerative braking means the actual brake systems are rarely used. Noise at low speeds prompted the inspection at a local shop. Braking under high speeds does not result in noise, telling me the system relies too heavily on the front brakes. The result is the rear rotors are too often unused leaving them to rust and then pit. Tesla recognizes that regen braking can actually harm brake rotors, suggesting burnishing the brakes at times using the following procedure: 1) Drive the vehicle at approximately 50 mph - 55 mph (80 km/h - 90 km/h) on a straight road. 2) Apply moderate, consistent pressure to the brake pedal to slowly decelerate the vehicle, releasing at 10 mph (15 km/h). 3) Repeat this procedure 6 times, waiting at least 30 seconds between applications. Since the rear brakes do not appear to engage on the Kia Niro, this method is fruitless. Other Niro drivers report this as seen here: [XXX] I my opinion, the vehicles should at minimum be repaired under warranty or recalled to "rebalance" the brake system. Thank you... INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)

NHTSA ID
11663437
Incident
May 20, 2025
Driver assistance
Filed Jul 30, 2021

I'm a new Niro Ev driver. The VESS noise when reversing the vehicle is very loud. It is too loud, I live in close proximity to neighbors and have to get up early for work and the sound is a major nuisance, I would not want a neighbor that has this car . I understand VESS in place for safety but the reverse backup beeping is just a step down from a garbage truck backing up, especially in the silence of a residential neighborhood in the early AM hours. Furthermore, I and others as seen on web forums will reverse faster than we normally would do to be able to take the car out of reverse as quickly as possible to stop the blaring beeping. This creates its own risk, as if there is less time to react if there is a pedestrian behind the vehicle. The volume of the noise should be greatly reduced. It is also unnecessary noise pollution. Kia, please fix this.

NHTSA ID
11427104
Incident
Jul 29, 2021

Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.

Data sources

Data on this page last refreshed .