2014 Kia Optima Hybrid Problems

The contact owns 2014 Kia Optima Hybrid. The contact stated that while driving at undisclosed speeds, the "Check Hybrid System - Turn Off Engine" message displayed on the instrument panel and the vehicle stalled. On two occasions, the vehicle shifted to LIMP Mode. The vehicle was towed to the dealer and the engine was replaced twice. The manufacturer was notified of the failure and a case was filed. The vehicle was not repaired. The failure mileage was 58,997.

The contact owns a 2014 Kia Optima Hybrid. The contact stated while driving approximately 35 MPH, the engine seized without warning. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was not notified of the failure. The approximate failure mileage was 140,000. The contact stated that the dealer and the manufacturer were notified but refused to help with the issue.

While driving during colder weather the car will show HEV (hybrid system) warning and tell you to shut it off. I was in a construction zone with no where to pull over when the car died and lost all propulsion and brakes. This seems to be a common problem on KIA Optima hybrids from 2012-2015.

The contact owns a 2014 Kia Optima Hybrid. The contact stated while driving 40 MPH, the vehicle lost motive power with a battery management system (BMS) message displayed. The contact desperately depressed the brake pedal, but the pedal became firm, causing the contact to almost crash into another vehicle. The contact was able to pull into a parking lot, turned off and restarted the vehicle, but the BMS message and check engine warning was light illuminated. The dealer was contacted but the vehicle needed be diagnosed. The manufacturer was not contacted. The failure mileage was 84,000.

ON 6/07/19 WHILE TRAVELLING TO WORK ON THE HIGHWAY, TRAVELLING ABOUT 65 MPH, THE DASH DISPLAY READ CHECK HYBRID SYSTEM, AND SUDDENLY SHUT DOWN. ENGINE STOPPED RUNNING, STEERING WHEEL BEGAN STIFFENING, I COASTED FROM THE PASSING LANE TO THE RIGHT LANE AND THEN TO THE SHOULDER WITHOUT INCIDENT AND WAS ABLE TO SAFELY PARK THE CAR. KIA FAILED TO PROVIDE ROADSIDE ASSISTANCE SINCE THE CAR HAS OVER 60,000 MILES(ACTUALLY HAS 95,000 MILES), HOWEVER I AM STILL UNDER THE 10YR/100,000 MILES WARRANTY. THE CAR WAS TOWED TO THE KIA DEALERSHIP VIA MY INSURANCE COVERAGE. AFTER THE ASSESSMENT I WAS TOLD I HAD A BLOWN MAIN HYBRID FUSE. CHARGED $201.24 TO REPLACE THE FUSE. I PRESENT THIS AS A SAFETY ISSUE BECAUSE HAD I BEEN ON A MAJOR HIGHWAY WITH MY GRANDCHILDREN IN THE MIDDLE OF TRAFFIC, THERE WOULD BE NO WAY POSSIBLE TO REACH A LANE SHOULDER WITHOUT POSSIBLE HARM OR DEATH. ACCORDING TO KIA'S OWN "TECHNICAL OPERATIONS NOTICE - PS515(REV 2, 02/28/2019" DATED AUGUST 2017), THEY ARE FULLY AWARE OF THIS PROBLEM. THE BATTERY FUSE IS TO BE REPLACED FROM A 125 AMP TO A 150 AMP. THIS FUSE IS PART OF THE SAFETY PLUG LOCATED IN THE TRUNK. AS A OWNER I SHOULD HAVE BEEN WARNED OF THIS POSSIBLY HAPPENING TO THE CAR AND GIVEN THE OPTION TO HAVE THIS FUSE REPLACED....AT KIA'S EXPENSE. FOR THOSE STILL DRIVING THIS YEAR AND MAKE OPTIMA HYBRID,PLEASE BE AWARE OF THIS OCCURRENCE. THE 125 AMP HV BATTERY FUSE SHOULD BE REPLACED WITH THE NEWER 150 AMP HV BATTERY FUSE(PART #375F2 4R150. SEE KIA'S PITSTOP: TECHNICAL OPERATIONS NOTICE #PS515. UNFORTUNATELY MY COMMUNICATION WITH KIA PROVED FRUITLESS.

WHEN STARTING UP THE CAR YOU CAN SMELL A RUBBER BURNING SMELL COMIMG FROM THE AIR VENTS. WHEN DRIVING THE VEHICLE SOMETIMES WHILE DRIVING IT THE CAR ACCELERATES ON ITS OWN.

"TAKATA RECALL" AIRBAG LIGHT ON (CONSTANTLY)

I WAS DRIVING DOWN A CITY STREET (35MPH) WHEN I WAS CUT OFF BY ANOTHER CAR MAKING A TURN IN FRONT OF ME AND WE COLLIDED. I T-BONED HIS CAR AND MY AIR BAGS DIDNT GOT OFF. MY CAR STALLED COMPLETELY AND NOTHING ABOUT THE VEHICLE SAFETY EQUIPMENT REACTED TO THE CRASH. THE SYSTEM (CLUSTER AND SCREEN) DIDNT SHOW THAT THERE HAD BEEN ANY IMPACT AND THE CAR WAS READY TO DRIVE. I REPORTED THIS TO KIA OF DOWNTOWN LA (THE DEALER) AND KIAUSA CORPORATE WHERE THEY OFFERED TO CHECK THE CAR OUT AND SEE IF THE CAR REACTED THE WAY IT WAS SUPPOSE TO. AT THE END OF THEIR INSPECTION THEY CLAIMED THAT MY CAR DID WHAT IT WAS SUPPOSE TO AND DIDNT DEPLOY THE AIRBAGS AS THE CAR DETERMINED THAT IS DIDNT NEED TO. I ASKED WHY DIDNT THE CAR SHOW ANYWHERE THAT THERE WAS IMPACT AND IF THE SENSORS EVEN DETECTED ANYTHING AS THERE WAS NO MESSAGED ANYWHERE. THEY CLAIM IT DOESNT SUPPOSE TO. A FEW WEEKS AFTER IT WAS REPAIRED I STARTED GETTING MESSAGES IN THE CLUSTER "CHECK AIR FLAP SYSTEM". TOOK IT BACK AND FOURTH TO THE DEALER WHERE I FINALLY OPENED A BBB CLAIM. IN MY CLAIM I ALSO REPORTED A DELAY REACTION WHEN ACCELERATING AND WAS TOLD THAT HYBRIDS WORK THAT WAY AND THE RESPONSE TIME IS SLOWER THAN REGULAR GAS CARS. THE PROBLEM IS WHEN TURNING AFTER A COMPLETE STOP THE CAR DOESNT MOVE FOR A FEW SECONDS AND THEN TAKES OFF. OCCASIONALLY, THE CAR WONT TURN OFF, AND ASKS ME TO SHIFT TO P (PARK) WHEN IT IS IN PARK. WHEN THAT HAPPENS I AM FORCED TO TAKE IT TO THE DEALERSHIP WHERE THEY HAVE TO "RESET" THE CAR TO FORCE IT TO TURN OFF (NO ACTUAL SOLUTION BUT TO UNPLUG THE BATTERY AND PLUG IT BACK IN IS WHAT THEY DO) ACCORDING TO KIA I CANT PROVE THAT THE AIRBAGS DONT WORK AS I AM NOT AN EXPERT AND SAME WITH THE DRIVE TRAIN. UNFORTUNATELY THE ONLY WAY OF FINDING OUT IS IF THIS CAR IS INVOLVED IN ANOTHER ACCIDENT. THANK YOU FOR YOUR TIME.

While driving during colder weather the car will show HEV (hybrid system) warning and tell you to shut it off. I was in a construction zone with no where to pull over when the car died and lost all propulsion and brakes. This seems to be a common problem on KIA Optima hybrids from 2012-2015.

WHILE TRYING TO PARK THE CAR IN THE PARKING LOT STRUCTURE, THE CAR ACCELERATED BEYOND CONTROL ON IT'S OWN AND HIT THE WALL HEAD ON. I WAS ALREADY IN MY PARKING SPOT AND ONLY FEW FEET AWAY WHEN THE CAR ACCELERATED. THE PASSENGER AIR BAG WAS DEPLOYED AND BODY DAMAGE OCCURRED. EVERYTHING HAPPENED SO SUDDENLY, I AM NOT SURE ABOUT THE SPEED AT THE TIME OF IMPACT. NOTE: THIS COMPLAINT IS A DUPLICATE OF 10620789. THE FOLLOWING ADDITIONAL INFORMATION IS BEING PROVIDED TO INDICATE A TREND OF SIMILAR SUDDEN ACCELERATION SAFETY ISSUES WITH THE KIA HYBRID OPTIMA. THIS IS A REQUEST TO INITIATE A SAFETY INVESTIGATION AS THERE HAVE BEEN SIMILAR REPORTS WITH KIA OPTIMA HYBRID AND KIA OPTIMA. THE FOLLOWING COMPLAINTS ARE SIMILAR IN NATURE: 10608382 FOR KIA OPTIMA HYBRID 2013, 10615352 FOR KIA OPTIMA HYBRID 2012, 10552403 FOR KIA OPTIMA HYBRID 2012, 10608739 FOR KIA OPTIMA 2014 AND 10588733 FOR KIA OPTIMA 2013. *TR

While driving during colder weather the car will show HEV (hybrid system) warning and tell you to shut it off. I was in a construction zone with no where to pull over when the car died and lost all propulsion and brakes. This seems to be a common problem on KIA Optima hybrids from 2012-2015.

DRIVING NORMALLY, HCU ERROR POPPED UP ON NAV DISPLAY AS WELL AS DRIVERS DISPLAY. TOLD TO PULL OVER IMMEDIATELY AND TURN OFF ENGINE. I WAS TRAVELING ON ONCE HE INTERSTATE, BY THE TIME I GOT INTO THE EMERGENCY LANE THE CAR COMPLETELY LOST ALL POWER. TURNED ON EMERGENCY HAZARD LIGHTS AND AFTER 5 MINUTES THE CAR WAS COMPLETELY DEAD. CALLED A TOW TRUCK AND BROUGHT IT TO ROCK RIVER KIA IN ROCKDOED, IL. LATER WAS TOLD THAT THE ENGINE HAD SEIZED AND THE HYBRID BATTERY WAS NO LONGER HOLDING A CHARGE. ESTIMATED 14,000 REPAIR COST.

I'VE HAD THIS VEHICLE FOR ABOUT 10 MONTHS (PURCHASED OCT. 2017). A FEW WEEKS AFTER I BOUGHT IT I NOTICED MORE AND MORE THAT THE STEERING IS VERY DIFFICULT TO CONTROL AND KEEP IN A STRAIGHT LINE, ESPECIALLY ON THE FREEWAY ABOVE 55 OR 60 MPH. ( WHILE DRIVING ON THE FREEWAY THE CAR STARTS TO DRIFT SLOWLY, I TRY TO RE-ADJUST THE STEERING AND WHILE TURNING THE STEERING WHEEL, NOTHING HAPPENS. I TURN A LITTLE MORE AND IT OVER-REACTS MAKING ME DRIFT WAY INTO THE OTHER DIRECTION. I FEEL VERY UNSAFE ON THE FREEWAY IN THIS CAR, ESPECIALLY AROUND BIGGER VEHICLES) I TOOK IT TO 3 DIFFERENT KIA DEALERS TO TRY AND SOLVE THE PROBLEM, THE FIRST SUGGESTED THAT IT NEEDS A 'STEERING WHEEL UPDATE' SINCE IT HAS ELECTRONIC STEERING. THAT DID NOT SOLVE OR FIX THE PROBLEM. I TOOK IT TO TWO OTHER DEALERS TRYING TO DIAGNOSE AND FIX THIS UNSAFE BEHAVIOR OF THE CAR. THEY SAID THAT THEY ARE UNABLE TO DUPLICATE MY PROBLEM AND SO THEY CANT FIX ANYTHING ON IT. I TOLD THEM THAT THEY NEED TO DRIVE IT FOR AT LEAST 15 MINUTES OR SO, ON THE FREEWAY AND ABOVE 55/60 MPH. THEY SAID THAT THEY STILL CANT DUPLICATE THE PROBLEM. - - AFTER CALLING KIA CONSUMER AFFAIRS MULTIPLE TIMES AND FLING A REPORT, THEY TELL ME TO TAKE IT TO A KIA DEALER. I HAVE TAKEN IT TO MULTIPLE DEALERS BUT STILL NO SOLUTION.

TL* THE CONTACT OWNS A 2014 KIA OPTIMA HYBRID. THE CONTACT STATED THAT THE STEERING WHEEL WOULD JOLT WHILE DRIVING AT ANY SPEED. THE VEHICLE WAS TAKEN TO THE DEALER, BUT THEY WERE NOT ABLE TO DIAGNOSE OR REPAIR THE VEHICLE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 18,000.

ORIGINALLY THE NOISE STARTED ABOUT A WEEK AGO I TOOK IT TO THE DEALER THEY DID VERIFY MY COMPLAINT AND THEY FIXED IT THEN ON 2/14/2015 STARTED TO DO THE SAME THING THE REPAIR INVOICE STATES THEY PERFORMED BRAKE FLUID BLEEDING AND CALIBRATION OF THE BRAKE SYSTEM. *TR

ORIGINALLY THE NOISE STARTED ABOUT A WEEK AGO I TOOK IT TO THE DEALER THEY DID VERIFY MY COMPLAINT AND THEY FIXED IT THEN ON 2/14/2015 STARTED TO DO THE SAME THING THE REPAIR INVOICE STATES THEY PERFORMED BRAKE FLUID BLEEDING AND CALIBRATION OF THE BRAKE SYSTEM. *TR

The contact owns a 2014 Kia Optima Hybrid. The contact stated that while driving at an unknown speed, the hybrid system malfunctioned. The contact stated that during the failure the vehicle decelerated and lost motive power. The contact stated that several unknown warning lights were illuminated. The contact stated that the vehicle was taken to the dealer and remained with the dealer. The vehicle was not repaired. The contact stated that the manufacturer was notified of the failure. The approximate failure mileage was 75,000. Error message comes up on the dashboard.