2018 Kia Optima PHEV Problems
Owner-reported complaints filed with NHTSA, grouped by component
Data refreshed
What this page shows
Everything below is an owner-reported complaint submitted to NHTSA about the 2018 Kia Optima PHEV, grouped by the component NHTSA recorded on the report. These are not confirmed defects, and they are not recalls. NHTSA does not verify most reports before publishing them, and a category with more reports in it is not evidence that a part is defective.
Complaints are reports submitted by owners and drivers to NHTSA. They are not verified and do not establish that a defect exists.
Reports by component
Ranked by how many owner reports name each component category
- Engine440.0%
- Electrical330.0%
- Powertrain (other)110.0%
- Steering110.0%
- Visibility110.0%
Percentages are of component mentions. A single complaint can name more than one component, so these do not sum to the total complaint count.
Each component in detail
What the reports in each category say, in the owners' own words
Engine
Reports naming the engine itself — including stalling, misfires, oil consumption, cooling and internal engine components.
From owner reports, verbatim
See attached document for complaint.
I WAS TOLD BY THE DEALERSHIP THAT MY 2018 KIA OPTIMA PHEV WAS REPAIRED BUT AFTER I DROVE IT OFF THE LOT AND GOT ON THE FREEWAY THE WARNING LIGHT CAME ON AGAIN AND LOST ALL POWER. I ALMOST GOT INTO ANOTHER ACCIDENT BECAUSE OF THIS. THE DEALERSHIP SAID THEY WORKED WITH KIA TECHNICAL SUPPORT TO FIX MY CAR BUT APPARENTLY KIA DOESN'T KNOW WHAT'S WRONG WITH THEIR OWN CAR. THE VEHICLE HAS ONLY 19K MILES. I'M AFRAID FOR MY SAFETY AND MY FAMILIES THAT THIS WILL CONTINUE TO HAPPEN.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Electrical
Reports naming the electrical system — wiring, battery, charging, control modules, infotainment and electrical accessories.
From owner reports, verbatim
The contact owns a 2018 Kia Optima PHEV. The contact's daughter stated that while driving at an undisclosed speed, the high systems temperature switching to hybrid mode message was displayed. The contact stated that there was a two-hour delay for a full charge. The vehicle was taken to the dealer but was not diagnosed or repaired. The dealer informed the contact that the fluids in the vehicle needed to be changed. The vehicle wasn’t repaired; however, the failure recurred. The vehicle was taken back to the dealer, where it was not diagnosed or repaired. The contact was informed by the dealer to remove all the items located in the trunk of the vehicle. The vehicle was not repaired; however, the failure recurred. The vehicle was taken to the dealer, where it was diagnosed that the battery fan assembly had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was not made aware of the failure. The approximate failure mileage was 35,000.
I WAS TOLD BY THE DEALERSHIP THAT MY 2018 KIA OPTIMA PHEV WAS REPAIRED BUT AFTER I DROVE IT OFF THE LOT AND GOT ON THE FREEWAY THE WARNING LIGHT CAME ON AGAIN AND LOST ALL POWER. I ALMOST GOT INTO ANOTHER ACCIDENT BECAUSE OF THIS. THE DEALERSHIP SAID THEY WORKED WITH KIA TECHNICAL SUPPORT TO FIX MY CAR BUT APPARENTLY KIA DOESN'T KNOW WHAT'S WRONG WITH THEIR OWN CAR. THE VEHICLE HAS ONLY 19K MILES. I'M AFRAID FOR MY SAFETY AND MY FAMILIES THAT THIS WILL CONTINUE TO HAPPEN.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Powertrain (other)
Powertrain reports that are not specifically the engine or transmission — driveshafts, axles, transfer cases and differentials.
From owner reports, verbatim
I WAS TOLD BY THE DEALERSHIP THAT MY 2018 KIA OPTIMA PHEV WAS REPAIRED BUT AFTER I DROVE IT OFF THE LOT AND GOT ON THE FREEWAY THE WARNING LIGHT CAME ON AGAIN AND LOST ALL POWER. I ALMOST GOT INTO ANOTHER ACCIDENT BECAUSE OF THIS. THE DEALERSHIP SAID THEY WORKED WITH KIA TECHNICAL SUPPORT TO FIX MY CAR BUT APPARENTLY KIA DOESN'T KNOW WHAT'S WRONG WITH THEIR OWN CAR. THE VEHICLE HAS ONLY 19K MILES. I'M AFRAID FOR MY SAFETY AND MY FAMILIES THAT THIS WILL CONTINUE TO HAPPEN.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Steering
Reports naming the steering system — racks, columns, power-steering assist and steering linkage.
From owner reports, verbatim
The plastic coupling for the steering is broken in my 2018 Kia optima the same Issue that the 2011-2014 issue optima’s have my car has this same issue.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Visibility
Reports naming windshields, glass, wipers, defrosters and mirrors.
From owner reports, verbatim
THE CAR WAS PARK IN THE HOUSE AND WHEN I GET BACK I SAW A LONG CRACK ON THE WINDSHIELD SO I CHECK THE SURROUNDING IF THERE IS SOMETHING FELL ON IT BUT THERE'S NO EVEN AN IMPACT ON IT IT'S JUST CRACK FROM THE TOP OF THE WINDSHIELD UP TO THE MIDDLE CENTER. IT'S A BRAND NEW CAR SO HOW WILL THE WINDSHIELD GET CRACK LIKE THAT. I ASK AROUND TO REPLACE MY WINDSHIELD AND MOST OF THEM TOLD ME THAT IS A COMMON PROBLEM WITH THE NEW VEHICLE LIKE MINE AND THEY EVEN ASK THE DEALER IF IT'S AVAILABLE AND THEY SAID IT WILL TAKE ABOUT A MONTH TO HAVE IT.
Too few reports in this category for a page of its own — they appear in the full complaint list.
Higher-selling and older vehicles accumulate more reports. Counts are not failure rates and are not directly comparable between vehicles that sold in very different numbers.
Elsewhere on this vehicle
Data sources
- NHTSA Office of Defects Investigation — owner-reported complaints and the components recorded on them
Data on this page last refreshed .